1 Attempt following all questions
i. Investment casting is used for.......
A) Shapes which are made by difficulty
using complex patterns in sand casting
B) Mass production
D) Stainless steel
ii. | Large and heavy castings are made
A) Green sand moulding
B) Pit mouldingD) Pressure moulding
iii. The volume of metal that enters the
rolling stand
A) should increase after rolling process
B) should decrease after rolling process
a
D) unpredictable
iv. Which characteristic of material is
used in forging process?
A) characteristics of elasticity of material
B) characteristics of ductility of materialC) characteristics of plasticity of material
D) none of the above
v. Injection moulding is the ideal
method of processing.......
A) Plastics
B) Thermo-setting plastics _
C) Thermoplastics
D) Non-ferrous materials
vi. | The size of the lathe is specified by
A) Length of the bed
B) Distance between centres
C) ) Height of centres 1D) ALCOFtheabove |
vii. |The return stroke of shaper machine
is called
A) static stroke
B) cutting stroke
C) dynamic stroke
0) eto
viii. | Knee of milling machine is attached
and slides up and down on
A) Base
B)Column
C) KneeD) Table
ix. | The workpiece motion and tool
motion respectively in a horizontal boring
machine are.......
A) Stationary and rotational
B) Rotational and translational
C) Translational and rotational
conn
x. Which of the following machine is
superior to other machines as regards
accuracy and better surface finish?
A) lathe
B) DrillC) Shaper
ova
11)Runner is a
the path through which hot molten
material comes out of the mold
“sini
connecting passage between mold and
riser
none of these
12)The sand used here is known as green
sand because
A)it is green in colorB)it contains zircon
Clit contains moisture
D)none of these
13)What is the process, in which the metal
is caused to flow through a restricted
orifice to create an extremely elongated
strip of uniform and comparatively smaller
cross-sectional area, called?
A) Rolling
C) Drawing
D) Spinning
14)Hot working process is the plastic
deformation of metal which is carried outA) at temperature below the
recrystallisation temperature
he
C) at temperature equals to boiling point of
water
D) none of the above
15) Chances of crack propagation are more
in
A) cold working process
C) both a. and b
D) none of the above16)Thermosetting materials are
A) the plastics which can be softened even
after they have set and hardened
and
p
C) both a. and b.
D) none of the above
17)The welding process by Metal Inert-Gas
(MIG) welding is
A) slower than the welding process by
Tungsten Inert-Gas (TIG) welding
B) fa by
=C) at same speed as the welding process
by Tungsten Inert-Gas (TIG) welding
D) at unpredictable speed
18)Producing circular hole in a solid metal
by means of revolving tool is known as
B) Reaming
C) Boring
D) Counter boring
19)In which of the following machines does
the work-piece reciprocate while the
cutting tool remains stationary during
cutting?
(A) Milling machine
(B) Lathe* (C)Shaper
(D) Planer
20)Spindle of a lathe is housed in
(A) Apron
(B) Carriage
"(C)Headstock
(D) Tailstock
Six Short Questions on each unit (2
Marks each)
|. What are the uses of runner and riser
ii, | What are the two major drawbacks of
hot working?