DEMONSTRATION CHECKLISTS

Trainee’s Name:
Trainer’s Name: BRYAN JAKE BRIONES CASTRO
Units of Competency PERFORM ROUGHING-IN ACTIVITIES, WIRING
covered:
AND CABLING WORKS FOR SINGLE-PHASE
DISTRIBUTION, POWER, LIGHTING AND
AUXILIARY SYSTEMS
Date of Assessment:
Time of Assessment
Instructions for Demonstration
Given the necessary materials, tools and equipment, the trainee
must be able to perform all the following assessment criteria.

Please see attached instruction for Demonstration (Candidate)

Supplies and Materials Tools and Equipment

 PPE  Metallic conduits
 Metallic conduit (EMT, RSC, IMC)  Heat gun
 Non-metallic conduit (PVC conduit)  Rags
 Tools and Equipment  PVC pipe cutter
 Conduit connectors  Pipe cutter
 Conduit fittings  Portable drill
 Conduit support  Measuring tools
 Wire ways  Spirit level
 Cable tray  Screwdrivers
 Auxiliary terminal cabinet  File tool
 Distribution panel  Marking tools
 Cable and wires  Hickey bender
 Tightening tools
 Pulling materials
 Pulling lubricants
 Set of pliers

 To show if evidence
is demonstrated

Electrical Installation and Document No. – CVS - 01

Date Developed:
Maintenance NC II Issued by:
Page 1 of
Developed by:
Demonstration Checklist Concepcion 2
Vocational School
PLAN TRAINING SESSION Revision # 00
During the Demonstration of skills, the Yes No N/A
candidate:
 Installed electrical metallic /non- metallic (PVC   
conduit)
 Installed wire ways and cable tray   

 Installed auxiliary terminal cabinet and   

distribution panel
 Prepared for cable pulling and installation   

 Performed wiring and cabling lay out   

 Notified completion of work   

The trainee’s demonstration was:

 Satisfactory  Not Satisfactory

Trainee’s Signature Date:

Trainer’s Signature Date:

Electrical Installation and Document No. – CVS - 01

Date Developed:
Maintenance NC II Issued by:
Page 2 of
Developed by:
Demonstration Checklist Concepcion 2
Vocational School
PLAN TRAINING SESSION Revision # 00