Professional Documents
Culture Documents
CHEMICAL IDENTIFICATION
PHYSICAL PROPERTIES
0
2 0
HEALTH REACTIVITY
P&G Hazard Class per HSE CBA GGC105: 2
Health Concerns: Slight eye and skin irritant. Repeated inhalation of dust above the TLV for
long prolonged periods (months to years) causes silicosis a fibrotic lung
disease. Hazard increases in proportion to the crystalline silica content.
ACGIH-TLV: 1.07-7.5 mg/CU M
OSHA-PEL: Not available at the time of publication
HSDS: P&G=2 Other=2017
Exposure Standards: mg/cu m: OSHA standard and TLV for total dust applies to clays containing 1-25%
crystalline silica and =(30mg/CU M (% Si02 +3)
Safety Shower / Eyewash Station per HSE DP GID090: Not required
MSDS: Not available at the time of publication
Personal Protective Equip: Use an approved dust mask where exposure exceeds the TLV.
Environmental Concerns: Installation using this material may require an environmental permit.
Air: Appropriate emission control is required.
Water: Spills in unloading, storage and process areas should not be permitted
to reach waterways via rainfall, runoff or hosing to storm sewers.
Locations with frequent spills should have yard or building drains
connected to municipal sewers with curbs or grading designed to
minimize rainfall run-off and encourage dry clean-up.
Process Safety Hazard/Concern: No process safety hazards concerns
Electrical Classification: Not available at the time of publication
Conductivity: Not available at the time of publication
Dust Control: Use effective dust control to maintain dust levels below the TLV, Required
at dump.
Dust Explosion Data:
Maximum Explosion Pressure: ----- psi
Maximum Rate of Pressure Rise: ----- psi/sec
Explosion Severity: ------
Minimum Ignition Energy of Dust Cloud: ------ btu
Minimum Ignition Temperature: ------ ° F
Minimum Explosive Dust Concentration: ------ oz /cu ft
Comments: Not available at the time of publication
Procter & Gamble Co. DESIGN AND CONSTRUCTION SPECIFICATION
Engineering Practice Revised:
------:------
AP-BASE SODIUM
Dry Material Data Sheet 12/01/01
Non- Discretionary
For P&G Use Only APBA
P&G HAZARD CLASS Design and manage per GGO 1002C and GGC 105. Changes to this
practice must follow the “Hazardous Service Specification Change Page: 3 of 3
2 Process”.
FABRIC & HOME CARE Product Category: Dry Laundry N.A.: X
Global:
SYSTEM CONSIDERATIONS
EQUIPMENT GUIDELINES