Professional Documents
Culture Documents
HPE OfficeConnect 1950 Switch Series - Connecting The Power Cord
HPE OfficeConnect 1950 Switch Series - Connecting The Power Cord
CAUTION:
Provide a circuit breaker for each power cord.
Before connecting the power cord, make sure the circuit breaker on the power cord is turned off.
AC power source
HPE 1950 12XGT 4SFP+
HPE A-RPS800
top
1. Connect the AC power cord plug to the AC-input power receptacle on the switch.
2. Pass the cable tie through the cable retainer.
3. Use the cable tie to secure the AC power cord to the cable retainer.
4. Connect the other end of the power cord to an AC power source.
Figure 1: Passing the cable tie through the cable retainer
top
about:blank 2/4
14/11/22, 12:20 HPE OfficeConnect 1950 Switch Series - Connecting the Power Cord
top
Figure 4: Connecting the A-RPS800 power cord to an HPE 1950 12XGT 4SFP+ switch
about:blank 3/4
14/11/22, 12:20 HPE OfficeConnect 1950 Switch Series - Connecting the Power Cord
top
Hewlett Packard Enterprise Development shall not be liable for technical or editorial errors or omissions contained herein. The information
provided is provided "as is" without warranty of any kind. To the extent permitted by law, neither HPE nor its affiliates, subcontractors or
suppliers will be liable for incidental, special or consequential damages including downtime cost; lost profits; damages relating to the
procurement of substitute products or services; or damages for loss of data, or software restoration. The information in this document is subject
to change without notice. Hewlett Packard Enterprise Development and the names of Hewlett Packard Enterprise Development products
referenced herein are trademarks of Hewlett Packard Enterprise Development in the United States and other countries. Other product and
company names mentioned herein may be trademarks of their respective owners.
about:blank 4/4