You are on page 1of 12
SERVICE MANUAL No:TE040720 LL ES Models. TAC-42CF TAC-42CHF ‘TCL Air Conditioner Service Manual IMPORTANT NOTICE This service manual is intended for use by individuals possessing adequate backgrounds of electrical, electronic and mechanical experience. Any attempt to repair the appliance may result in personal injury and property damage. The manufacturer or seller cannot be responsible for the interpretation of this information, nor can it assume any liability in connection with its use. The information, specifications and parameter are subject fo change due to technical modification or improvement without any prior notice. The accurate specifications are presented on the nameplate label. How to order spare parts To have your order filled promptly and correctly, please furnish the following information: 1. Model No. with Indoor or Outdoor 2. No. in the Explosion View 3, Part Name 4. The quantity you ordered 1 Lied bero 2b-£0-8002 21/E d TOL. Air Conlon Service Mamsl Technical Specifications Model No. TACaRCF __[TACADOHE [ Tipe. {ooing Only | Heaing Pump ‘Conta yoe Remote Remcie Rated cooling capectiy Bui 2000 742000 ated heating capacity Biuh NA ,500+40,500. 4 EER for cooling Btuhar 2.48 3.03, COP for heating wa nN 103 iisture removal Liters 0 a0 [Hi aba 57 57 in rose [tS | 2 Low | eB4Ay 53 33 | Ouidoor noi level aA) et 64 Electeal Data —] Powersupply BOO BP Voltage Range v Cooling | A a0 30 Rated cutent Heating [A NA 76 ooing | Ww 4600 2700 oma Heating |W WA 7300000 Refrigerating System RefigerevCherge Gram | ReaRSDGg | REIBSOO Type. Rotary Rotary Model Compressor Mogel = — MEG —— Evaporator Tavern and Grooved tubo Qype ( 8.53) Condenser orugated fir and Grooved tubo ype © 8.53) Expansion deve Coplay ube Detecting system Wicrocomputer conrad everes sytem Fan System a a 10 70 indoor fan pe Gross ow | Gross tow Gooing [mm | Be0vae0re80 | Seav807360 Indocr fan speed [Heating [rom WA 5504801380 HM Dy pm 380 280 ‘Sieep [rpm 380 380 — Tn fan motor ouput Ww 100 160 ‘utdor air ereuaton ah = = ‘Outdoor fan ype Propelerfan| Propeller an ‘Gutior fan speed Bm 720 720 Outdoor fan metor ouput LW 200 200) ‘Connections Refigerant coupling : Fare bp Gas___ | nehes we a Connecting Pipe | Tiguid” [Inches rr 7 Sizo ++ Core connecting wing | S20, Drainage Pos oD ieam Others a Suilable area a 6-50 5-80 Netimensions [Indoor [mmm | 6AD> 4785» 860 | Bl 4765~ GB (wxHx0) [outdoor [mm | 960- e40- 960_| 900 840+ 960 Indoor Pkg a7 a7 os Outdoor | kg 6 60 Packing dimensions [indoor | mm | 625 4876+ 460 | Go5- 4a7 400 | wxHxD) ‘Guidaor [mm | 1405+ 490-4008 1105- 420-4005] indoor | Kg 55 35 cere ‘Outdoor | ks 66 6 Treading Gapadly | 20140140HQ 26056161 25156051 3 LeeaL Q 2L-£0-8002 TCL Air Gonattioner Service Manual Operation Details Remote Controller B6°S0)| Sscee7| aces EEO =008 ©8e8o0 D iS ° ® ON/OFF Baton © Used to start and stop operation when pressed. @ OPERATION MODE Selection Button © Used to select he type of operation mode: AUTO, Cooling, Dry, Fan(Only for Cooling Only) and Heating(Only for Heat Pump) @ FAN SPEED CONTROL Button © Used to select the indoor fen motor speed: Auto, High, Mid and Low. Zl/9 4 wei7L — @b-£0-B002 ‘TCL Air Consttioner Service Manual @ SLEEP Button © Used to set or cancel sleep mode operation. © VANE CONTROL Button © Used to adjust airflow direction. © UP Button (TOO COOL Button) © Used to increase the set room temperature and time, @ DOWN Button (TOO WARM Button) © Used to decrease the set room temperature and ti, ® ON TIMER Button © Used to select ON TIMER operation, © OFF TIMER Button © Used to select OFF TIMER operation, ‘The indication symbols on LCD: £3 ATO Indicator 2D Steep Mode indicator EHH Clock Indicator cooling indicator Air Flow Direction Indicator i ON TIMER Indicator @ 7 ? & Dry Indicator "°. Set Room Temp. Indicator © OFF TIMER Indicator 2 s B pan indicator a Fan Speed Indicator 5S Onder of ON and OFF Timer ‘Heating Indicator q ZU/S d beta 2L-£0-8002 ‘TCL Air Conditioner Service Manisl Eletronic Controller 1, Safety Control (1) Time Delay Safety Control © 3 minutos delay for compresior—The compressor is ceased for 3minutes to balance the pressure in the teftigeration eycle in order to protect the compressor. © 2 minutes delay for 4way valve—The 4way valve is consed for 2 minulcs to prevent the rofrigerant-gas abnormal noise when the HEATING operation is OFF or switch to the other operation mods. © 20 seconds delay for indoor fan— When the assistant thermistor tums off, the indoor fan operates in low speed for 20 seconds to release the heat of indoor unit (2) Indoor Pipe Temperature Sensor Frost Prevention Control ‘When the indoor pipe temperature sensor reads O* vor below for 5 minutes, the indoor pipe temperature sensor frost prevention control stats. The compressor and outdoor fan stop and indoor fan operates at high speed for 3 minutes, After, that, if the indoor pipe temperature sensor reads less than 5+ *this control prolonged until the indoor pipe temperature sensor reads 5+ *or more. (8) High Temperature Protection Control Dating HEATING operation, the outdoor fan, motor and compressor arc controlled by the indoor pipe temperature (o provent the high temperature of compressor. Outdoor fan OFF: 56+ + ‘Outdoor fan ON:50* + ‘Compressor OFF:60" * Compressor ON:50° + “AUTO” Mode Operation (2) When the "AUTO" mode is selected, the operation mode and initial set temperature are determined by the initial room temperature at start-up of the operation except to tum off the air conditioner and operates it again, (2) sfthe mode is change to “AUTO” mode from other mode, the “AUTO” mode doesn’t operate until compressor stop for more than 3 minutes. Mode Initial room tetaperature Initial sot temperature COOLING 26+ *or more Dae 6 DRY 20 +1025 + + 18 + HEATING for Heat Purp Type Less than 20° * Bee | FAN for Cooling Only Type ® In the “AUTO” mode , when the controller receives the up or down single of temperature, the set temperature can adjust by 1+ *upper or lower. The biggest you can adjust by 2+ + upper or lower. 3. “COOLING” Mode Operation (2) Wheo the COOLING mode is selected without setting temperature, the system will set the sct temperature at 26+ + eutomatically with the AUTO FAN speed. Q) When selecting the COOLING mode operation, the system will operate according to the setting by the remote controller and the operation is as following: 21/9 22a 2L-£0-8002 TCL Ait Conditioner Servive Manual Room Temp. Se\TEMP, + 4+ +] Set TEMP. + 4+ +] Time More then 2 min | More than 2min | More than 2mmin | More thani2 min | More than 2 min Indoor Fan SetSpeed | SetSpeed | Set Speed | Sei Speed ‘Set Speed Compressor ON OFF ON, OFF ON. Outdoor Fan ON, OFF ON ‘OFF ‘ON “DRY” Mode Operation: (1) The system for DRY operation used the same refrigerant circle as the cooling circle. (@) When the system operates in DRY mode at first it operates in cooling mode at 18 for 3 minutes, and then, the system operates in cooting mode with low speed that regards the temperature of the room ‘temperature sensor reads decrease 2+ as the set temperarure. During the course of this, the fan speed ‘setted operation is failing but the vane motor can be controlled. “HEATING” Mode Operation (Only available for Hout Purnp) (2) When the HEATING sods is selected without setting lemperaturc, the systems will sat the temperature at 23 ‘+ + sutornatically with the AUTO FAN speed. (2) When selecting the HEATING imode operation, the system will operate according to the setting by the remote controler aud the operation is as following: SetTemp. » 4 +} SctTemp. + 4* | I 7 Room Temp. | a Time ‘More than 2 min | More thin 2 min | More than 2min | Morethan 2 min | More than 2 min ‘Compressor ON OFF ON OFF ON ‘Outdoor fan ON OFF ‘ON OFF ON @) InHEATING mode, the indoor fan motor is coniolled by Cold Air Prevention Control (4) Cold Air Prevention Controt © The function is intend to prevent cold air from being discharged when the heeting operation starts or when defrosting. © Ths indoor fan speed will be cottrolled as following: © The vane angle is atthe angle C(100» 3, 34° 30° a 25°F 23 sampiodiay, adtg Z0opuy 6 AL d a 22F9L 2L-£0-8002 ‘TCL Air Conditioner Service Manual (8) Defrost Deftosting of the outdoor heat exchange is controlied by the microprocessor with detection by the defrost sensor. © Defrost starting conditions When the conditions ofa) or b) is satisfy, the detkosting operation stars a) Under the heating operation, the compressor cumulative operation time exceeds 40 minutes and the \emperature ofthe outdoor deftost sensor reads lowerthan + 6° *continuously for 3ninutes. ) Under the heating operttion, the compressor cumulative opcration time exceeds 40 ininutes, if the indoor pipe temperature is lower than 32+ + continuously for 3minutes, Note: If haven't the otitdoor pipe temperature sensor that use the condition b) to defrost, against ase the condition ¢). © Deftost terminating conditions ‘When the condition e) ord) i satis, the defrosting operation stops. ) The outdoor pipe temperature is higher than 20° + @) The defrosting time exceeds 10 minutes. © Deftosting time chart ‘Outdoor Fan on or, on t I t 1 t | Reversing Valve ON, OFF | ON | 1 i | i | 14 tot Compressor Relay |ON | OFF ON DEF ON rt — <——____—p | 398 158 [Defrost Count MAX 12m 198| 15S | t s+ (6) Assistant Thermistor Function Assistant thermistor is add the thermitor of the electricity to rise the heating capacity automaticaly not effected by’ the signal of the remote controller about assistant thermistor ON/OFF buttons. 1) When the condition all of A~G aro satisfy the assistant thermistor should be on. ‘A. Under the heating operation, the compressor has been running over than 2 minutes. ‘The indoor fen operates in normal. ‘The system operates notin defrosting ‘The assistant thermistor has been off over than 10 scconds. ‘The setted temperature is 3+ bigher than the room temperature and 15°C

You might also like