Professional Documents
Culture Documents
Tool Control
Tool Control
Systems Operation
312C, 315C, 318C, 319C, 320C, 321C, 322C, 325C, 330C and M325C Excavators
and 325C MHPU and 330C MHPU Mobile Hydraulic Power Units Engine and Pump
Control - V2
i01895785
Tool Control
SMCS - 5700
When an attachment tool is being operated, the engine speed and the pump flow are
controlled according to the type of tool. For more information, refer to the appropriate service
manual for the tool control of the machine that is being serviced.
Selection Of A Tool
There are five preprogrammed tools. The operator selects the tool. The monitor is used to
make the selection. The following items are examples of some parameters which can be
adjusted in order to accommodate a particular tool:
This process results in better simultaneous operation of the tool and operation of the
implement.
Note: A "System 5" Tool Control does not have a proportional reducing valve.
The controller detects an attachment pump section. This offsets the load of the attachment
pump. This process also prevents a decrease of the engine speed. If an attachment pump is
operated with 30 percent of the rated load and the main pumps are operated at the same
time, a reduction in engine speed is prevented.
Copyright 1993 - 2011 Caterpillar Inc. Mon Mar 7 16:32:39 UTC+0700 2011 Mon Mar 7 16:32:27 UTC
All Rights Reserved. +0700 2011
Private Network For SIS Licensees.