Ail A 746-03
TABLE 4 Reduction Factors (R) for Truck Load Calculations
Depth of Cover A)
sve, 2) ae7 ee 71080)
2021) 241030)
Reducion Far
‘e on 2 400 400
16 88 095 400 400
8 085 20 00 +00
2 088 20 O98 400
241020 oat a O95 400
351064 080 05 990 100
TABLE 5 Allowances fer Casting Tolerance
Saat ‘Catng Toorance, (om)
38 005 (13)
sore 008 (1)
182 oor (1a)
ia 0.08 20)
504 00923)
7.23 For bending-stress design, enter the column headed
Bending-Stress Design” in the appropriate table of Tables 7-11,
‘and locate the tabulated trench load P, nearest to the calculated
P, nearest to the caleulated P, from See. 7.2.1. (If the ealeu-
lated P, is halfway between two tabulated values, use the larger
P, value.) Select the corresponding D/t value for this P,. Divide
the pipe’s outside diameter D (Table 2) by the D/T value to
‘obtain net thickness t.
7.2.4 For deflection design, enter the column headed De-
flection Design” in the appropriate table of Tables 7-11, and
locate the tabulated trench load P, nearest to the calculated P,
from Sec. 7.21. (If the calculated P, is less than the minimum
P, listed in the table, design for trench load is not controlled by