Professional Documents
Culture Documents
The system uses standard Windows features and styles such as tool bars, menus, and
property pages.
The power center uses network protocol to communicate with the unit from a remote or
serial connection for direct connection.
Communication Menu
The communication menu contains commands to get the real time info and configure
new settings on the unite.
Request status: request from the unit the last update information log
Request location: request from the unit the last location log
Text message: sending an sms request to the unit
Read all parameters: reading all the parameters that configure on the unit in the
past
Write all parameters: write the parameters that being change to the unit
Config Update Enable: If you need to configure EX6, you must first click on the
Config. Update Enable button in order to enable configuration over the EX6. The
configuration session will be opened for 10 minutes. Once you completed the
configuration, click on the button again to close the configuration session.
Reset device: refreshing the unit after change server and network settings
Clear internal log: clear all log memory from the unit
Set time: setting the time according the current computer
set location: force location by entering coordinates number
Storage mode: Shut down the unit
DC meter 9600:
Upgrade version: Upgrade/downgrade unit’s firmware only wen the unit is
connected with serial connection
Change unite ID: allows to change the ID number
AT terminal: sending an sms request to the modem
Modbus terminal:
Misc Menu
Service Center
Service center allows the user you connect to the sensors with an RS485 connection
and change parameters in the sensor such as ID, bound rate, zero calibration.
Status
The status tab is seperated into 7 departments receiving online data from the unit and
from different sensors that are connected to the unit.
Main device: Receiving online data of the main unit including ID, time, power, backup,
version, On board iOS, GPS, connection status and more.
Configuration
Configuration tab allows the user to change and configure parameters to be saved in
the unit.
Communication: Configures the server and network, reporting interval and misc.
iOS: Configures the iOS inputs and output.
Output Control: Displays and controls the output status.
Devices: Configuration of device types and unit ids
Unit Connection to PC
Prior to installing the unit in the asset, the unit needs to be connecting to a PC for initial
configurations and settings.
There are 2 methods to connect a unit to a PC: OTA Connection or Serial Connection
OTA Connection
OTA connection appears at the bottom left of the page. Click on “contact via” and then
chose “OTA” and then the correct server as provided by Galooli To proceed, click on the
earth icon:
Serial Connection
“main device” the data from the unit you are connect