Operator's Manual
Flo-Gard® 6200
Volumetric Infusion Pump
Baxter(CHANGE RECORD PAGE
Spestation number: 7-196-148
Original sue: 169
Revision A: 780,
ae change rood
Page vision
Coverbank
Tie
hangs record page
12
3
4
5
6 through 10
"
Signature
Total number of pages: 18
Ae nthe revision column indicates orga issue,
eseIntroduction
“The Baxter Fo-Gard® 6200 Volume Inuson Pum can deve a wide vary of fulds,heudng blood, over abroad
‘ange of infusion ates. The pumps features nce:
+ asyto oad, spilcesistant pumping mechanism,
“+ Occision sensors that detect both upstream and downstream aston,
+ Utrasonc ar detector tat senses bubles approximately 50 microltars or lpr without nuance alarms.
+ Safty lama mectarsm that proven accidental ree fo.
+ Looking control pana that prevents tampering.
+ ndeandent sendy mestton progam that atonateay switches oe Yo pray program vpon
compl
+ Uses standard Baxtr solution administration sets.
+ Autorati sal-est routine that checks for proper function afore use.
+ Fveour momory whic tans infusion data after power-of
+ Easy replaceable fuse, batty, and power cord,
‘Technical Specifications
(Catalog Code Number 218043
Deseipon Una perstaic volumetric infusion pump
Adinstation Set Banter Standard administration sets wih’ sui
Dutpu Pressure Ina distal octusion arm pressures approx. t07 psi
‘Aine Dtetion Air buble approximately 80 miroir or larger
Flow Rate Range 4-989 mL int mL increments, for both primary and secondary
Volume Range 48899 mL for bath primary and secondary
Koop Ven Open {KUO} Rate § mL/hr or programmed rate, whichever as
Nurse call Option anistaation kt is requed
Baty Le 5 hours on tly charged batteries, at 125 mL
Baty Recharge ‘6 hous to recharge ta 8% of capacity
ACPower Requirements 110/120V,€0 Ke
Power Cord 24 (tong, wth Hospital Grae pug
fuse (05 A, 2600, $8, 695 mm (1 In) x 31.8 mm (1-44 in)
Leakage current Lass man 0 microamps (using UL specie est matnaas)
Wight ha (14s)
Dimensions 24 om Wx 16cm 027 om (94 /2inW x6inD x 11 in)
eePhysical Description
efor to igures 1,2, and3 for he focaton ofthe fallowing tems.
‘tem
1.0N-OFFICHARGE Key
2, Massage Display
8. Nain Display
4. PRIRATE Key
5.PRIVTBI Kay
6.PRI START Koy
7. Numeral Keyboard
8 STOP Key
8. SILENCE Key
10.SEC RATE Key
11. SED VT Key
12. SEC START Key
18, ALARWLED
14, PUMPING LED
15, ALERTLED
18 TOTVOLISTATUS Key
17,LEAR TOTVOL Key
18, BACK LIGHT key
19, CHARGING LED
20, Door Latch
21, Upstream Osesion
Sensor
22, Pumping Mecnarism
Funct
Turns the pump on and oft, To pus internal tary charger remains on
regardless ofthe OH-OFFICHARGE key a lon as the pump is lugged ito
“15 VAC power source,
‘Shows al alam and art messages.
‘Shows te, volume tobe infod (VAN, an total volume intse for pinay
and secondary ntsion programs.
Ertars thentusion ate forthe pinay solution,
Enters the VTBI forthe primary soliton,
Stars the Slvr of te primary soluon
‘The numerical values for Rate and VTB are antered wth these Keys. The CLA
ay clears any RATE or VIB} curantybeing entered.
‘Stops purging unl futher instwtions ae given. Analet wl sound the
‘pumps stoped for more han two minutes
“ermporarty shones an ual ala or alr fortwo minutes, All iu nm
or alt infemation mains spayed
Ents tha nso at forthe secondary sluton.
Enters the VIB rhe sesondry soliton
‘Stats th dvr ofthe secondary salon
‘Red LED hats onan ft uring an slam, accompanied by isa! es
ope cispay and arate one sound An am ets ha to pump =
tres inmate ateton,
Gren LED wich is constant trina puri.
‘elo LED wtich's constant during an ale, aecorgane by avisual mes
‘40 pay anda lngl ong evry ight secon. AN at nde that the
pump mutes sma rate ateton
‘Whoa pss, he tl volume nus is splayed forth secon, ne
{anal and volume dt react puping program spayed fr thee
secnnds
esos the volume ins 1 ao when he pup is stopped
Sackights the main and messape dispays when presse. resing te ky
nu urs the bachlgning ft te pumps oprsing on btn post
cling remains on for 0 saconds each ie the BACKLIGHT to
press
Green LED whichis constantly wl the pump Is plugged in andthe battery
Iseraroing.
(pens an cases the pump doo.
Detects 2 complete fing restriction upstream ofthe pump.
near grist pumping mechanism
Se
oe23, Dounstear Occlusion
‘Sensor
24. Tube Loading Diagram
25. Safety Ciamp
28. Ar Sensor
27. Powe Cord cp
28, PANEL LOCK Switch
29, FUSE
20, VOLUME Knod
5, Power Cod
2, Accossory Port
38. Auto
94, Nurse Cl Pont
96, sattery ompartmant
26.1V Pole Camp
Tee
Figure 1. Front View of Pump
Detects tung restrctons downstream ofthe pump,
Shows the correct way to load tubing int the pur.
Prevents accidental id fow when te pump door is opened,
Detects air bubbles nthe ting,
Storas power cord duxing battery operation and pump storage.
Disables front pane control, exept BACKLIGHT and TOT VOLISTATUS, when
presse
Fuse camparimant
‘Adusts sound lve! of asi alarm andlor tones. The tones cannot be
‘umes completely of
Femevable ony by qualified personel for easy replacement
‘ws aditon future acessories.
For goaration ofa
‘Allows aon of an optional nurse cal ack,
‘ons easy acess to the bey.
Senurs the pump tothe IV pole
alarm and alert tones.\
\33 (N34
Figure 3. Rear View of Pump
TreesDperating instructions
Satety Precautions
«+ DANGER Pasibe explosion nazad Hus Inthe presence ot lammabieanesinatcs.
ope pump fom 115 V, 60 He nasal orade arth-qrounded ouetony. Leave the pump lugged inwhed
notin us a mahtan te bat charge.
‘as wihanylusion det alvay replat fl eananers bore srs permitted ene eset aires
thet or fhe pup cece lr, pipe ala rom se.
‘+ no tre pump wih ihe ON-OFFICHAAGE lay ON. The batiry may discharge complete
1 Nways ose he admiration sel corte lamp belo opening pun door and remoing Se
Ensure she bing is leaded eight trough the pura mechinsm ting gules and sufaly camp before
{losing ine urn Coo. reser se whan dosing te coor, check se misloace ubn.
Use nly wth start ante soft wing adminstain ses tal contain an" ha ast charac of he
‘ode nrior (Ir wail: 2084973),
«Whe nung tid rough ean! venus cata, Baxter rootimands ses with a Loerlock aopterbe
used
«using ter se, use on iar whic state special inthe nstreins wat ney may be used wh
mp Reeb and aw insets fhe Mart be Use.
«Winans sucindayinlsions programed se only Contin- Fl sts asthe pray tine sith a compatle
ecandey sat fr tha secondary
+s wit any insion devin vas very pingrammed information porto stating te cee
nstructions For Use
1. eed andundastand tls manual belo sng pump
2, Plug pum int 195Y, 6OHz grounded out unless ates power trea.
5. Prebard suis contne atid aaeh acmiitaon set accorcng to th dreetons accomparying the sods
ape a arto se
4, ose set coil lan,
5, Rese pump dot tise haa! poston an pul eof open
6, Pus safely clamp lo open postion.
7-Tnea tong run gl hal woop 0 Boo 99 shown Ha 4
8 hose pum door.
69, Opin set earl ci completely. Vay that ots ar fting in dip chamber tow ober, recheck
Tbe ong and make sure the pope it blag Used I Now aga obsres, domo use te mp. Have
Inspealy sere personnal :
40 itch sto vernunare or ober device
+1. ress ON-CFFICHARGE ke). Al iis iluminte moientay a shwnin igure 6. Te aude ale sounds
‘snd pumps plugoadin, the CHARGING CED igh.Esther)
Bee
Oo
aes
@ @ Bam
Figure 4. Tube Loading Diagram Figure. Sot
St Displays
12 Set autble star knob onthe ear of the pump tothe desired lve
13. Set primary ow rates falous:
rose RATE ky.
> Enter desires cw rate n Lin} on keyboard. The pun wll nat accepte2r0as theft gered,
To correcta mistake press PRI RATE apa and reantarcoredt ae,
14, Set primary volume tobe itusad as follows:
4. Press PAI VTE,
. Entrcesred VII (nm on keyboard et V7BI equal tothe amount ffi in he container ress it
‘ested. To corect amit, poss PRI TEL again and e-anter the corect TEL,
15. If desire, reset the volume ntuse to or by pressing CLEAR TOT VOL,
16. Press PRI START ko. The groan PUMPING LED ght and a roving bor appear next othe low ate actg
Cont ow ty checking for dops in th administration st crip chamber.
17. To ead fot! volume infusod andor review infusion setings, press TOT VOUSTATUS key, TOTAL VOLUME
INFUSED i splayed fist, flowed by RATE and VTL
18. To halt infusion, press STOP kay, The PUMPING LED goes ou and STOPPED appears the massage dsl.
1 pump is ot restarted in two nuts, an ail alt sounds19, han he slated volume has bean delivered, te pup sounds an alert tone and switches toa KVO (Keep Vein
(pe) ate a § mL/r or he curet rte eting, whichever i owe.
Femave set rom pump as flows:
Press STOP ky.
Clase set ca.
Open pump door
Press SAFETY clamp buton
«heck that no i i owing in set, ten remove st fom pump.
Start
1. Prepare scene fid onthe and administaionset ecordingto ne instructors accompanying produc.
Exel alarrom he secondary et. Ta perarm avtomatipiggybacking, a Banter sellabeled Continuo should
housed
2 lose secondary set contol camp.
43, Sot secondary fw rate as flows:
‘Pras SEC RATE key The right-hand sea the main espay now shows secondary infusion data,
Emr cesired tow ate (a mL for secondary slution, To conecta mistake, press SEC RATE again
a revere the correct vale
4, Se sacondary volume t be infused a ows
2. Pros SEC VBI ha.
by Emar the cesied fd amount (in ml) on the keyboard, Set VTB! equal to the volume of uid inthe
‘comeing. To correcta mistake, press SEC VTB again an re-enter te correct ale.
8. Lower rimary container with the hanger accompanying the Baxter secondary st
6 Open secondary set control clamp,
1 Press SEC START to bagi itslon rops begin fling in the secondary set drip chamber. When the VTBl ofthe
‘secondary program reaches zero, the pump reverts tthe primary program.
‘Changing Flow Rates, whi 4s Rum
‘To change he pray Hort, iow the procedure given below.
4. ress PRI RATE key while pumps running. TITRATE apnears inthe message dsplay and an let tone sounds
peiogcaty.
2 Enter te new fw rate on he keyboart
'3,PressPRISTART, The pump bopns delving id atthe new ate, tealerttone stops, an the TITRATE message
Ssappes.
4.To change secondary How ata, flow the above procedure sing the SEC RATE and SEC START keys instead of
‘tha PRI RATE and PRI START keys.Locking The Control Panel
‘The pump conto pana canbe locked uring pumping to prevent tampering. canbe unlocke at ay tine. Tha TOT
\VOL STATUS and BACK LIGHT kas ara not fete ty the fck-out. This lows rouine fusion cata checks whl the
‘onto are sil cke
To lock the panel: While pump is running, press the PANEL LOCK svitch onthe rear of pump, The messape Loc
appears nthe main dsl.
To unlock the pane: Press PANEL LOOK again. The Loc message disappear. tthe pump s stoped due to an
infusion alam or an opened dor, the panel must unlocked to restate latuson.
Battery Powered Operation
‘The pun can operate cn itera battery power or up to fe hours at 125 mL. The pup automaticaly swiches to
baer oparation when the AG power is interrupted or the pump is unplvgges. When operating on try power, BAT-
TERY appears inthe message spay. Te batty automaticaly recarges whenever the pumps plugged in tis
recommended thatthe pump be plugged nto an AC outlet during storage to maintain tres aul charge‘Rierts And Alarms,
‘The flowing chat describes th pum’s alarm alertmessepes along wih the cause ofeach,
‘lor Message
‘STOPPED
0
RIVE! =0
TITRATE
PIRATE <0,
BarTERY
BATTERY Low
‘wit interior
Sartore
SECPROGRAM
SEC RATEO
seo vTBteg
‘lar message
AR
DeoLUsioN
ocotusion
UBSTAEAM,
‘000R OPEN
‘BATTERY Low with
"api thee
arm tone
FAILURE wih cote
umber
gow
Sits
Sp
gk
ae
wer
te
Sane
Shae
ange
Nofow
No tow
Flow
Eats
No Row
Notow
No tow
No tow
Alert Conon
Pump hasbeen in STOPPED modo fortwo minutes.
‘Primary V7B has been dlvere, The pum has suche to @KVO rate ofS
‘nh or programed rae, whichever Is ess.
Flow ates teng changod while purp fs wong. Pump wil remain in TTTRATE
alert condion unt START kay is pressod.
A primary ow rate of oo has ben ented. The ump wil remain in ts art
conden unl a non-eroprimary flaw rat is entered.
ump is operating on internal battery power.
‘Batory nesds recharging Pomp wl sop operating In appronimately teen
minutes uiss tis logged into an RC oul,
Secondary program datas beng programmed wile pump is running. Purp wil
romain ia Seo PROGRAM ale condition untl SE START keys pressed
A sozondary flow ae of rao has been enared. The pump wl rain in this alert
‘condton Una non-resaconcary flow ate sented.
A secondary VTBI of 200 has ben erteed. The pump wl remain inthis ert
Condon una on-treseeoncary VTE is entered
Possible Cause
4 Alrbubble at detector
bs mpty id container
ca setin ump
Closed distal clamp, stopeack,conged tr or ater blockage doomstream af the
ump.
‘lose lamp or other blockage upstream of the pup
Pump door not uly eased
Baty power has boon exhausted. tug pump into AO ott 1 restore operation
and recharge bay
Press OW-OFFIOHARGE ky twice ta ese. I FAILURE doos not clay, record the
‘or code number, remove pump rom use and have served,Cleaning and Maintenance
‘The exterior ofthe pump may be ceaned with sot eth, sparingly darpenee with any of the caver ste bel.
Follow manufacurers' ition instructors for concenvate cleaners,
‘lan puns that have ben usd in an solaton area wth an agent irom the Ist below tat leans ad snes,
1 spiage it he pumping mechanism oceurs, lean the mechanism immediately by wiping wit a sot cath dam
ponod with anya he claanors isto below
List of Cleaners
Cleaner ‘Manufacturer
pH, Septisol Vestal Laos
idex7 Surgios
‘Super Edison Eaison Camical Go,
‘iniaine (lnipas Co
Botaine Prous Freecck
‘solution of 10% bleach and
water
Soapy water
Isoprop alcohol up to 95%
Do nat clean or iinet internal pars by autoclave or seize ts pump with eylene oxide gas. Doing so may
damage the pump and void the warranty.
‘Do nat use th flowing chomicas on the pump. They wll damage te rot panel, Acetone, ammonia, berzene,
hyéroxlouene, methylene chlo, n-alky!slmediy ethybenzy!ammonluehlorie, and czon,
'‘Warranty And Service Information.
ee
Banter Healthcare Corporation warrants ha the equipment shall ete rom detects materia and workmanship
whan deivered tothe orgtal purchaser Barter Hoatneare Corporation's sol obligation stl be itd to repair or =
paceren, at Baste's option and excense ofthe defective pat or unit ora period of ane yar flowing he deo ne
"al davery, Warranty forthe replaceable batery packs ied to a prod of six months under nora use ane sr-
ve.
"THERE ARE NO OTHER WARRANTIES INCLUDING A IMPLIED WARRANTY AND ARY WARRANTY OF MERCHAN:
AGILITY OR FITNESS FOR A PARTICULAR PURPOSE WIHICH EXTEND BEVOND THE DESCRIPTION OF THE
PRODUCT AND THOSE EXPRESSLY SET FORTH IN TS LABELING, UNLESS USED ACCORDING TO THE DIRECTIONS
ACCOMPANYING THE PRODUCT, ALL WARRANTIES ARE SPECIFICALLY EXCLUDED. In na event shall Baer
Healthcare Corporation be responsible for nidetal consequential or exemplary damages, Madan, aeration,
‘ecalration o abuse, ang serve oy ther than a Saar Heatheare Crporatlon autre representative may vod
‘he waranty.
Service Informatio
Wie under Bat Heathcare Corpraion Warranty, Servi Agreement option) or ease apreementthe instu-
‘ment must nt be opened by unauthorized personnal
‘Contac Baxter Heatncare Corporation Customer Service sion for servioe and repair infomation forall instar
ment. In USA al (@00) THE: PUMP,
Shipping costs for ll unis retumed o Baxter Heltiare Corporation shal be paid bythe customer. The unit must be
Backs ins orignal container orn anther Baxter approved contains that wl provide adequate protection ding
Shipment. To ensure prompt elura, a Baxter Product Senice representative mus be otfed before shipping any unt
for repair. Wen caling Baste Procut Service, please be prare to provide code number and serial number othe
lun. sevice requst number wil be issued and shoul accomparyallcammuncatons. Atl witton dscripton
Of the problem shoul be attached tothe instrument when its returned fr sere,
Banter Heathcare Corporation wil nat be responsible for unawthoriedcetums or fruits damaged in shipment de
‘oiproper packing.