Professional Documents
Culture Documents
Please read whole pages carefully before you proceed for the work.
Mini repeater can be made by connecting two IC-400Pro(IC-F210) back to back using Optional
OPC-617 cables and Combine cable (Not prepared by Icom)
This modification applies only to IC-400Pro and IC-F210, and does not apply to IC-F210S
and other radios.
Adaptor cable
Required materials
1. IC-400Pro (transceiver) x2
2. OPC-617 (optional cable) x2
3. Adaptor cable (2x 9Pin D-sub Male connectors)
4. Resistors 10k ohms, 1.8k ohms.
(Programming software CS-400pro#11 and programming cable OPC1122 are required to
complete the job)
To connect two radios via OPC-617 cables, prepare adaptor cable made with two male 9 pin
D-sub connectors.
Radio modification
Remove R225 and connect wire to C288 from 10k ohm resister.
Connect wire from 10k ohm resister to the joints of C179, C359
Mod 3 :
Make a soldering bridge at Link "F"
Radio programming
Using programming software you need to do…………
1. Program Transmit and Receive frequencies and CTCSS tones, etc.
2. Enable a switch which goes to ground when signal is received. (RX EXO)
This enable the PTT on the transimtter radio when signal is received at RX radio.
3. Enable a PTT from option socket. (EPTT) (As a default, external PTT is inhibited)
4. Repeater tail adjustment. (RX EXO delay time)
Prgoram Transmit frequency , CTCSS tone and power setting in Transmitter radio.
You can erase unwanted channels by highlighting the channels and pressing Del button.
Program the Receiver for RX channel in same way. Put freq.
CTCSS Power setting
Check the repeater performance by injecting 1kHz single tone with variable deviations
and see the output deviation varies linearly acording to the input.
If the output deviation exceeds too much or not sufficient, adjust the 1.8k ohm
resister by replacing it to similar value with some variation.
In case the operator uses the repeater as a despatch radio and cutting the repeating audio by
setting the volume control to minimum is not acceptable, please take the audio line from other
point on the main board (Please see next page for details).
Instead of taking the RX AF from the joints of C179 and C359 which is located top
side of the main board, you need to take it from the bottom side of the main board,
Connect C288 and C185 via 10k ohm resister and ground it via 10k ohm resister as
shown in the picture below.