Professional Documents
Culture Documents
1. MATERIAL IDENTIFICATION
Skin Contact :
Wash the contacted part with water and soap. Wash the
contaminated clothes before being worn again.
Date of Construction : June 2007
PT. PERTAMINA (PERSERO)
Date of Revision :-
Directorate of Marketing and Business Page : 2 of 8
Inhaled :
Stop/Avoid further exposure. If there is occurrence of
irritation in the respiratory tract, dizziness,
unconsciousness, seek medical advice. When
BREATHING STOPS, GIVE RESUSCITATION FROM
MOUTH TO MOUTH.
Swallowed :
When is swallowed, give 1 or 2 glasses of water and
then once prior to the seeking of doctor, the Emergency
Installation or other Emergency Centers.
CAUTION :
Never stimulate the victims to vomit or to swallow
anything when they are unconscious.
Environmental Protection :
Prevent the entrance of the spill into the water ditches,
disposal channels, or its seepage into the earth.
Storage :
Ventilation system must be considered ,when we store
inside room. The classification of fuel must be
considered when we store in the storage tank. The
flammable vapour can be formed although stored at
below flash point.
The storage tanks must be grounded and bonded and
must be equipped with self closing valves, pressure
vacuum valve and flame traps. Avoid from flammable
substance, fire, electric or other hot surface
Breathing Protection :
Use breathing apparatus when the polluted
concentration in the air is higher than the permissible
threshold limit value.
Date of Construction : June 2007
PT. PERTAMINA (PERSERO)
Date of Revision :-
Directorate of Marketing and Business Page : 4 of 8
Eye Protection :
Use chemical type goggles
Skin Protection :
Use rubber or PVC gloves. Apply Good Personal
Hygiene Practices
RANGE METHOD
No. CARACTERISTIC UNITS MIN MAX ASTM IP
1. Cetane Number
Cetane Number or - 48 - D 613-95
Cetane Index - 45 - D 4737-96a
2. Density at (15o C) Kg/m3 815 870 D1298/D4052-96
3. Viscosity (at 400C) mm2/sec 2.0 5.0 D 445-97
1
4. Sulphur Content %m/m - 0.35 ) D 2622-98
5. Distillation :
Temp. 95 ºC - 370
6. Flash Point ºC 60 - D 93-99c
7. Pour Point ºC - 18 D 97
8. Carbon Residue % m/m - 0.1 D 4530-93
9. Water Content mg/kg - 500 D 1744-92
10. Biological growth *) - Nul
*) Special for Diesel Fuel that contain Bio Diesel, specification of Bio Diesel is accordance with the Goverment Regulation
NOTES
1. Aditif must be compatibel with engine
Aditif that contain ash forming is prohibited
2. Good maintain to reduce contamination with (dust, water, fuel,etc)
3. Labelling at pump must be adequate and definited
FOOT NOTE
NOTE 1 Range 0.35% m/m equivalent to 3500 ppm
The above mentioned specifications are in accordance with the Attachment of the Letter of Decision of Directorate General of
Oil and Gas No. 3675 K/24/DJM/2006 dated March17th 2006 and alterable anytime
Date of Construction : June 2007
PT. PERTAMINA (PERSERO)
Date of Revision :-
Directorate of Marketing and Business Page : 5 of 8
REPRODUCTION TOXICOLOGY :
Exposure through the skin of pregnant mice at
representative dosage does not give bad effect to the
mother mice and to their descendants
CHRONIC TOXICOLOGY :
Base oil which is contained in this product is refined and
hydro treated solvent. A study conducted by rubbing this
product on the mice skin does not show carcinogenic
effect
Regulation Information :
Sludge of this product can be categorized as Hazardous
Waste except if the test result of TCLP (Toxicity
Characteristic Leaching Procedure) unproved and
disposal methode in accordance with government
regulation on effluent disposal of Hazardous Waste.
RID / ADR :
HAZARD CLASS : 3
HAZARD SUB CLASS : 31(c)
LABEL : 3
DANGER NUMBER : 30
UN NUMBER : 1202
IMO :
HAZARD CLASS & DIV : 3.3
ID/UN NUMBER : 1202
PACKING GROUP : PG III
SHIPPING NAME : Diesel Fuel
Date of Construction : June 2007
PT. PERTAMINA (PERSERO)
Date of Revision :-
Directorate of Marketing and Business Page : 7 of 8
ICAO / IATA:
HAZARD CLASS & DIV : 3
ID/UN NUMBER : 1203
PACKING GROUP : PG III
LABEL(s) : Combustible
liquid
White
Radioactiive