Professional Documents
Culture Documents
USA-E00081 -007*
USA
List of Past Revisions
Procedure:
1) Power down control.
2) Attached keyboard.
3) Put startup disk in floppy drive.
4) Power on control, when bios shows up on screen press F-10 on key board
5) In bios go to startup menu.
6) Set diskette boot to enable, and save changes on this screen and on main screen.
7) Upon second save, control will boot to A:\ drive.
8) If no Windows 95 disk are available go to step 14
9) Reload Windows from floppy disk by putting first disk in A:\ drive and running
setup.
10) When control reboots hit F-10 and set startup option on diskette boot back to disable
the resave changes.
11) Control should boot to Windows 95.
12) If Mazatrol Fussion software does not start it will need to be reloaded from disk or
from the backup directory. Or the short cut to Fusion M640 put back in Startup menu
and restart.
13) Go To End.
14) Change to C:\ drive and locate the C:\windows\options\cabs directory this is where
the Windows 95 disk and set routines are stored. This directory may have been
moved, if windows would not start, so it take some searching to find.
15) When found start reinstall by typing “setup” then enter from the directory that the
windows setup disk were found. This will reload Windows 95.
16) When control reboots hit F-10 and set startup option on diskette boot back to disable
then resave changes.
17) Control should boot to Windows 95.
18) If Mazatrol Fussion software does not start it will need to be reloaded from disk or
from the backup directory. Or the short cut to Fusion M640 put back in Startup menu
and restart.
19) End