Professional Documents
Culture Documents
Silent Install
Silent Install
---------------------------------
;
; To run this installer in quiet mode:
; 1. Edit the information below to match your company information and install
location.
; 2. Run : setup.exe <path to this file> /q /AcceptLicenses yes. Passing the value
"yes"
; to the /AcceptLicenses parameter indicates that you agree with the license
agreements.
; Alternatively, instead of /q, /qb can be used to run the installer in basic UI
mode.
; 3. The installer will automatically restart your system after the installation is
done.
; To prevent the restart use the command line : setup.exe <path to this file>
/r:n /q /AcceptLicenses yes
;
; Please contact National Instruments support at www.ni.com/support for further
assistance.
; If the SerialNo key exists but its value is empty, and the installer support
an evaluation mode, then an evaluation mode will be selected by default.
[UserInfo]
Name=
Company=
SerialNo=
; The valid feature states are Local, Absent, NoChange and Default.
; Local - Install it (on the local hard drive). If already installed leave it
installed.
; Absent - Do not install it. If already installed uninstall it.
; NoChange - Do not install it. If already installed, leave it installed.
; Default is equivalent to not listing the feature in this file. The feature
follows its default behavior.
[Features]
EWBEdu.EWB.EDU.120=Default
EWBCosim.EWB.COSIM.120=Default
ELVIS.EWB.EDU.120=Default
[Directories]
; This determines where on your hard drive the National Instruments directory goes.
; Leave this directory commented out if you prefer the default directory be used.
;<RootDirectory>=C:\Program Files\National Instruments
;
; Additionally, for each feature in the installer, you can specify where that
feature will be installed.
;
; NI Circuit Design Suite 12.0
;EWBEdu.EWB.EDU.120=C:\Program Files\National Instruments\Circuit Design Suite
12.0\