SA.216/SA-216M ASME BPVCILA-2019
TABLE 1
CHEMICAL REQUIREMENTS
Composition %
“Grade WEA “rage WEB,
Element UNS 402502 UNS J03002
Carbon, ma 0254 030° 025°
Prosohons, max 0.08 04 008
Sulfur, max 2.085 2.085 0.085
Silicon, max 60 060 060
Specifies residual elements:
Cope, max 030 030 030
Nickel, max 050 050 050
Chromium, max 050) 050 250
Molybdenin, ax 020 020 020
Yanagi, max 0.02 0.02 0.02
Total ofthese specified residual 1.00 1.00 1.00
“For each reduction of 0.01% below te specified maximum carbon content, an increase of 0.06%
manganese above the specfed maximum wil be permite upto a maximum of 1.10%.
For each reduction ef 0.01% below te specified maximum carbon contert, an increase of 0.08% Na
ave the specified maximum wil te permitted upto a maximum of 1.28%
For each reaution of 0.02% teow the speed maximum carbon conten, an increase of 0.04%
manganese above the spaced maximum wil be permits toa maxim of 1.40%.
"Not applicable when Supplementary Requreren: Si is specifies
TABLE 2
TENSILE REQUIREMENTS
‘Grace WOR Grade WOE [ese wee]
Tensile strength, ksi (MPa) 60 to 65 [415 t0 585) 70 to 95 [485 to 655] 70 to 95 [485 to 655)
lea tena in, 30 12051 3s [280 sors)
isi (Meal
Elongation in 2 in 2% 22 2
(50 mm) min, 96°
Reduiion of area, min, % 35 3s 35
4 Determine by ether 0.2% offset method or 0.5% extension under-load method
“When IO test bars are used in tensile testing as provided for in Specfeation A 703A 703M, the
faage length te reduced section alarater ratio stall be 4 to 1
308