MATERIAL SAFETY .
Date ofissus : July 2018
DATA SHEET Date fein ne 2023,
According to 91/185/EEC, 99/112/EC, 2001/58/EC
FOR EMERGENCY AND GENERAL INFORMATION TOLL FREE HELPLINE : 1800 209 2095
Diversey India Hygiene Pvt.Ltd, 501, Sth Floor, Ack Centr Point,
MIDC Central Road, Ancher (Eas), Mursbai- 400003. INDIA
Tel: +97 22 66444222 Fax: +01 22 65444229
SECTION 1 - PRODUCT IDENTIFICATION,
Product Name : Virex Il 256
Application of the product
SECTION 2 - HAZARDS IDENTIFICATION.
Classification :
Emergency Overview : Danger. Corrosive. Causes Skin and Eye burns. Harmful or fatal if swallowed. Combustible
liquid and vapour.
Principle routes of exposure : Eye contact. Skin contact. Inhalation.
Eyes : Corrosive. Causes permanent damage including blindness.
Skin : Corrosive. Causes permanent damage.
Inhalation : May cause irritation and corrosive effects to nose, throat and respiratory tract.
Ingestion : May be irritating to mouth, throat and stomach.
‘SECTION 3 - COMPOSITION / INFORMATION ON INGREDIENTS,
Chemical characterization
Description : Mixture in water of non-dangerous ingredients and the substances listed below.
Hazardous ingredients :
CAS Ingredients % by LD50 OrarRat —_LDS0 Dermal- _LC50 Inhalation-
Weight (mg/kg) Rabbit Rat
4643-20-5 _Lauryl dimethyl 04-15% Not available Notavailable _Notavailable
amine oxide
6417-5 ethylalcohol 15% 7060 Notavailable _=124.7 mgil (4h)
68424-85-1_N-Alkyl Dimethyl Benzyl 56-10% 426 Notavailable _Notavailable
Ammonium Chloride
7173-51-5 _ Didecy! Dimethyl 510% 4 Notavailable Not available
Ammonium Chloride
SECTION 4 - FIRST AID MEASURES.
Inhalation : If breathing is affected, remove to fresh air. f person is not breathing, call an ambulance and then give
artificial respiration, preferably by mouth to mouth, if possible, Get medical attention immediately.
Skin contact : Take off contaminated clothing. Rinse immediately with plenty of water for 18-20 minutes. Get medical
attention immediately.
Eye contact : Hold eye open and rinse slowly and gently with water for 16-20 minutes. Remove contact lenses, if
present, after the first 5 minutes, then continue rinsing eyes. Get medical attention immediately.
Ingestion : Call a doctor or poison control center immediately for treatment advice. Have person sip a glass of water if
able to swallow. Do not induce voring unless tld todo so by a poison contrl center or doctr. Never give anything by
mouth to an unconsciousness person.
Notes to Physician : Probable mucosal damage may conlraindicate the use of gastric lavage.
vena (cone. on page 2)MATERIAL SAFETY
DATA SHEET
According to 91/185/EEC, 99/112/EC, 2001/58/EC
Product Name : Virex Il 256
Aggravated Medical Conditions : Individuals with chronic respiratory disorders such as asthma, chronic bronchitis,
emphysema, etc., may be more susceptible to irritating effects,
SECTION 5 - FIRE FIGHTING MEASURES.
Suitable extinguishing media : Use dry chemical, CO2, water spray or "alcohol" foam.
Specific hazards : Although this product has a flash point below 200°F, itis an aqueous solution containing an
alcohol and does not sustain combustion.
Unusual hazards : Corrosive material (see Sections 8 and 10)
Specific methods : No special methods required.
Special protective equipment for firefighters : As in any fire, wear self-contained breathng apparatus pressure-
demand, MSHAINIOSH (approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons : No information available.
SECTION 6 - ACCIDENTAL RELEASE MEASURES,
Protection of personnel : Put on appropriate personal protective equipment (see Section 8)
Environmental precautions and Clean-up Method : Clean-up methods - Large spillage. Remove all sources of
ignition. Absorb spill with inert material (eg. dry sand or earth), then place in a chemical waste container. Use a water
rinse for a final clean-up.
SECTION 7 - HANDLING AND STORAGE,
Handling ( see also sections 8 and 15)
‘Avoid contact with eyes, skin and clothing. Do not taste or swallow. Avoid breathing vapors or spray mists. Use only
with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. Wash thoroughly
after handling. Product residue may remain onfin empty containers. All precautions for handling the product must be
Used in handling the emply container and residue. COMBUSTIBLE LIQUID AND VAPOUR. Keep away from open
flames, hot surfaces and sources of ignition. Use only in well-ventilated areas. FOR COMMERCIAL AND
INDUSTRIAL USE ONLY.
Storage : Protect from freezing. Keep tightly closed in a dry coo! and well-ventilated place.. KEEP OUT OF REACH OF
CHILDREN.
SECTION 8 - EXPOSURE CONTROLS AND PERSONAL PROTECTION.
Engineering Controls : Good general ventilation should be sufficient to control airborne levels. Respiratory
protection is not required if food ventilation is maintained,
Personal Protection Equipment:
Breathing equipment :In case of insufficient ventilation wear suitable respiratory equipment. A respiratory protection
program that meets OSHA's 29 CFR 1910. 134 and ANSI 288.2 requirements must be followed whenever workplace
conditions warrant a respiralor’s use.
Protection of hands :Chemical resistant gloves.
Eye protection : Chemical splash goggles.
Skin and body protection : Protective footwear. If major exposure is possible wear suitable protective clothing and
footwear.
Hygiene measures : If major exposure is possible, wear suitable protective clothing and footwear.
cas Ingredients ACGIH OSHA Mexico
C178 ethylalcohol 1000 ppm(STEL) 1000 ppm (TWA) 1900 1000 ppm (TWA) 1900
mgim* (TWA) mgim (TWA)
vena (Cond. on page 3)MATERIAL SAFETY
DATA SHEET
According to 91/185/EEC, 99/112/EC, 2001/58/EC
Product Name : Virex Il 256
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES,
General information
Form: Liquid
‘Appearance ‘Aqueous solution
Colour : Clear Blue
Odour Minty
Specific gravity : 1.0
Bulk Density No information available
Evaporation rate : No information available
Vapor density : No information available
Change in condition :
Melting point! Melting range Not determined
Not determined
Not determined
No information available
Completely Soluble
No information available
Solubility in other solvents :
Partition coefficient : No information available
(n-octanol/water)
Elemental phosphorus : 0.00% by wt
Density : 8.34 Ibs/gal 1 Kgl.
Flash point > 187°F > 86.1°C.
Viscosity No information available
voc: 3.1%"
pH-value : 102
Dilution pH: 8.8@1:256
Explosion li
upper Not determined
lower Not determined
* Tile 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products,
Sections $4508
‘SECTION 10 - STABILITY AND REACTIVITY.
Stability : The product is stable
Polymerization: Hazardous polymerization does not occur.
Hazardous decomposition products : None reasonably foreseeable.
Materials to avoid : Oxidizing agents.
Conditions to avoid: Keep away from heat. Keep away from open flames, hot surfaces and sources of ignition.
SECTION 11 - TOXICOLOGICAL INFORMATION.
Acute toxicity : Corrosive. Oral L050 estimated to be between 1000-2000 mg/kg. Dermal LDS0 estimated to be
>2000 mg/kg
‘Component information : See Section 3
Chronic toxicity : None known,
Specific Effects
vena (Cont on pane)MATERIAL SAFETY Page aot
DATA SHEET
According to 91/185/EEC, 99/112/EC, 2001/58/EC
Product Name : Virex Il 256
Carcinogenic effects : None known
Mutageic effects : None known
Reproductive toxicity : None known
Target organ effects : None known
SECTION 12 - ECOLOGICAL INFORMATION,
Environmental information : No data available.
SECTION 13 - DISPOSAL CONSIDERATIONS.
Do not contaminate water, food or feed by storage or disposal.
Store in original container in areas inaccessible to children. Open dumping is prohibited. Do not reuse empty
Container Disposal : See product label for complete disposal instructions. Always dispose of according to all federal,
state and local applicable regulations.
SECTION 14 - TRANSPORT INFORMATION,
Land transport ADRIRID (cross-border)
ADRIRID Class : 8 Corrosive substances
Kemler Number 80
UN-Number : 1903,
Packaging Group : u
Label : 8
Proper Shipping Name : DISINFECTANT, LIQUID, CORROSIVE, N.O.S, (DIDECYL DIMETHYL
AMMONIUM CHLORIDE, ALKYL DIMETHYL BENZYL AMMONIUM
CHLORIDE)
Maritime transport IMDG :
IMDG Class : 8
UN-Number : 1903,
Label : 8
Packaging Group : W
Proper Shipping Name = DISINFECTANT, LIQUID, CORROSIVE, N.O.S, (DIDECYL DIMETHYL.
AMMONIUM CHLORIDE, ALKYL DIMETHYL BENZYL AMMONIUM
CHLORIDE)
Air transport ICAO-TI and IATA-DGR :
ICAO /IATA Class: a
vena (cone. on page 5)MATERIAL SAFETY Page Sots
DATA SHEET
According to 91/185/EEC, 99/112/EC, 2001/58/EC
Product Name : Virex Il 256
UN-Number : 1903
Label : a
Packaging Group : uM
Proper Shipping Name : DISINFECTANT, LIQUID, CORROSIVE, N.O.S, (DIDECYL DIMETHYL
AMMONIUM CHLORIDE, ALKYL DIMETHYL BENZYL AMMONIUM
CHLORIDE)
‘Transport / Additional Information : Transport regulations include special provisions for certain classes of
dangerous goods packed in limited quantities.
SECTION 15 - REGULATORY INFORMATION.
International Inventories at CAS# Level : All components of this product are listed on the following inventories
USA. (TSCA)
US Regulations :
EPA Reg, No. : 70627-24
California Proposition 65 : This product is not subject to the reporting requirements under California's Proposi
CERCLASARA,
SARA 311/312 Hazard Categories :
Immediate
Delayed
Fire
Reactivity
‘Sudden Release of Pressure
x
x
SECTION 16 - OTHER INFORMATION,
‘The information in this document is based on our best present knowledge. However, it does not constitute a guarantee
for any specific product features and does not establish a legally binding contract.
Department issuing material safety data sheet:
Contact :
Diversey India Hygiene Pvt. Ltd.
501, 5th Floor, Ackruti Centre Point, MIDC Central Road,
Andheri (East), Mumbai - 400093. INDIA
Tel: +91 2266444222. Fax:+91 2266444223
* In case of local regulation change or formulation change this MSDS may undergo revision before the stated revision date.