Professional Documents
Culture Documents
Welcome to the DRAGONLOCK: Ultimate™ terrain system. This instruction manual will outline some
basic materials you will need for 3D printing these models, specific printing information for the models in
this set, and links to additional resources.
For more information on getting started with 3D printing, help with choosing a printer, settings for many
popular printers, troubleshooting, and more; please visit our 3D Printer forums:
http://fatdragongames.proboards.com/board/21/3d-printing-dragonlock-terrain
For painting tutorials on these and other models in the DRAGONLOCK: Ultimate™ product line, please
visit our Youtube channel:
https://www.youtube.com/channel/UC5Lbnd97HV3rU98gcwHklzQ
https://www.youtube.com/channel/UC5Lbnd97HV3rU98gcwHklzQ
https://www.facebook.com/groups/528423924186756/
http://fatdragongames.proboards.com
Before inserting a Dragonbite™ clip, you must first remove the printing support present in each slot on all four sides of every
model. We recommend using needle-nose pliers to gently twist the support out of place (always wear eye protection when using
tools.) Clips should be printed with 15-20% infill (but can be printed with 0%.)
To connect DRAGONLOCK™ Ultimate models together, simply insert a Dragonbite™ clip into the slot of one model, then slide
the adjoining model into the opposite side. In addition to the standard v3.0 clip, there is an optional thinner clip included. If your
clips are still too tight vertically, just scale them down a few % on the Z AXIS ONLY in your slicer.
Wall D Wall E Wall F
Stair Adaptor
Inside Corner
Stairs
Edge (Dungeon)
Floor F Floor C Floor A
Dungeon Door
Layer Height:
•All clips, walls and floor models: 200 micron/.2mm
Top/Bottom layers:
•5 layers or 1 mm
Infill:
•5-10 (15-20% for clips)
Rafts:
•None
Brim:
•None except for door
DRAGONLOCK™, DRAGONLOCK: Ultimate™, and Dragonbite™ are trademarks of Fat Dragon Games. @2019 Fat Dragon Games. All rights reserved.
For more information please visit: www.fatdragongames.com
Insert the door hinge into the hole in the door base Glue the door plug into place being careful not to
piece as shown (DO NOT GLUE.) get glue on the hinge (this step can also be done
last.)
Glue the lintel piece to the top as shown, being sure Put a small piece of electrical tape on the hinge as
the top of the door hinge is ‘captured’ in the hole shown (wraps to both sides.) This will allow you to
in the lintel. have your doors ‘friction’ fit to the hinge so they
can be easily swapped out with other door models
in Dragonlock Dungeon expansion sets.
FDG0160R Dragonlock Ultimate
Dungeon Starter Set (Revised)
Stair Adaptor
Inside Corner
Stairs
Edge (Dungeon)
FDG0160R Dragonlock Ultimate
Dungeon Starter Set (Revised)
Dungeon Door