Professional Documents
Culture Documents
LMT Guide:: To Configure The CC Board, You Need LMT Version 2.18 To Install The Software Version
LMT Guide:: To Configure The CC Board, You Need LMT Version 2.18 To Install The Software Version
To configure the cc board, you need LMT Version 2.18 to install the software Version
4.17 + configuration file (XML) that we sent you.
The software you need to download it depends on the site type, table below shows which
software to install:
G ✓ ✓
GU ✓ ✓ ✓
GUL ✓ ✓ ✓ ✓
GL ✓ ✓ ✓
U ✓ ✓
1- when burning the configuration file and software to CC, you need to use a software
called LMT 2.18, after you open the file click on EOMS, at first you need to change your
computer IP to 192.254.1.10 (10,11,12 anything) and then add the station IP in the LMT
as 192.254.1.16.
you can put any name in the user name and station name.
2- Make sure that the CC in the slot 1 not 2 and the ethernet cable in the LMT plug which is
on the right. Then try to ping the station IP using cmd, when ping is ok to the CC board
Click on Image and Burn.
Packages
Configuration file
3- Press ok and wait tell you see that everything was successful.
4- After you finish try to login to the CC as shown below by pressing ok:
5- If the cc have the software and something went wrong with the configuration file and
you need to reinstalled again, no need to reinstall the software again it will take long
time, you can only reinstalled the configuration file by pressing on system << import
XML file.