Professional Documents
Culture Documents
This manual walks through the steps to create a simple project from setting HMI IP,
building project file, configuring PLC, to downloading project to HMI.
UM020003E_20200515
Table of Contents
1. Setting HMI IP ......................................................................................................... 1
cMT Series HMI ....................................................................................................... 1
Non-cMT Series HMI ............................................................................................... 4
2. Building EasyBuilder Pro Project ............................................................................. 7
3. Compiling, Downloading, and Running the Project ............................................. 10
EasyBuilder Pro Quick Start
1. Setting HMI IP
1
EasyBuilder Pro Quick Start
Step 4. Enter default password 111111 and then tap the Enter key.
Step 6. Toggle on [Obtain an IP address automatically] and then tap [OK] for HMI to
obtain a LAN IP address.
2
EasyBuilder Pro Quick Start
Step 7. If a DHCP server is not available or does not exist on the network, open
search bar on PC, enter cmd to launch command prompt and then enter
ipconfig to see current network configuration.
Step 8. Toggle off [Obtain an IP address automatically] and then enter an IP address
on the same network segment as PC. Click OK for HMI to obtain a LAN IP
address.
3
EasyBuilder Pro Quick Start
4
EasyBuilder Pro Quick Start
Step 4. Enter default password 111111 and then tap the OK button.
Step 5. Select [Obtain an IP address automatically] and then tap Apply for HMI to
obtain a LAN IP address.
5
EasyBuilder Pro Quick Start
Step 6. If a DHCP server is not available or does not exist on the network, open
search bar on PC, enter cmd to launch command prompt and then enter
ipconfig to see current network configuration.
Step 7. Tap [IP address get from below] and then enter an IP address on the same
network segment as PC. Tap Apply for HMI to obtain a LAN IP address.
6
EasyBuilder Pro Quick Start
Step 3. In the device list click [New Device/Server…] to set the device to be
connected.
7
EasyBuilder Pro Quick Start
8
EasyBuilder Pro Quick Start
Step 6. Create an object, e.g. a Toggle Switch, and set its Read/Write Address.
Step 7. Place the object in the editing window, and a simple project is built.
9
EasyBuilder Pro Quick Start
10
EasyBuilder Pro Quick Start
Step 7. A successful communication between HMI and PLC will display project
11
EasyBuilder Pro Quick Start
12