Dr Nader Shawky Eng Ahmed Wagih 1- Drive Power Angle Relation ?
2- A power system shown in the following figure, the impedance
of each of the parallel transmission lines is j0.3 and the delivered power is 0.8 per unit when the Delivered Active and Reactive Power of the infinite Bus equal 0.8 pu and 0.074 pu respectively and the voltage of the infinite bus are 1.0 per unit and H=5MJ/MVA , f=50Hz , ∆t = 0.01sec The fault at the middle of transmission line and is cleared by isolation the faulty line , Find the numerical Solution for swing equation at tcc= 0.04sec ??
J0.2
Xd=0.3
3- A power system shown in the following figure, the
impedance of each of the parallel transmission lines is j0.5 and the delivered power is 0.8 per unit when both the terminal voltage of the machine and the voltage of the infinite bus are 1.0 per unit and H=5MJ/MVA , the fault at the middle of transmission line ,when the fault is cleared the original network condition again exist , find the numerical solution for swing equation at tcc=0.3sec ?? Take f=50Hz and ∆t = 0.15sec.
4- A power system shown in the following figure, the
impedance of each of the parallel transmission lines is j0.5 and the delivered power is 0.8 per unit when both the terminal voltage of the machine and the voltage of the infinite bus are 1.0 per unit and H=5MJ/MVA , the fault at the sending end ,when the fault is cleared the original network condition again exist , find the numerical solution for swing equation at tcc=0.3sec ?? Take f=50Hz and ∆t = 0.15sec.