Professional Documents
Culture Documents
2 Connect sensors or
not been admitted before, to ensure that the settings are reset
transducers. Push 3 Select Confirm. The note appears in the display status line, FHR3 On
SpO2 NBP Any fetal sensor to user defaults for a new patient. NBP Pulse
connectors firmly into and on the trace if the fetal recorder is on.
(model dependent) in any socket 1 Open Patient Demographics window.
sockets. ...and the bright, blue Finder LED lights up on the
2 Touch the Discharge Patient pop-up key. corresponding transducer monitoring that channel.
3 Apply transducers to the patient. 3 Select Confirm.
4 Measurements appear on the display. Loading Paper
1 If the recorder is on, stop it. Finder
LED on
2 Open the paper drawer.
3 With the bottom side of the paper pack down (“STOP”
appears on the final page), unfold the top page of the pack,
and position the uterine activity scale on the right.
4 Put the pack into the tray.
5 Push the paper drawer back until it “clicks” closed.
1 Touch the measurement numeric to open the Setup Menu. Start auto series 1 mV
Check the trace and reposition one of the transducers if Start/Stop 25 mm/sec
Resetting the Toco Baseline Yellow Alarms: message in yellow alarms field, medium
1 Select Auto/Man (toggle as necessary).
1 mV
Touch the Toco Baseline SmartKey to reset the priority audible alarm signal. 2 Select Repeat Time to set the interval between automatic 25 mm/sec
LL
For MHR For MECG (FM30/FM50 only) Obtaining Further Information
Full operating and safety information is contained in your monitor’s
Instructions for Use (IfU). Familiarize yourself with the IfU content before
putting the monitor into use and beginning to monitor patients. This Quick
Guide is in addition to, and does not replace, the IfU.