Professional Documents
Culture Documents
Master actuator
Location : Driver side door
Bonnet switch
Location : Below bonnet Follower
Location : All remaining door
Car security system
Functions
Security System
In an armed vehicle, if any of the above signals are sensed, the alarm will trigger.
ECU
To starter terminal
No. 50
Function Valet mode Standard
Valet mode delink the central door locking feature from anti-theft protection
features.
Procedure
Car locator feature can be used to locate the vehicle in a parking lot
Procedure
Ignition lock is a feature by which all doors will get locked, 20 seconds after
all the doors are closed and the ignition switch is turned on.
Ignition unlock is a feature by which all doors will get unlocked immediately
after the ignition switch is turned off.
Standard &
Function Siren chirp Programmable
Caution :
If , in a signal, the customer turns off the ignition, co driver gets out & waits for
more than 30 seconds and then tries to crank the engine, the siren will trigger
and the starter will be deactivated.
The customer will have to deactivate the alarm with remote and then start the
vehicle.
Passive locking is a feature by which the vehicle will get locked & armed
automatically , 30 seconds after the ignition is turned off & a door is
opened and closed
Caution :
If the customer gets out of the vehicle with the ignition key in the barrel , the
vehicle will get locked & armed in 30 seconds automatically, with the key &
remote inside the vehicle.
Anti hijack mode can be used to discourage a potential car-jacker from hijacking you
and your vehicle while driving. Siren and indicator light turns ‘ON’ when this mode is
triggered.
The opening of the car door triggers this feature when you are driving the vehicle or
ignition is ‘ON’. Siren will start after 20 seconds of the door trigger and will continue
to chirp for 20 seconds and after that it will continuously blow.
Under this condition, remote ceases to function and emergency disarm code need to
be entered to come out of anti- hijack mode.
Before the continuous blow of siren, one can turn ‘OFF’ the trigger by pressing the
valet switch once and can drive.
Caution :
The feature may be activated only on the insistance of the customers, where they
feel that, it is very helpful for them to get out of the hijack attempts and customer
should be educated on EMERGENCY DISARM procedure.
Function Two stage shock sensor Programmable
This feature provides the warning against possible intrusion into the vehicle in
armed condition. Incase of intrusion attempt or a shock , the shock sensor senses it
& triggers the alarm giving warning to the user.
Sensitivity of the sensor against shock can be adjusted by a setting screw (refer the
photograph). To adjust the sensitivity , first the feature has to be enabled using the
programming. Once the feature is enabled , the security system module has to be
accessed by opening the centre console . Adjustments have to be done to the screw
to get the desired sensitivity.
The system will be highly sensitive to the shock if position of the screw is at
maximum (Turn clockwise) and is less sensitive if the position is at minimum (Turn
anti-clockwise).
Reports are read by looking at the flashing rate of the security system LED.
LED
Rearming
Passive (arming) mode
Passive lock mode
Reports are read by looking at the flashing rate of the security system LED
When unlocking a vehicle with remote, if you hear four chirp sound, it indicates that
the vehicle has been intruded.
Diagnostic reports are read by looking at the flashing rate of the security system
LED
LED
CDL 2 – 5A
CDL 1- 20A
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the Passive arming mode off )
(Two chirp sound verifies the Passive arming mode on )
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the Passive locking mode off )
(Two chirp sound verifies the Passive locking mode on )
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the ignition lock mode on )
(Two chirp sound verifies the ignition lock mode off )
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the ignition unlock mode on )
(Two chirp sound verifies the ignition unlock mode off )
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the siren chirp mode on )
(Two chirp sound verifies the siren chirp mode off )
• Within 5 seconds, press and release valet switch FIVE times & wait for a second.
(One short siren chirp and one long chirp will confirm entry into the programming
mode)
• Within 5 seconds press & release valet switch A ( 1 to 9) times & wait for 1.5 Sec
(Siren beep A times confirms digit 1 of new password)
Within 5 seconds press & release valet switch B ( 1 to 9) times & wait for 1.5 Sec
(Siren beep B times confirms digit 2 of new password)
Within 5 seconds press & release valet switch C ( 1 to 9) times & wait for 1.5 Sec
(Siren beep C times confirms digit 3 of new password)
Within 5 seconds press remote button ( lock / Unlock),
( A four siren beep verifies to enter into program digit 4)
Within 5 seconds press & release valet switch D ( 1 to 9) times & wait for 1.5 Sec
(Siren beep D times confirms digit 4 of new password)
One long beep confirms the completion of secret code password programming.
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the two stage shock sensor mode on )
(Two chirp sound verifies the two stage shock sensor mode off )
• Press the remote button lock / unlock, while holding the valet switch in press
position
( Single sound verifies the Anti hijack mode on )
(Two chirp sound verifies the Anti hijack mode off )
After system is disarmed engine could Starter terminal of car connector may be
7 Correct the terminal connection
not start loose
Siren does not blows when alarm a.Siren connection loose Fix the connector properly
9 triggered (indicator light blinking, LED
flashing) a.Siren defective Replace siren
5 flashes Key at ignition ‘ON’ Put key at ‘OFF’ position and disarm
22 Siren blows when battery is connected This is system feature Press remote button
26 Security system is not doing Rearming Opened the door after disarm Do arm by button