Sodium bicarbonate
Movabay Safety Data Sheet
‘econ othe Unt Nana GHS (Re. 6,201)
SS eee nae ae
aE
Pro frm substance
Name Sodium hysagencartonate
Eo, 2056338
CAS-No 14558
REACH regtraton No. (808) or2rse4sr608-s2.00r1
Produ code Novesooa
12. Relevant identified uses ofthe substance or mixture and uses advised against
Lite ofthe astancemoute Classmahing, meaty, ttoney arn, chemical nus, pH corer.
Fume reat
Deteraeney
Pama arimal mtrion
Hemoday,exapni ihe pramacetial ll, eset
DBepencng on race
13. Supplier's deta
NOVABAY PTE LTO
So tenbuss hrenve
Shngaore 627586
Tedpeanstaes
haces von.aia
14. Emergency telephone number
No aadtenlwtomaton alte
Se
Classification ofthe substance or mixture
Classitoaton acording tothe United Nations GHS
Not olsaes
22, Lal lement
Labeling according to the United Nations GHS
No abetngspoicatie
23. omer hazards
Cte nazarcs not conrbutng tothe None known
Gaustcaton
Adverse pivslcochemcahumanheath and To our knowledge, this produc dows no presen ary patra, poised ti handed in
‘roel fess 2corsance wt goed esupatona hypene an saley packs
ISECTION 3: Composition/information on ingredients
34. Substances
Substance ientfcation codes: See section 1.1
Name %
‘Sadun hysrogeneabonate | (sn 144858 100 Not lesaed
tan cao _
32 Mixtures
Not applicable
44. Description of first ald measures
Fist-acd measures general * Inal cases of doubt, or when symplems peri, seek medial attention, Never give anything
by mouth to an unconscious person.
Fist. measures after inhalation “Move the affected person away fom the contaminated area and into the fresh a. eration
persists, consutt a sector
First-akd measures aftr skin contact ‘wasn wan soapy water.
First-akd measures afte eye contact Immecttely rinse wih wate fora prolonged period wale holding the eyelids wide open. it
station pert, conauit an eye special
maoa7 EN Ealehy 6Sodium bicarbonate
Safety Data Sheet
orig tothe Unt Nations GS (Rey 6, 2015
Festal mestues after Ingestion ‘Get medial edvieatenion If possible show bs sheet, not avalabie show packaging or
label
42. Most important symptoms and secs, both acute and delayed
No atonal intematon avaliable
43. Indication of any immediate medica attention and special treatment needed
"No axonal information avaible
84. Extinguishing media
‘Sutable extinguishing media ‘All extingushing agents can be used.
52. Special hazards arising from the substance or mixture
Fie hazard Not combustible.
React To our knowedge, the product does not present any particular rk, under normal condtions of
53. Advice for firefighters
Fiofighting instructions Contain the extinguishing fu by bunding
Protection during thefghting Do not attempt o take action without suitable protective equipment. Sei contained breathing
‘apparatus. Complete protective eethng
SECTION 6: Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
8.4.1. For non-emergency personnel
Emergency procedures ‘Avoid contact with skin and eyes. Do not breathe dust
6.1.2. For emergency responders
Protective equipment ‘Do not attempt to take action wihout sutable protective equipment. For further information
‘refer to section 8: "Exposure contoa/personal protection
82. Environmental precautions
Contain he spilled material by bunding, Do not dlscharge into drains or rivers.
6.3. Methods and material for containment and cleaning up
Fer containment ‘Sweep up or vacuum up the preduct
Methods fo clearing up Wash contaminated area with lage amounts of wate,
Other information Dispose of contaminated materials in accordance wth curtentreguiations.
ISECTION 7: Handling and storage
7A. Precautions for safe handling
Precautions for sate handling ‘Avoid contact with stn ana eyes. Avia creating or spreading dust. Extraction to remove dust
atts source
Hygiene measures ‘Do not drink, eat oF smoke in the workplace. Alays wash hands ater handing the product
7.2. Conditions for safe storage, including any incompatibiities
Technical measures Take all necessary measures to avoid aocdental discharge of products into drains and
waterways due to the rupture of containers or transfer systems
‘Storage conditions ‘Store in original container. Store in a cry area
Incompatile products Actes,
SSSR ENE
1. Control parameters
‘No ackstional information avaiable
82, Appropriate engineering contols
Appropriate engineering cortits Ensure good vertaton ofthe work station. Emergency eye wash ounars and salty showers
Pamssranesirg ‘should be available in the immediate vicinity of any potential exposure,Sodium bicarbonate
Safety Data Sheet
scx tothe Unt Nato GS (Rey 6, 2015)
83. Individual protection measures, such as personal protective equipment (PPE)
Hand protection CChemicaly resistant protective gloves,
ye protection Safety glanses (EN 185)
‘Skin and body protection Protective clothing
Respiratory protection the ventilation i suitable, fs not essential to wear respiratory equipment. n case of
insufcent ventilation, wear sutabe respeatory equipment (EN 148) Dust mask FFP
8.4, Exposure limit values forthe other components
No adatonal information avaiable
nT
{Information on basic physical and chemical properties
Physical tate Sold
Aopearance Powder
Colour white.
dour odouress.
(Odour threshold No data avaiable
PH 8
pH soluson S0oH
Relative evaporation rate (byacetate=1) No data avaiable
Relative evaporation rate (ether=1) No data avadabie
ting point 270°C
Freezing point No data avaiable
Boling point ‘No data avaiable
Flash point Not applicable
‘Autoignition temperature No data avaliable
‘Decomposition temperature >=50°C
Flammability (sd, 2) Non nammable
Vapour pressure No data avaiable
Vapour pressure at 50°C No date avaiable
Relative vapour density at20°C No data avalabie
Relative densty 221-223(20°0)
Relative density of saturated asia mixture No data avaiable
Density No data avaitle
988 denaty No data avaiable
Sohbity soluble in water.
Water 93:4 gf (20 °c) (pH = 8.4)
Organic sovert insoluble
Lop Pow No ta avaiable
Log Kow No data avaiable
Viscosity, kinematic Not applicable
Viscosity, dynamic Not applicable
‘Vscosty, kinematic (aleulated value) (40°C) No data availabe
Explosive properties Not explosive.
‘Oxidising properties [Non oxidizing material according to EC entria.
Explosive its No data avalatie
Lower expiosive imt (LEL) No data avalable
Upper explosive lt (UEL) No data avaiable
d reac
‘To our knomedg, the product does not present any particular risk, under normal condions of use
102, Chemical stabitty
‘Stable at ambient temperature and under normal conto oF use
“Tends to cake (coli) on heating or under humid condone.Sodium bicarbonate
Safety Data Sheet
scan othe Unt Nato 5 (Rev 62015)
103. Possibly of hazardous reactions
Nene to our knowedge.
104, Conditions to avoid
Moisture. High temperature
10. Incompatible materials,
Fluorine. Acide.
108. Hazardous decomposition products
Carbon dioxide
ESSERE
¥
‘Acie toxic (ra
‘Acie txity (ermal)
‘cate tact (inhalation)
Not classed (Based on avalable data, the classification ceria are not met)
Not classifed (Based on avallabe data, the cassiction tera are not met)
"Not classed (Based on available data, the ciaseieationcrtria ae not met)
Sodium hyarogencarbonate (144-858)
L050 era rat > 4000 mgtg(EPAFIFRA 40 CFR 160)
{C50 inalaton rat > 474 mplan(EPAOTS 7501150)
Skin coresionietaton Nt assed (OECD 404 method)
pie
Senous eye damage/ntaton Not cassited((0ECD 405 method)
aH 8
Respiratory or ski senatisaton Not cassifed (Based on avaliable data, the clastication teria ae ot met)
Germ cet mutagenioty Not clase (Based on avlabl dt, the cassiicaton itera ae ott)
Carcnogensty Not cassifed (Based on avaate data, he Gassiation teria are not met)
Reproductive toxety Not classed (Based on avaible sat, the clasiicatin crea ae not met)
NOAEL (oa rat): 340 mgt
STOT-ingle expoaice Not assed (Based on avaiable data the classification teria re not met)
STOT-tepeated exposure
Not classified (Based on avaiable data the classification eri are not met)
‘Sodium Rydrogencarbonate (144-558)
[ NOAEL (ora, rat, 90 days)
‘Aspiration hazard
ISECTION 12: Ecol
121, Toxicity
‘Acute aquatictoxcty
(Chronic aquatic toxicty
[ 586 maha bodyweighivday Deveopnertaloncty
Not classed (Not appleate)
Not classes
Not cassiteg
‘Sodium hydrogencarbonate (144-55-8)
C50 fis
7100 mgWEh (Lepomis macrochirss) -
EC50 Daphnia “4100 mg/¥48h (Oaphnia magna)
'NOEC (ehroni) > ST mali 21 d (Daphnia magna) =
122. _ Persistence and degradability zi
‘Sodium hydrogencarbonate (144-55-8)
Persistence and degradatity Not applicable
123. _Bioaccumulative potential
‘Sodium hydrogencarbonate (144-558)
Bicaceumatve potential [ N@ adtional information availabe
124, Mobility in sot Be
‘Sodium hydrogencarbonate (144-558)
‘Mopity in so ‘No adaonal information avaiable
125. Other adverse eects
ozone
(ther acverse eects
Not classified
No adtiona information availableSodium bicarbonate
Safety Data Sheet
accord othe Unt Nations GHS (Rev. 62015)
ISECTION 13: Disposal considerations
Dispose of n accordance wth relevant local regulations. ncinerate ata icensed instalation.
SSqUOECAI IE
tr
131. Disposal methods
Waste treatment methoss
in accordance with IMDG /IATA /UN RTOS
141. UN number,
Not aplcable Nt applicable Not applicable
42, Proper Shipping Name
Tot applicable Tot apicabie [ Ret applicable
743. Transport hazard cass{es]
Nt appcabie Not appicable ot appicable
Nat appicabie Nt appicable ot appheable i
Taa__Packing TOU
Not appieable Not applicable ict applicable
145. Environmental hazard
‘Dangerous forthe envronment No Dangerous forthe envionment No Dangerous forthe envionment No
Manne posant
148. Special precautions for user
-UNRTDG
Transport regulations (UN)
-1moG
“Transport regulations (MDG)
“ATA
‘Transport regulations (IATA)
No supplementary infomation aval
Not subject
Not subject
Not subject
147. _‘Transportin bulk according to Annex of MARPOL. 72/78 and the IBC Code
Not applicable
SECTION 15: Regulatory information
16:1. Safety, health, and environmental national regulations specific for the product
Usted onthe United States TSCA (Toxic Substances Contol Act) invertor. Listed on the EEC
Inventory EINECS (European Inventory of Existing Commercial Chemical Substances) Listed
nthe Canadian DSL (Domestic Substances Lis) Listed on the AICS (Australian Invanory of
‘Chemical Substances). Usted onthe Korean ECL (Existing Chemicals Uist) Listed on lECSC.
(Inventory of €xisting Chemical Substances Produced or Imported in China. Usted onthe
‘Japanese ENCS (Exising & New Chemical Substances) inventory
SSRN ance
Regional egisiation
Date of issue
05 UN
301032017
‘7 oman on cra eed ect te pe he, ay and annmere meme nk ete
edo gaan am pop ee