Professional Documents
Culture Documents
ISBN 978-1-138-67349-6
www.routledge.com/cw/bird
© Taylor & Francis, 2017
All rights reserved
2. Which of the following is needed to extend the range of milliammeter to read voltages of
the order of 100V?
[a] a parallel high-value resistance
[b] a series high-value resistance
[c] a parallel low-value resistance
[d] a series low-value resistance
3. Figure 1 shows a scale of a multi-range ammeter. What is the current indicated when switched
to a 25 A scale ?
[a] 84 A
[b] 5.6 A
[c] 14 A
[d] 8.4 A
Figure 1
9. For the double-beam c.r.o. waveform traces shown in Figure 2, the amplitude of waveform P
is:
[a] 30 V
[b] 50 V
[c] 15 V
[d] 75 V
Figure 2
10. For the double-beam c.r.o. waveform traces shown in Figure 2, the peak-to-peak value of
waveform Q is:
[a] 30 V
[b] 50 V
[c] 15 V
[d] 75 V
Figure 2
11. For the double-beam c.r.o. waveform traces shown in Figure 2, the periodic time of both
waveforms is:
[a] 0.2 s
[b] 40 μs
[c] 0.1 Hz
[d] 200 s
Figure 2
12. For the double-beam c.r.o. waveform traces shown in Figure 2, the frequency of both
waveforms is:
[a] 10 kHz
[b] 5 mHz
[c] 10 Hz
[d] 5 Hz
Figure 2
13. For the double-beam c.r.o. waveform traces shown in Figure 2, the r.m.s. value of waveform P
is:
250
[a] V
2
15
[b] V
2
50
[c] V
2
30
[d] V
2
Figure 2
14. For the double-beam c.r.o. waveform traces shown in Figure 2, the r.m.s. value of waveform Q
is:
250
[a] V
2
15
[b] V
2
50
[c] V
2
25
[d] V
2
Figure 2
15. For the double-beam c.r.o. waveform traces shown in Figure 2, the phase displacement of
waveform Q relative to waveform P is:
[a] 54 leading
3
[b] rads leading
10
3
[c] rads lagging
10
[d] 30 lagging
Figure 2
16. The input and output powers of a system are 2 mW and 18 mW respectively. The decibel
power ratio of output power to input power is:
[a] 9
[b] 9.54
[c] 1.9
[d] 19.08
17. The input and output voltages of a system are 500 µV and 500 mV respectively. The decibel
voltage ratio of output to input voltage (assuming the input resistance equals load
resistance) is:
[a] 1000
[b] 30
[c] 0
[d] 60
18. The input and output currents of a system are 3 mA and 18 mA respectively. The decibel
ratio of output to input current (assuming the input and load resistances are equal) is:
[a] 15.56
[b] 6
[c] 1.6
[d] 7.78