You are on page 1of 2

Q1) Design an electronic circuit based on OPAMPs that converts the analog current input

signal range [2, 5] mA to analog output signal range [0, 10] volt. Then calculate the closed
loop amplifier bandwidth if unity gain bandwidth is equal to 2 MHz, Note: power supply is
±15 volt.
Q2) It is required to remove the value of DC signal from the input signal
Vin (t )  2.5  Cos(2 104 t ) , as shown in Fig. (1). Draw the waveform in each part then assign
the frequency and amplitude. Where the Vcc at pin 4 is equal +15 volt and the –Vcc at pin
11 is equal -15 volt.
Q3) Design an electronic circuit, which consists of multiple stages to achieve the given
waveforms, as shown in Fig. (1). Using capacitor 0.01 μF and Vcc=±15 volt.

Q4) It is required to design an electronic circuit based on OPAMP LM741 for the tank
water level indicator, as shown in Fig. (1). A monitoring device has to indicate different
water levels, as shown in Table (1). The level sensor sensitivity is equal to 0.1 mA/cm and
the maximum water level in the tank is equal to 100 cm. The input signal to the monitoring
device has to be between (0 and 10) volts.
Table (1)
Water Level
LED Indicator
Monitoring Device
(cm)
Level Over 90 cm Full
Sensor
90 – 80 cm High Level
Tank Water Full H M L Empty 80 – 40 cm Middle Level
Sensor Signal 40 – 10 cm Low Level
Below 10 cm Empty
Figure (1)

You might also like