a) 4.5 b) 10.4 c) 6.6 d) 8.8 2. Minimum Open Excavation Angle a) 40* b) 30* c) 20* d) 50* 3. Cantilever beam deshutter days – 4. Cantilever slab deshutter days – 5. Beam side Shutter removal days – 6. Cantilever support point load of free end, maximum Bending moment is a) Fixed end b) Free end c) Centre d) Point of inflection 7. All pile tests should be a) Integrity test b) Static load test c) dynamic load test d) none of above 8. Most common slab used a) Flat slab b) Solid slab c) ribbed slab d) all the above 9. Footing less than 5 m on water table, maximum shoring is a) Secant pile b) Contiguous pile c) Soldier pile d) none of above 10. Difference between secant & Contiguous pile a) Secant pile are overlapped b) Contiguous pile are overlapped c) All secant piles are reinforcement d) none of above 11. Steel roof covering by a) Pattern b) Structure c) Rafter d) Column 12.110 m3 above concrete, how much cubes? a) 6 b) 12 c) 3 d) 9 13. Shear reinforcement RCC resist to – Diagonal tension 14. Plasticizer adding concrete used for a) Increase compression strength b) decrease compression strength c) increase workability d) none of above 15. Honeycomb used for – a) vibrator not used b) low w/c ratio c) all the above 16. Density of steel – 7800 kg/m3 17. Density of aluminum – 2700 kg/m3 18. Water quantity was increase concrete quantity a) Increase compression strength b) decrease compression strength 19. Shotcrete concrete are – all the above 20. Where we use construction joint – a) Low shear b) low bending moment c) different members d) all of these 21. Slump test used for a) Compression shear b) workability 22. When u pouring concrete exceed the temperature more then 32*c to reduce what will u do a) Water b) cement c) ice d) none of these