Professional Documents
Culture Documents
ND0 Gear Box Renault Technical Note 4559A
ND0 Gear Box Renault Technical Note 4559A
EDITION ANGLAISE
SEPTEMBER 2005
77 11 340 802 4559AService 00429
Type
MEGANE II XM0 M
XM0 W
XM1 N
XMR G
SCENIC II JM0 G
JM0 U
JM0 W
JM1 N
JMR G
●
Engine: XXX Basic manual:
●
Gearbox: ND0 Workshop Repair Manual: 364 - 3 - 8
370 - 3 - 8
Technical Note: 4429A
"The repair procedures given by the manufacturer in this document are based on the All rights reserved by RENAULT S.A.S.
technical specifications current when it was prepared.
Copying or translating, in part or in full, of this document or use of the service part
The procedures may be modified as a result of changes introduced by the reference numbering system is forbidden without the prior written authority of
manufacturer in the production of the various component units and accessories from RENAULT S.A.S.
which his vehicles are constructed".
●
With or without PGCS
– Supplier code: 050
– Customer complaint code 7K
21A-2
MANUAL GEARBOX
Replacing the control module 21A
REPLACING THE CONTROL MODULE Parts required
– Remove Quantity and description of parts Part no.
– the air intake unit,
– the battery plus its mounting, 1 Control module 82 00 523 232
– the computer,
4 Control module mounting bolts 77 03 002 547
– the air filter,
– the MTX external control cables, 1 Gearshift stop bolt 32 18 18H 500
– the 4 control module mounting bolts,
– the gearshift stop bolt through the wheel arch. Time required
– Remove the control module by lifting it vertically.
– Position the new integrated control module earth. MEGANE II
Code Description Time
IMPORTANT
To prevent damaging the neutral switch: 3313 Replacing the control 1.2
– Tilt the control module towards the bulkhead, then module
align the unit to engage the neutral switch. 3198 Adjusting the gearshift 0.6
It will be easy to position the control module shaft in control
its housing.
0129 Basic road test 0.5
– Tighten to torque the 4 new control module mounting TOTAL 2.3
bolts (7.3 Nm).
– Tighten to torque the new gearshift stop bolt, through SCENIC II
the wheel arch (28 Nm).
– Refit the external control cables. Code Description Time
– Adjust the gearshift mechanism (see Technical 3313 Replacing the control 1.7
Note 4429A). module
3198 Adjusting the gearshift 0.6
IMPORTANT
control
The gearshift mechanism is adjusted in 3 rd gear for
MEGANE II vehicles and in 4 th gear for SCENIC II 0129 Basic road test 0.5
vehicles.
TOTAL 2.8
21A-3
MANUAL GEARBOX
Replacing the gearshift control (SCENIC II) 21A
SCENIC II ONLY
Parts required
Time required
Code Description Time
3197 Replacing the gearshift 2.1
control
3198 Adjusting the gearshift 0.6
control
0129 Basic road test 0.5
TOTAL 3.2
21A-4