Liquid Hardener and Densifier for Concrete Floor Flat Floor Specialist
DESCRIPTION chemically. Contact INTRA’s representative for
INTRAFLOOR LH is a single component, ready-to-use more information solution to harden concrete floor. When sprayed evenly Fill and repair all holes, cracks and deteriorated over the concrete floor, it penetrates the surface and areas with cementitious patching mortar such as reacts with the free calcium hydroxide to produce tri- INTRACRETE PM. calcium silica structures, which fills up the pores on the For best result, the surface should be completely dry surface. to allow INTRAFLOOR LH penetrate the pores and react as deep as possible. It could be obtained by INTRAFLOOR drying floor with big fan LH is suitable INTRAFLOOR LH should not be diluted. It can be for applied on clean surface by using a low-pressure refurbishment sprayer or by spreading evenly with a soft-bristled old concrete broom. floors and also Keep the surface wet with INTRAFLOOR LH for a for new minimum of 30 minutes. (A range of 30-60 minutes concrete floor. may be required depending on temperature and The areas of condition). Porous and/or dry areas must be kept application are warehouses, retail/grocery stores, sport wet at all times with INTRAFLOOR LH. Scrub the facilities, terminals, car parks, convention centre, etc. surface with a broom or mechanical scrubber to increase the penetration of the INTRAFLOOR LH. COMPOSITION Once the surface begins to gel and becomes INTRAFLOOR LH is a premium nano-lithium silicate slippery, immediately spray the surface with a light solution water mist. Thoroughly flush the surface with water, with a ADVANTAGES broom to remove excess INTRAFLOOR LH. Fast and easy to apply, dries in 10 minutes and Thoroughly squeeze the surface dry. If there are passable in 30 minutes slippery patches, this is an indication that Smaller particle size, penetrates deep into the INTRAFLOOR LH is still present. These areas surface – harden and dense surface should be re-flushed and squeezed again until the High and permanent light reflectance entire surface is dry. (Extremely porous surfaces It provides a tough protected surface that does not may require a second application.) discolour or show pedestrian or vehicular wear Immediately wash off over-spray from glass, marks. aluminum, or highly polished surfaces with water to Improves abrasion resistance, chemical resistance avoid etching of surfaces. Failure to thoroughly and slip resistance wash and remove all excess material from floor VOC content is very low, it is VOC compliant, thus surfaces may result in white stains. helps earning LEED points in green building Restrict usage of the treated surface for 12 hours. earning Average consumption is 8 – 12 m2/litre, depends on Low maintenance and long lasting porosity of concrete
TECHNICAL DATA PACKAGING
INTRAFLOOR LH is packed 200 litre drum and 20 litre Form Clear Liquid plastic container. Solids Content 14% Active Ingredients 100% of total solids STORAGE Specific Gravity 1.11 + 0.02 When stored in an airtight & sealed container, pH 11.0 INTRAFLOOR LH has a shelf life of 12 months from VOC Content <50 gr/L date of production.
APPLICATION HEALTH AND SAFETY
Clean the surface before application. If there is Avoid contact with eyes, skin and clothing. In case of coating on the surface, for e.g. curing compound skin contact, wash immediately. In case of eye contact, etc., it should be removed either mechanically or Flush immediately with water for at least 15 minutes and obtain prompt medical attention
PT INTRA MAJU INDONESIA Phn : 62-21-7329999
Metro Permata 2 Blok D3/15 Tangerang INDONESIA Fax : 62-21-7328999