Professional Documents
Culture Documents
Op nbr 46302
Tool:
9993741 Socket
9998547 Lifting tool
11668007 Jack 15 metric tons
11668010 Wheel forklift
Sling 6 m, 2 pcs.
1. Lock the frame joint. 2. Use 9993741 to remove the prop shaft from
the final drive.
Figure 2
Figure 1
3. Place 2 jacks 11668007 under the rear frame and lift up the rear wheels.
Figure 3
4. Release the brake system pressure by depressing the brake pedal repeatedly (30–40 times).
Fully depress the brake pedal and block it in that position with a suitable tool. When the brake pedal is blocked
in the depressed position, the oil in the hydraulic tank is prevented from running out to respective brake piston.
Detach the lubrication oil pipes from the axle brackets and the brake hose from the axle's brake pipe. Fit
protective plugs. Disconnect the wiring harness from the axle's temperature sensor and the hose from the
breather filter.
Note
The brake pedal must be locked in position until the rear axle has been refitted.
5. Remove the rear part of the rear fenders.
Figure 4
7. Secure the front rear axle cradle by fastening a tensioning strap or similar around the front rear axle cradle and
the axle housing.
Figure 5
1. 9998547
2. Sling, 6 m
9. Lower and pull out the axle. Secure the axle with a jack under the axle so that it doesn't fall over.
Note
Make sure that the front axle bracket doesn't slide off the axle.