Professional Documents
Culture Documents
PAFM250W Rev3.0
PAFM250W Rev3.0
___________________________________________________________________________
250W - PROFESSIONAL FM POWER AMPLIFIER MODULE
Designed for FM radio transposers and transmitters, this amplifier incorporates ALL-IN-ONE technology and MOSFET
transistors to enhance ruggedness and reliability.
General characteristics:
● 87.5 - 108.0 MHz.
● 48 Volts.
● Input/Output 50 Ω .
● Pout : 250 W NOMINAL, 300 W max.
● Gain : 14 dB typical.
● Output -60dB Low Pass Filter (L.P.F.).
● Fuse protection (10A).
● FWD/SWR output sensors, FWD input sensor and Temperature sensor1.
● Input 2.5dB attenuator.
● Devices: MRF151 or equivalent.
1.
Temperature sensor installed: LM35, LM335, LM50, DS18B20 or similar.
RF Output/RF Input
98 Mhz test
350
300
250
RF Output (W)
200
150
100
50
0
4 6 8 10 12 14 16 18 20
RF Input (W)
RF Output/Frequency
15W RF Input
255
254
253
RF Output (W)
252
251
250
249
248
247
88 90 92 94 96 98 100 102 104 106 108
Frequency (Mhz)
RF Output/Frequency
20W RF Input
305
300
RF Output (W)
295
290
285
280
88 90 92 94 96 98 100 102 104 106 108
Frequency (Mhz)
Connections
1. RF Input (0-20W). You connect 50 ohm coaxial cable (RG316 or RG178 type) in this connection.
2. FWD Input Sensor 2-pin connector. 1= VFWD INPUT, 2=GND
3. Temperature sensor 3-pin connector.
If LM35 installed - 1= , 2= , 3=
If LM335 installed - 1= , 2= , 3=
If LM50 installed - 1= , 2= , 3=
If DS18B20 installed - 1= , 2= , 3=
4. V-Bias. Control V bias.
5. Fuse (10A). You use 10A max. fuse.
6. FWD/SWR Output Sensors 3-pin connector. 1=VFWD OUTPUT, 2=GND, 3=VSWR/RFL/ROE
7. RF Output (0-250W). You connect 50 ohm coaxial cable (RG303, RG400 or RG142 type) in this
connection.
8. +48V input power supply connection Vs. Connect BLACK/GND to GND/Earth and RED/+48V to
you +48V power supply. +48V/9A min. RECOMMENDED.
9. V-Bias. Control V bias.
Mechanical