Professional Documents
Culture Documents
Route of Exposure
Eye Contact: Check for and remove any contact lenses. Do not rub eyes. Immediately flush
with warm running water, holding the eyelids apart, for 15 minutes. Call a
physician if irritation develops.
Skin Contact: Remove contaminated clothing. Wash affected skin with soap and water.
See physician if irritation develops.
Page 1 of 6
SAFETY DATA SHEET
Inhalation: Immediately remove the affected victim to fresh air. If symptoms persist,
obtain medical attention.
Ingestion: No toxic effect is expected Rinse mouths with water and drink 1 glass of
water. Do not induce vomiting. Consult a physician.
Important Symptoms &
Effects (acute &
delayed): May cause eye irritation.
Medical Attention/Special
Treatment Required if: Treat symptomatically.
Extinguishing Media
Suitable Media: Product is not combustible.
Unsuitable Media: Not applicable.
Specific Hazards: Not applicable.
Protective Equipment: Not applicable.
Precautions/Advice: N/Av
Personal Precautions, For non- emergency personnel: Small spills: Use appropriate tools to wipe up
Protective Equipment, the product. Rinse contaminated area with water. Large spill: Stop the leak if
and Emergency possible. Ventilate the area involved. Block release of the chemical from
Procedures: sewer or storm drains. Contain and clean-up the spill. Observe all personal
protection equipment recommendations. Local authority should be advised
if significant spill cannot be contained.
For emergency responders: Use personnel protection recommended in
Section 8.
Methods and Materials of
Containment and Do not release large quantities into the surface water or into drains.
Cleanup: Wear suitable protective clothing, gloves and eye/face protection.
Environmental
Precautions: Prevent further leakage or spillage if safe to do so. Avoid discharge into
drains, water courses or onto the ground.
Reference to Other
Sections: See Also Section 7,8, 13.
Additional Information: For waste Disposal: Follow local regulations for discharge of waste effluent.
Precautions for Handling: Avoid breathing vapor. Avoid ingestion. Use only in well-ventilated areas.
Avoid inhalation of high concentrations of vapors. Keep away from oxidizing,
reducing agents. Keep away from fire, sparks and heated surfaces - no
smoking.
Page 2 of 6
SAFETY DATA SHEET
Control Parameters
National Limit Values: Not Available
Monitoring Procedures: Not Available
Air Contaminants
(Occupational and Occupational Exposure Limits: US Workplace Environmental Exposure Level
Biological): (WEEL) Guides
Ingredient(s) CAS No. ACGIH
Terpenes hydrocarbons 5989-27-5 30 ppm -TWA
Sodium Citrate 1344-09-8 Not included to the list
Alkylbenzene Sulphonate 85536-14-7 Not included to the list
Biological limit values are not available for this product.
Engineering Controls: Guarantee sufficient ventilation during and after use, to prevent vapor
accumulation.
Personal Protective
Equipment
Protective Handwear: Gloves recommended preventing drying of hands.
Protective Eyewear: Safety glasses with side shields or goggles.
Other protective clothing: Not required.
Respiratory Apparatus: Adequate fresh air ventilation recommended.
Local/Mechanical Exhaust: Not normally required if good ventilation is maintained.
Environmental Exposure
Controls: Adequate ventilation must be used. Guarantee sufficient ventilation during
and after use, to prevent vapor accumulation.
Page 3 of 6
SAFETY DATA SHEET
Page 4 of 6
SAFETY DATA SHEET
Waste Treatment: Consult your local regional authority for disposal options.
Additional Information: Avoid release to the environment.
OSHA This material is not classified as hazardous under OSHA regulations (29 CFR
1910.1200).
USA TSCA All chemicals listed.
US CERCLA Reportable
Quantity: Not applicable.
SARA TITLE III
Sec. 302. 40 CFR 355. No extremely hazardous substances are present in this material.
Sec. 313. 40 CFR 372. This substance contains no materials subject to the reporting
requirements of SARA (III) Section 313.
Sec. 311 and 312. 40 CFR 370. MSDS Requirements.
Hazardous Classes: no acute health hazards, no chronic health hazards, no
fire hazards, no sudden release of pressure hazards, and no reactive hazards.
Under SARA Section 311 and 312, the EPA has established threshold
quantities for the reporting of hazardous chemicals. The current thresholds
are 500 pounds for the threshold planning quantity (TPQ), whichever is low,
for extremely hazardous substances and 10,000 pounds for all the other
hazardous chemicals.
US State Right to Know
Law: Proposition 65 California Safe Drinking Water and Toxic Enforcement Act
of 1986: This product is not known to contain any chemicals currently listed
as carcinogens or reproductive toxins under California Proposition 65 at
levels under which would be subject to the proposition.
Other States: Ingredient(s) CAS CA MA MN NJ PA RI
d-Limonene 5989-7-5 No No No No No No
Sodium Citrate 1344-09-8 No No No No No No
Alkylbenzene Sulphonate 85536-14-7 No No No No No No
International Information
Canadian Environmental
Protection Act (CEPA): All ingredients listed appear on the Domestic Substance List (DSL).
Page 5 of 6
SAFETY DATA SHEET
Further Information: Information for this Material Safety Data Sheet was prepared from sources
considered reliable. While every effort has been made to ensure full disclosure
of product hazards, data is not available in some cases and is so stated where
applicable. The manufacturer assumes no liability or responsibility, and no
warranty is expressed or implied, in cases where products are mishandled,
misused or instructions are not strictly observed. Each recipient of this SDS is
encouraged to study it carefully to fully understand this product.
<< N/E = Not established N/AP = Not Applicable N/AV = Not Available C.O.C = Cleveland Open Cup >>
Page 6 of 6