You are on page 1of 15
| 1, SPECIFICATIONS Type: Gain: Continuous Average Power Output Frequency Response: Distortion: Hum and Noise: Input Sensitivity: Input Impedance: Input Connector: Output Connectors: Controls & Indicators: Power: Dimensions: Weight: ‘Two channel audio power amplifier 26 dB (each channel) 75 watts per channel at 8 ohms 100 watts per channel at 4 ohms 180 watts at Bridged mono at 8 ohms. Plus/Minus 0.5dB 20Hz-20kHz No more than 0.25% THD or IM, 0.01W to rated power, 20Hz to 20kHz (typically 0.02%) 101dB below rated output (unweighted 20KHz bandwidth) 1.6V RMS for rated output 15K ohms, nominal (2) Yinch phone jacks and XLR jacks. (unbalanced and balanced) Dual 5-way binding posts (Front Panel) AC main power switch, Power-on LED indicator, Signal on LED indicator Clip LED indicator x 2pes Channel One and Two level controls Monitor jacks 2 pes 110-120VACI60Hz | zeo.eaovacisoHz } Switchable 30W (idle), 300W (maximum) 1-3/4"H (440m) 19"W (48.3cm) 11.9" (30.2cm) behind panel 13” (82.5em) overall 16.2 Ibs (73 kg) ss al ' | 2, OPERATING THE AB 200 L — — “FRONT PANEL- tos a mel + POWER SWITCH - HEADPHONE MONITOR JACKS. 2. POWER INDICATING LED 4. LEVEL CONTROLS - CLIP INDICATORS 6. ON INDICATORS a. 0. 1 3 5. REAR: 7. UNBALANCED INPUT CORNECTIONS. BALANCED INPUT CONNECTIONS. @. NORM/HONO SELECTOR SWITCH 10. GROUND/LIFT SWITCH 1. OUTPUT CONNECTIONS. AA HOLLYOOT SLavd “€ | - | 4, 1 NN AVNSTENT AND TEST POINT LOCATIO INTIAL, SETTINGS: LEVEL CONTROL: MINIMUM eM via a a710-PA MEASURING PONT i ° iS eee ADLPOINT | MEASURE TDEL CURRENT ADL (oeu current aba. 2827,828, 927,928 war | stony | Tyra01 | 6-10my_| [OE conn Aoi, |___kez7eze___ (center voutcneck [ct outeut ro oxo | - | _

You might also like