Professional Documents
Culture Documents
Utilizes RET-PMOD-A20-3A07
All Internal RET actuators are connected in “Cascaded SRET” configuration
Conforms to RoHS 2011/65/EU
General Specifications
Antenna Type Sector
Band Multiband
Grounding Type RF connector inner conductor and body grounded to reflector and mounting
bracket
RET Interface 2x 8 pin connector as per IEC 60130-9 Daisy chain in: Male / Daisy chain out:
Female Pin3: RS485A(AISG_B), Pin5: RS485B(AISG_A), Pin6: DC 10~30V, Pin7:
DC_ Return
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: May 31, 2021
6P-2L4M-D3
Dimensions
Width 397 mm | 15.63 in
Array Layout
Port Configuration
Electrical Specifications
Impedance 50 ohm
Polarization ±45°
Page 2 of 4
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: May 31, 2021
6P-2L4M-D3
Total Input Power, maximum 900 W
Electrical Specifications
Frequency Band, MHz 694–790 790–890 890–960 1695–1920 1920–2200 2300–2500 2500–2690
Gain, dBi 16.7 17.1 17.8 17.6 18.3 18.6 18.8
Beamwidth, Horizontal, 66 62 59 66 64 63 62
degrees
Beamwidth, Vertical, degrees 8.7 7.7 7 5.5 4.9 4.2 4
Beam Tilt, degrees 2–12 2–12 2–12 2–12 2–12 2–12 2–12
USLS (First Lobe), dB 16 18 16 18 19 18 17
Front-to-Back Ratio, 30 31 30 28 30 30 28
Copolarization 180° ± 30°, dB
Isolation, Cross Polarization, 28 28 28 28 28 28 28
dB
Isolation, Inter-band, dB 28 28 28 28 28 28 28
VSWR | Return loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
PIM, 3rd Order, 2 x 20 W, dBc -153 -153 -153 -153 -153 -153 -153
Input Power per Port, 250 250 250 200 200 200 170
maximum, watts
Mechanical Specifications
Wind Loading at Velocity, frontal 150.4 lbf @ 150 km/h | 669.0 N @ 150 km/h
Wind Loading at Velocity, lateral 366.0 N @ 150 km/h | 82.3 lbf @ 150 km/h
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: May 31, 2021
6P-2L4M-D3
Wind Loading at Velocity, rear 1080.0 N @ 150 km/h | 242.6 lbf @ 150 km/h
Regulatory Compliance/Certifications
Agency Classification
CHINA-ROHS Below maximum concentration value
ISO 9001:2015 Designed, manufactured and/or distributed under this quality management system
REACH-SVHC Compliant as per SVHC revision on www.commscope.com/ProductCompliance
ROHS Compliant
Included Products
BSAMNT-B95-03 – Wide Profile Antenna Downtilt Mounting Kit for 2.4 - 4.5 in (60 - 115 mm) OD round members.
Kit contains one scissor top bracket set and one bottom bracket set.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
Page 4 of 4
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: May 31, 2021