Professional Documents
Culture Documents
Teorema
Teorema
Index
Page Page
*HQHUDO5XOHV
,QVWDOODWLRQ5XOHV
(OHFWULFDO,QVWDOODWLRQ5XOHV
:DWHU,QVWDOODWLRQ5XOHV
,QVWDOODWLRQ&KHFNXS
86( &86720(5352*5$00,1*
'D\WRGD\RSHUDWLRQ 'DWDÀRZFKDUW
Manual powering 6 &ORFNDGMXVWPHQW
Automatic switch off / Switch on 6
&XVWRPHUSDUDPHWHUVPHQX
Energy saving standby 6
Language selection 22
Energy saving mode 7
Service time menu 23
Forced switch on 7
Date and time 23
Description display symbols 7
'$7$PHQX&RXQWHUGLVSOD\DQG
&KDQJLQJWKHZDWHULQWKHERLOHU ]HURLQJ
&XS:DUPHUZKHUHFRQWHPSODWHG +RZWRDFFHVVWKHSURJUDPPLQJPRGH
'HOLYHU\RIWKHFRIIHH .H\PHQX&RIIHHVHOHFWLRQ
+RWZDWHUGLVSHQVLQJ .H\PHQX+RWZDWHUVHOHFWLRQ
6WHDPGLVSHQVLQJ .H\PHQX6WHDPDQGDLUVHOHFWLRQ
&OHDQLQJDQGPDLQWHQDQFH 3URJUDPPLQJPHDVXUHVXVLQJWKH
Simultaneous Washing 12 ³6(/)/($51,1*´IXQFWLRQ
Sequential Washing 13
Single Washing 14
,//8675$7,216 9,,
5XOHVIRUWKHZRUNHURSHUDWLQJWKH
machine 17 &KDQJLQJWKHHOHFWULFSRZHUVXSSO\ 9,,,
0DLQWHQDQFHDQG5HSDLUV
'LVPDQWOLQJWKHPDFKLQH
'HIHFWV0DOIXQFWLRQV
7KHVHFKDSWHUVLQWKHPDQXDODUHWREHXVHGE\TXDOL¿HGDXWKRUL]HGWHFKQLFDOVWDII
1 EN
1. General Rules
Please read the warnings and rules in this User’s Manual carefully before using or handling the machine
in any way because they provide important information regarding safety and hygiene when operating the
machine.
Keep this booklet handy for easy reference.
• The machine was designed solely for preparing espresso coffee and hot beverages using hot water or steam, and for
warming cups.
• The machine must be installed in a place where it is only used by carefully trained staff that knows the risks tied to using the
machine.
• The machine is for professional use only.
• The machine must not be used by children or by people with physical, sensorial, or mental impairments: if such people use
the machine, they must be supervised during operation.
• Children must be supervised at all times to prevent them from playing with the machine.
• The machine must not be left unattended.
• The machine must not be used outdoors.
• If the machine is stored in rooms where the temperature can drop below freezing, empty the boiler and water circuit tubes.
• Do not expose the machine to atmospheric agents (rain, sun, and cold).
• Noise: assessed acoustic pressure level: 79 dB(A) (+/- 1dB).
• If the machine is used improperly or for purposes other than those described above, it can be a source of danger. The
manufacturer will not be held responsible for damages caused by improper use of the machine.
2 EN English
,QVWDOODWLRQ5XOHV
:$51,1*
,QVWDOODWLRQGLVPDQWOLQJDQGDGMXVWPHQWVPXVWRQO\EHSHUIRUPHGE\TXDOL¿HGDQGDXWKRUL]HGWHFKQLFLDQV
&DUHIXOO\UHDGWKHZDUQLQJVDQGUXOHVLQWKLVPDQXDOEHFDXVHWKH\SURYLGHLPSRUWDQWLQIRUPDWLRQUHJDUGLQJ
VDIHLQVWDOODWLRQXVHDQGPDLQWHQDQFHRIWKHPDFKLQH
.HHSWKLVERRNOHWKDQG\IRUHDV\UHIHUHQFH
• Staff responsible for moving the machine must realize the risks in moving heavy loads.
Move the machine carefully, using the correct lifting equipment (fork lift, for example).
If moving the machine by hand, make sure:
HQRXJKSHRSOHDUHDYDLODEOHIRUWKHWDVNGHSHQGLQJRQWKHPDFKLQHZHLJKWDQGGLI¿FXOWKDQGOLQJ
- to always use the necessary safety gear (shoes/gloves).
• After removing the machine from its packing materials, make sure that the machine and its safety devices are intact.
• ,IWKHSRZHUVXSSO\FRUGLVGDPDJHGLWFDQRQO\EHUHSODFHGE\TXDOL¿HGDQGDXWKRUL]HGWHFKQLFLDQV
• Packing materials (plastic bags, polystyrene foam, staples, etc.) must be kept out of the reach of children because they are
potentially hazardous.
• Before plugging in the machine, make sure that the information on the nameplate (voltage, etc.) matches that of the electrical
and water systems.
• Completely unwind the power supply cable.
• 7KHFRIIHHPDFKLQHVKRXOGVLWRQDÀDWVWDEOHVXUIDFHDWOHDVWPPIURPZDOOVDQGIURPWKHFRXQWHU.HHSLQPLQGWKDWWKH
highest surface on the machine (the cup warmer tray) sits at a height of at least 1.2 meters. Make sure there is a shelf nearby
for accessories.
• Room temperature must range between 10° and 32°C (50°F and 90°F).
• An electrical outlet, water connections, and a drain with siphon must be in the immediate vicinity.
• Do not install in rooms (kitchens) that are cleaned with jets of water.
• Do not clean the machine with jets of water.
• Do not obstruct openings or ventilation and heat vents.
• Do not install the machine outdoors.
(OHFWULFDO,QVWDOODWLRQ5XOHV
Prior to installation, make sure there is a circuit breaker installed with a distance between the contacts that allows for complete
disconnection when there is a category III overload and that provides protection against current leakage equal to 30 mA. The
circuit breaker must be installed on the power supply in compliance with installation rules.
If the power supply is not working properly, the machine can cause transitory voltage drops.
7KHHOHFWULFDOVDIHW\RIWKLVPDFKLQHLVRQO\HQVXUHGZKHQLWLVFRUUHFWO\FRQQHFWHGWRDQHI¿FLHQWHDUWKLQJV\VWHPLQFRPSOLDQFH
ZLWKWKHHOHFWULFDOVDIHW\ODZVLQIRUFH7KLVIXQGDPHQWDOVDIHW\UHTXLUHPHQWPXVWEHYHUL¿HG,ILQGRXEWUHTXHVWWKDWDTXDOL¿HG
electrician inspect the system. The manufacturer cannot be held responsible for any damage caused by the lack of an earthing
system on the electrical supply.
It is unadvisable to use adaptors, multiple plugs, and/or extension cords. If their use is indispensible, only use simple or multiple
adaptor plugs and extension cords that are in compliance with safety laws. Make sure these devices do not exceed the voltage
capacity marked on the simple adaptor and on extension cords, and the maximum voltage marked on the multiple adaptor.
Check that the type of connection and voltage correspond with the information on the nameplate: see LOOXVWUDWLRQVFKDSWHU¿JXUH.
For machines with a Y connection: see LOOXVWUDWLRQVFKDSWHU¿JXUH.
For machines with a ' connection: see LOOXVWUDWLRQVFKDSWHU¿JXUH.
For machines with a single-phase connection: see LOOXVWUDWLRQVFKDSWHU¿JXUH.
3 EN
7KHVHFKDSWHUVLQWKHPDQXDODUHWREHXVHGE\TXDOL¿HGDXWKRUL]HGWHFKQLFDOVWDII
:DWHU,QVWDOODWLRQ5XOHV
:$7(55(48,5(0(176
Water used in coffee machines must be potable and suitable for human consumption (see laws and regulations in force).
Check on the machine’s water inlet that:
• the pH level complies with the laws in force
• the chloride value is less than 100 mg/l
If the values do not fall within the limits, an appropriate water treatment device must be inserted (respecting the local laws and
compatible with the machine).
,IWKHPDFKLQHXVHVZDWHUZLWKDKDUGQHVVH[FHHGLQJ)'DVSHFL¿FPDLQWHQDQFHSODQPXVWEHLPSOHPHQWHGDFFRUGLQJ
to the hardness detected and machine usage.
:$51,1*
Only use the supplied parts for installation. If other parts are installed, they must be new (not used) and they must be able to come
in contact with potable water suitable for human consumption (according to local laws in force).
:$7(5&211(&7,216
3ODFHWKHPDFKLQHRQDÀDWVXUIDFHDQGVWDELOL]HLWE\DGMXVWLQJDQGVHFXULQJWKHIHHW
Hook up the water connections as shown in the ,OOXVWUDWLRQV FKDSWHU )LJXUH , respecting the hygiene, water safety, and anti-
pollution laws in the country of installation.
1RWH: If the water pressure can rise above six bar, install a pressure reducer set at 2-3 bar. See ,OOXVWUDWLRQVFKDSWHU)LJXUH.
Water draining tube: place the end of the water draining tube in a drain with a siphon for inspection and cleaning.
,03257$17: The curves of the draining tube must NOT bend as shown in ,OOXVWUDWLRQVFKDSWHU)LJXUH.
4 EN English
,QVWDOODWLRQ&KHFNXS
:$51,1* $)7(5 ,167$//$7,21 &+(&. 72 6(( ,) 7+( 0$&+,1( ,6 :25.,1* 3523(5/< VHH WKH
Installation Module C)
WATER CONNECTIONS
• No leaks from the connections or tubes
FUNCTIONING
• Boiler and operating pressures are normal.
• The pressure gauge is working properly.
• The self-leveling device is working properly.
• The expansion valves are working properly
:$51,1*: ONCE THE MACHINE HAS BEEN INSTALLED AND IS READY FOR USE, BEFORE ALLOWING THE
:25.(5 72 67$57 86,1* 7+( 0$&+,1( :$6+ 7+( ,17(51$/ &20321(176$&&25',1* 72 7+(
INSTRUCTIONS BELOW:
*52836
• +RRNXSWKH¿OWHUKROGHUVWRWKHJURXSVZLWKRXWFRIIHH
• Let each group dispense water for about a minute.
+27:$7(5
• Continuously dispense hot water (pressing the appropriate button) until at least 6 liters of water have been used for a
machine with 2 groups and 9 liters for a machine with 3 groups (see the “Cleaning and Maintenance” Chapter in the User’s
Manual).
5 EN
86(
'D\WRGD\RSHUDWLRQ
³%HIRUHVHWWLQJWKHPDFKLQHDWZRUNPDNHVXUHWKDW:
• WKHPDLQHOHFWULFSRZHUVZLWFKLVRQ;
• WKHPDLQVZDWHUFRFNKDVEHHQWXUQHGRQ OK 1 2
0$18$/32:(5,1*
Press the luminous main switch (1) to turn on the machine. The
the key LEDs light up and the following message will appear
on the display (14):
14
26 September 2012
wednesday 15:15:04
21
If the water level in the boiler is lower than the minimum limit,
WKH ERLOHU ZLOO EH ¿OOHG WR WKH ULJKW OHYHO$W WKH HQG RI WKLV
phase, the icon will appear in the lower left hand corner The machine is ready for use when the display (14) indicates
of the display. the set working pressure and the icon
The preset working pressure must be reached before the is no longer shown on the display:
machine is ready for use.
If any dispensing key is pressed during this phase, the following
26 September 2012
message will appear on the display:
wednesday 15:18:12
26 September 2012
wednesday 15:15:04
MACHINE COLD
PLEASE WAIT
$8720$7,&6:,7&+2))6:,7&+21
The machine can be set to switch off and switch on at 1RWH. When the machine is working in the automatic on/off
programmed times. Consult the “Service time menu” chapter function do not use the general switch (1) to switch off the
to set the “ON Time” switch-on time and the “OFF Time” machine. If this happens, the machine will not be able to switch
switch-off time. on again automatically.
When a service time is set, the machine automatically switches The machine switches on automatically at the programmed
off at the programmed time. During the automatic switch-off timed. The messages displayed and the operations performed
phase, the following message will appear on the display: by the machine are the same as those described in the para-
graph “0$18$/32:(5,1*”.
26 September 2012
wednesday 15:15:04 (1(5*<6$9,1*67$1'%<
When the machine is switched off, it can be set to the ENERGY
MACHINE OFF SAVING mode.
When this function is enabled, the machine resistance is not
completely disabled and keeps the boiler pressure at 0.2 bar.
Please consult the chapter “Service time menu” for setting
this function.
6 EN English
This symbol indicates the boiler water level. This symbol indicates that the machine is pre-heating or
During the loading phase, the dark bottom part of the icon the boiler pressure has dropped below 0.5 bar.
blinks. This also indicates the boiler heating situation, meaning that it
When the optimum level is reached, the symbol looks like DSSHDUVLIRQHRUPRUHERLOHUVDUHVWLOOLQWKH¿UVWKHDWLQJSKDVH
this: or if their temperature has fallen below 55°C.
If one of the STOP/continuous coffee" (&) keys is pressed,
coffee will be served at the temperature reached at that
moment.
This symbol (dark inside) indicates that the resistance All of the other keys are disabled because the working pressure
is activated and functioning. has not been reached.
While waiting for the machine to be ready for use, insert the
When the boiler pressure reaches the set value, the icon
¿OWHUKROGHUVLQWKHXQLWV
looks like this
The machine has reached the set work pressure and
(light inside). temperature when the icon
When the machine is in operation, the two icons disappears from the display.
alternate on the display, indicating the presence of the electric Press a coffee selection key for each keypad to adjust the
heating. WHPSHUDWXUHEHWZHHQWKHJURXSDQG¿OWHUKROGHU
1RWH WKH FXVWRPHU FDQQRW VZLWFK RQ RU VZLWFK RII WKH
HOHFWULFKHDWLQJ When present, this symbol indicates that the cup warmer
When the on/off function is programmed, the electric heating is on.
takes place automatically.
26 SEP 12 15:15
Press and hold down the “RES” key () for about 3
seconds to return to the regular display mode.
7 EN
&KDQJLQJWKHZDWHULQWKHERLOHU
%HIRUHRSHUDWLQJWKHPDFKLQHFKDQJHWKHZDWHU
LQWKHERLOHU´
Ensure that the indication on the display corresponds to the 1 2
working pressure value.
.HHS D KRW ZDWHU GLVWULEXWRU NH\ ) pressed down for
approximately 5 seconds.
The following message will be displayed: “WATER CHANGE”.
OK
The water from the boiler will drain from the hot water nozzle
1 2
&XS:DUPHU(where contemplated)
8 EN English
upon completion.
Press the continuous/STOP distribution button for
a continuous distribution.
The distribution, both dosed and continuous, may be interrupted
at any time by pressing the continuous/STOP key .
+RWZDWHUGLVSHQVLQJ
127(
- When using any of the dosing buttons, the distribution may
be interrupted at any time by pressing the previously active
key again.
- The adjustment of the economizer for regulating the deli-
vered water temperature is made by the installing service
technician.
9 EN
6WHDPGLVSHQVLQJ
'LVSHQVLQJZLWKWKH$XWRVWHDP(Turbosteam)VHOHFWRU
Machines equipped with the AUTOSTEAM (STOP STEAM)
dispensing system have the "VWRS VWHDP GLVSHQVLQJ ZKHQ
OK 1 2
$
1 Select the type of milk you prefer (heated or frothed)
by changing the position of the "steam selector lever" (11
depending on your selection, the following icons will appear
on the lower right hand corner of the display:
9a
IURWKHGPLONPD[LPXPIURWKLQJOHYHOOHYHUSRVLWLRQ
IURWKHGPLONPHGLXPIURWKLQJOHYHOOHYHUSRVLWLRQ
IURWKHGPLONPLQLPXPIURWKLQJOHYHOOHYHUSRVLWLRQ
Press the "AUTOSTEAM automatic steam key" ()
17
WKHWHPSHUDWXUHGHWHFWHGE\WKHSUREHDSSHDUVRQ
the display.
6WHDPGLVSHQVLQJZLWKOHYHUFRQWURO
Completely immerse the left () steam nozzle into the
container with the liquid to be heated and push the steam
control lever (17) upwards.
Wait until the liquid has reached the desired temperature, then FOHDQWKHLQVLGHRIWKHVWHDPQR]]OHDVIROORZV
lower the steam command lever to stop the issue of steam.
7XUQWKHQR]]OHWRZDUGVWKHFXSWUD\DQGFDUHIXOO\
DFWLYDWHVWHDPGLVSHQVLQJDWOHDVWRQFH
1RWH$WWKHFRQFOXVLRQRIHDFKVWHDPGLVSHQVLQJSKDVH
10 EN English
1RWH 2QFH WKH ZDVK F\FOH LV XQGHUZD\ LW &$1127 EH
)RUFRUUHFWDSSOLFDWLRQRIWKHIRRGVDIHW\V\VWHP VWRSSHGHYHQLIWKHPDFKLQHLVVZLWFKHGRII
+$&&3SOHDVHIROORZWKHLQVWUXFWLRQVLQWKLV ,IWKHUHLVDSRZHUIDLOXUHZKHQSRZHULVUHWXUQHGWKHPHV
SDUDJUDSK VDJH³EXECUTE WASHING´ZLOOEHGLVSOD\HG&RPSOHWH
WKHFOHDQLQJRSHUDWLRQVDVGHVFULEHGSUHYLRXVO\
Procedure to effect at the end of the work day on all groups
or when signaled by the machine. 7KHZDVKF\FOHVSHUIRUPHGZLWKRXWUHTXHVWE\WKHPDFKLQH
FDQEHLQWHUUXSWHGE\VZLWFKLQJRIIDQGVZLWFKLQJEDFN
&2))((&,5&8,7&/($1,1*&<&/(6 RQWKHPDFKLQH
7KHSXUSRVHRIWKHÀXVKLQJF\FOHLVWRUHPRYHDOOWUDFHVRI
grease and scaling deposited when the coffee is dispensed. The simultaneous washing mode lasts 7 minutes. The single
)DLOXUH WR ÀXVK RXW WKH FLUFXLW ZLOO DOORZ WKHVH GHSRVLWV WR washing mode lasts 7 minutes for each dispensing group.
solidify. This will impair the qualitative performance of the
coffee circuit. Programmed wash cycles that are not effected will be memo-
127(WKHIROORZLQJRSHUDWLRQVPXVWEHFDUULHGRXWZKHQ rized by the machine.
WKHPDFKLQHLVRQDQGSUHVVXUL]HG
To perform the washing cycles, follow the steps on the next
$77(17,215,6.2)6&$/',1*'XULQJWKHZDVKF\FOHV pages.
KRWZDWHUDQGVWHDPZLOOH[LWIURPWKHJURXSV.HHSWKH
KDQGVDQGDOORWKHUSDUWVRIWKHERG\ZHOODZD\XQWLOWKH
FOHDQLQJF\FOHKDVWHUPLQDWHG
1RWH,IQRZDVKF\FOHPHVVDJHVDSSHDUDQGWKHPDFKLQH
LVXVHGIUHTXHQWO\DZDVKF\FOHFDQEHSHUIRUPHGDWDQ\
WLPH
11 EN
SIMULTANEOUS WASHING
1 STOP
4
STOP
SET1 SET2
OK 2
1
t o c h a n g e s e l .
8
8 12
12 4
4
16 0 16
0
t o c o n f i r m
5 6 7 STOP
will display:
0 16
26 SEP 12 15:15
I N S E R T. F I LT E R H O L D E R
push
to confirm
Pour in a packet or dosing
cupful of detergent powder.
Insert the rubber disk into the +RRN DOO WKH ¿OWHU KROGHUV WR
¿OWHUKROGHUZLWKLWV¿OWHU the groups.
9 10 11
26 SEP 12 15:15 26 SEP 12 15:15 STOP
SET1 SET2
OK 1 2
R E M O V E F I LT E R H O L D E R
GR... WASH
push 8
12
to confirm 4
0 16
The wash cycle will start and At the end of wash cycle, the
the "GR... WASH" message message "REMOVE GROUP
Press the coffee circuit wash
will appear in alternated way FILTER HOLDER" will appear.
key (). on the display. 5HPRYHWKH¿OWHUKROGHUV
14 15
OK 1 2
26 SEP 12 15:15 26 SEP 12 15:15
GR... RINSE
12 EN English
1 STOP
4
STOP
SET1 SET2
OK 2
1
t o c h a n g e s e l .
8
8 12
12 4
4
16 0 16
0
t o c o n f i r m
9 10 11
STOP
26 SEP 12 15:15 26 SEP 12 15:15
R E M O V E F I LT E R H O L D E R
SET1 SET2
OK 1 2
GROUP 1
GR1 WASH
8
push
12
4
0 16
to confirm
The Group 1 wash cycle will At the end of the group 1 wash
start and the *5 :$6+ cycle, the message "REMOVE
Press the coffee circuit wash
Hook the filter holder to message will appear on the ),/7(5 +2/'(5 *5283 "
Group 1. key (). display. will appear.
14 15 16
STOP
SET1 SET2
OK 1 2
26 SEP 12 15:15 26 SEP 12 15:15
8
12
GROUP 2 WA S H
4
0 16
GR1 RINSE
push
to confirm
17
Repeat the operations
described above for all machine
groups.
13 EN
SINGLE WASHING: Cannot be carried out if the machine launches a warning message.
1 STOP
4
STOP
SET1 SET2
OK 2
1
t o c h a n g e s e l .
8
8 12
12 4
4
16 0 16
0
t o c o n f i r m
5 6 7
t o c h a n g e s e l . t o c h a n g e s e l .
Confirm the choice (for
example, group 3), using the
key and OK . The screen will
display:
t o c o n f i r m t o c o n f i r m 26 SEP 12 15:15
I N S E R T. F I LT E R H O L D E R
GROUP 3
Use the “+” () and “” Use the “+” () and “”
keys to pass to the 6LQJOH () OK
() OK keys to choose the group
push
to confirm
Wash. A rectangle will highlight to be washed.
the group that will be washed.
Insert the rubber disk into the
¿OWHUKROGHUZLWKLWV¿OWHU
9 10 STOP
11
OK 1 2
26 SEP 12 15:15
8
4 12
0 16
GR3 WASH
14 15 16
26 SEP 12 15:15 STOP
R E M O V E F I LT E R H O L D E R SET1 SET2
GROUP 3
OK 1 2 26 SEP 12 15:15
push
to confirm 4
8
12 GR3 RINSE
0 16
17 26 SEP 12 15:15
The washing cycle is complete
after the rinsing phase. Repeat these steps for the
groups you want to wash.
14 EN English
*5283/2&.('
EXECUTE WASHING
&+$1*,1*7+(:$7(5,17+(%2,/(53URFHGXUHWRFDUU\RXWDWOHDVWRQFHDGD\
.HHS D KRW ZDWHU GLVWULEXWRU NH\ ) pressed down for
approximately 5 seconds.
The following message will be displayed: “WATER CHANGE”. 1 2
The water from the boiler will drain from the hot water nozzle
(10) (60 - 70% ca. of the total capacity). OK 1 2
),/7(5+2/'(567KLVRSHUDWLRQPXVWEHPDGHRQDOOWKH¿OWHUKROGHUVDWWKHHQGRIHDFKZRUNLQJGD\
1
Put a liter of cold water in a 6RDN WKH ¿OWHUV DQG WKH ¿OWHU
suitable container and add 5HPRYHWKH¿OWHUVIURPWKH¿OWHUKROGHUV holders in this solution for
detergent. about 2 hours.
4 5 $
3ODFHWKH¿OWHUVEDFNLQWKH¿OWHUKROGHUPDNLQJVXUHWKDWWKH
Remove any residue with a sponge and rinse well with cold water.
anchoring spring ($RIWKH¿OWHULVLQLWVVORW
15 EN
Using a clean sponge, wash with hot water removing any organic
residue present. Rinse carefully.
To clean the inside of the steam nozzles, follow these steps:
Turn the nozzle towards the cup tray and carefully activate steam
dispensing at least once.
127(WKHSURFHGXUHVGHVFULEHGEHORZFDQDOVREHFDUULHGRXWZKHQWKHPDFKLQHLVVZLWFKHGRII
'DQJHURIEXUQV
'2127 insert your hands beneath the
front panel.
16 EN English
%()25(<2867$57
:$51,1*: BEFORE YOU START OPERATING THE MACHINE, WASH THE INTERNAL COMPONENTS
FOLLOWING THE INSTRUCTIONS INDICATED BELOW.
THESE STEPS MUST BE REPEATED AT LEAST ONCE A DAY AND WHEN THE MACHINE HAS NOT BEEN
OPERATED FOR MORE THAN 8 HOURS.
*URXSV
• +RRNXSWKH¿OWHUKROGHUVWRWKHJURXSVZLWKRXWFRIIHH
• Let each group dispense water for about a minute.
+RW:DWHU
• Run the water replacement as indicated in the section "Changing the water in the boiler" (see the “Cleaning and Maintenance”
Chapter in the User’s Manual).
217+(-2%
6WHDPGLVSHQVLQJ(also with Autosteam)
• Before heating the beverage (water, milk, etc.), open the steam nozzle for at least 3 seconds and let the steam escape so
that the condensation is eliminated.
&RIIHHGLVSHQVLQJ
• If the machine has not been used for more than an hour, before making coffee, dispense about 100 cc and discard the
liquid.
+RWZDWHUGLVSHQVLQJ
• If the machine has not been used for more than an hour, before using the hot water, dispense about 200 cc and discard the
liquid.
&OHDQLQJWKHFRIIHHFLUFXLWV
• 3OHDVHUHDGWKHVSHFL¿FVHFWLRQLQWKHXVHU¶VPDQXDOWROHDUQKRZWRFOHDQWKHVHFLUFXLWV
17 EN
&DXWLRQ
'DQJHURI%XUQV 0$&+,1(&/26('2:1
Do not place the hands or other parts of the body close to the :KHQ WKH PDFKLQH UHPDLQV XQDWWHQGHG IRU
coffee distribution points, or near to the steam and hot water D ORQJ SHULRG RI WLPH DW QLJKW GXULQJ WKH
nozzles. ZHHNO\ FORVLQJ GD\ RU GXULQJ KROLGD\V WKH
Ensure that the machine is not handled by children or persons IROORZLQJRSHUDWLRQVVKDOOEHSHUIRUPHG
who have not been instructed in its correct use. 5HPRYHWKHSOXJRUVZLWFKRIIWKHPDLQ
VZLWFK
&XSZDUPLQJSODWH
&ORVHWKHZDWHUWDS
1RQFRPSOLDQFHZLWKWKHVHVDIHW\PHDVXUHV
H[RQHUDWHVWKHPDQXIDFWXUHUIURPDOOOLDELOLW\
IRU PDOIXQFWLRQV RU GDPDJH WR SHUVRQV RU
LWHPV
0DLQWHQDQFHDQG5HSDLUV
If the machine is not working properly, turn off the machine, If the power supply cord is damaged, switch off the machine
turn off the main off-on switch, and call the service center. and request a replacement from the service center.
:$51,1*
Only use original spare parts guaranteed by the
manufacturer.
If original spare parts are not used, the manufac-
turer warranty will no longer be valid.
:$51,1*
After maintenance, perform the installation
&+(&.83 DV LQGLFDWHG LQ WKH VSHFL¿F VHFWLRQ
of the user’s manual.
18 EN English
Electrical equipment cannot be disposed of as ordinary urban WKH ODZV LQ IRUFH ZLOO EH VXEMHFW WR DGPLQLVWUDWLYH ¿QHV DQG
waste: it must be disposed of according to the special EU penal sanctions.
directive for the recycling of electric and electronic equipment.
(19,5210(17$/,1)250$7,21
7KLVSURGXFWFRQWDLQVDQRQUHFKDUJHDEOHOLWKLXPOLWKLXPPDQJDQHVHGLR[LGHFKHPLVWU\EXWWRQFHOOEDWWHU\IXOO\HQFDSVXODWHGLQWKH¿QDOSURGXFW
Recycle or dispose of batteries in accordance with the battery manufacturer's instructions and local/national disposal and recycling regulations.
19 EN
'HIHFWV0DOIXQFWLRQV
'LUHFWDFWLRQE\WKHFXVWRPHU
Before calling service personnel, to avoid useless expense, check whether the machine problem corresponds to one of the cases
listed below.
The coffee machine does not work and No electricity supply. Check the electricity supply.
the display (14) is blank. Check the position of the ON/OFF
switch (1).
/HDNLQJIURPWKH¿OWHUKROGHUULP, Underpan gasket dirty with coffee. Clean using the special brush pro-
). vided.
Coffee dispensing time too short. Coffee ground too coarse. 8VHD¿QHUJULQG
Coffee too old. Use new coffee.
Loss of water under the machine. Discharge well clogged up. Clean.
Discharge pan hole blocked. Clean.
Machine heated up, but it does not Water supply or water softener tap Open.
dispense coffee. closed. No water in system. Wait until water is available or call a
plumber.
The automatic level control devices Same causes as above. Same solution as above.
remain in operation.
20 EN English
#
_
+
$
OK 1 2
RES PRG
#
Only if "Prog. cliente" is YES and “Program. block” is NO
$
.(<0(18 '$7$0(18 &86720(5
Press Press Press
$
6(/(&7,21
.(<
#
Type
# #
_
+
&2817(56 6(59,&(7,0(
OK _ _ DATE AND TIME
+ +
21WLPH
OK OK 2))WLPH
:DWHUGRVH 'D\RII
(QHUJ\VDYLQJ
1LJKW21
1FRIIHH ,7$/,$12 1LJKW2))
:$6+
1ZDWHU (1*/,6+ :$6+
:$6+
1VWHDP )5$1&$,6
1VWHDP76 '(876&+
1VWHDPDLU76 1('(5/$1'6
1WRWFRIIHH (63$12/
32578*Ó(6
ɊɭɋɋɄɂɣ
(;,7,1*7+(352*5$00,1*0(186
Before exiting the menus:
3UHVVWKH
OK
OK NH\WRFRQ¿UPDQ\FKDQJHVPDGHWRVHWWLQJV
3UHVVWKH ³5(6´NH\WROHDYHVHWWLQJVXQFKDQJHG
The icons below will appear alternating on the lower part of the display:
OK 1 2
21 EN
&ORFNDGMXVWPHQW
Use the “+” () and “” () keys to adjust the clock.
26 September 2012
TheOKtime increases (or decreases) one minute each time the
wednesday 15:18:12
key is pressed.
If one of the keys ( or ) is pressed and held down
OK seconds, the minutes setting stops and the
for more than 10
hours setting increases (or decreases).
During the time setting phase, the seconds remain at "00".
&XVWRPHUSDUDPHWHUVPHQX
À&86720(53$5$0(7(56
+
To access "Customer parameters" press key ( WKH
following message will appear on the display: 6(59,&(7,0(
,7$/,$12
(1*/,6+
)5$1&$,6
'(876&+
Language selection
À&86720(53$5$0(7(56
To display the messages in a different language from that set, +
after entering into Programming mode, position the cursor on
6(59,&(7,0(
the desired language by pressing the “+” () and “” ()
OK key (). The machine will ,7$/,$12
keys and then pressing the “PRG”
(1*/,6+
restart with the messages provided in the selected language.
)5$1&$,6
'(876&+
The display (16) provides a choice of the following languages.:
Italian, English, French, German, Dutch, Spanish, Portuguese,
Japanese and Russian.
22 EN English
Pressing the “PRG” key (), the following message will :$6+$1':$6+(6·
appear on the display: Washing cycles can be performed at pre-set times. At the set
time, the display will show: this message “EXECUTE COFFEE
WASHING”.
À6(59,&(7,0( +
When requested, a washing cycle (simultaneous or sequential)
'$7($1'7,0( will be performed as described in the “Cleaning Operations”
21time 03:00 paragraph.
2))time 03:00
Day off none Follow these steps to set the time for the washing cycle:
Energy Saving YES • 3RVLWLRQWKHFXUVRURQWKHOLQHWREHPRGL¿HGWASH
• Press the “PRG” key (
• ChangeOK the time, using the “+” () and “” (NH\V
• Press the “RES” keyOK (WRFRQ¿UPWKHVHWWLQJ.
7KHIROORZLQJVHUYLFHWLPHSDUDPHWHUVFDQEHPRGL¿HG Repeat the steps previously indicated to modify the washing
21WLPHWLPHWKHPDFKLQHVZLWFKHVRQ times.
2))WLPHWLPHWKHPDFKLQHVZLWFKHVRII
GD\RIIGD\RQZKLFKWKHHQWHUSULVHLVFORVHG 127(6
(QHUJ\6DYLQJ (enable/disable the Energy Saving function: :DVK: wash 1 cannot be disabled. It is requested daily at
<(612 the programmed hour, and always within 24 hours.
1LJKW21 (start time for evening beverage price: only when :DVKHV· : if the set hour for these wash cycles occurs
SD\PHQWV\VWHPLVFRQQHFWHG when the machine is switched off, the request will be canceled.
1LJKW2)) (end time for evening beverage price: only when
Set OFF against the time so as to not activate these wash cycles.
SD\PHQWV\VWHPLVFRQQHFWHG
:DVKUHTXHVWHYHU\KUVDWWKHSURJUDPPHGKRXU OFF is displayed press the “” () key the indicated time
FDQQRWEHGLVDEOHG is "00:00".
:DVK·3 (hour of scheduled washes from 2 to 5) For more details, please consult the technical manual at the
&RQ¿JXUDWLRQPHQXZDVKRSWLRQVSDUDJUDSK
*HQHUDOLQGLFDWLRQV
If there is no day off (i.e. the enterprise never closes), enter
“none” for the “day off” item.
Enter the same time for the “ON time” and “OFF time”
parameters (for example:
ON time 22:00
OFF time 22:00)
if the automatic switch on/switch off function is not required
and you wish to manually switch the machine on and off.
'DWHDQGWLPH
To modify the date and hour, press the “PRG” key ()on Use the “+” () and “” () keys to move the cursor
the corresponding line. The following message will appear: EODFNOLQHWRWKHHQWU\WREHPRGL¿HGWKHQSUHVVWKH
OK “PRG”
key (). The cursor will turn into an arrow è and it becomes
possible to change the number for the selected entry by using
the “+” () and “” () keys. OK
OK
À '$7($1'7,0(
+ Once the operation is completed, press the “RES” key ()
WRFRQ¿UPWKHGDWD
<ear 12 Note: the cursor changes back to black line.
0onth 09 6(3 Repeat the operation described above to modify other para-
'ate 26 :(' meters.
+our 17
0inutes 12
23 EN
'$7$PHQX&RXQWHUGLVSOD\DQG]HURLQJ
À&2817(560(18
+
Counters can be zeroed by aligning the cursor on the selected
1° coffee gr. 1 01234 entry, pressing the “PRG” key (), and then pressing the
1° coffee gr. 2 01234 “+” () or “” () key.
1° coffee gr. 3 01234 OK
OK
1° water 01234 Press the “RES” key (WRFRQ¿UP]HURLQJ
1° steam 01234
The "N. coffee" entry appears for as many times as there are
machine groups.
+RZWRDFFHVVWKHSURJUDPPLQJPRGH
1% ONLY if the item “&XVWRPHU3URJU” is set on “<(6" and 1RWH: When modifying data, the cursor changes to " Æ", or
the item “3URJUDPEORFN” is set on “12". a slide bar with maximum and minimum settings will appear:
To access programming press the “PRG” key ( WKH
following message will appear on the display:
FRQ¿UPWKHFKDQJHVPDGHE\SUHVVLQJWKH OK key
2)OK
exit the menu and leave the settings unchanged by pressing
the “RES” key ().
24 EN English
À.(<0(18
+
Type 1 coffee
Water dose 110
OK 1 2
.H\PHQX+RWZDWHUVHOHFWLRQ
Press the hot water dispensing key (). The following mes-
sage will appear on the display:
À.(<0(18 +
1 2
Type water
dispens. time 20.0
OK 1 2
7KHIROORZLQJKRWZDWHUVHOHFWLRQSDUDPHWHUVFDQEHPRGL¿HG
ZDWHUGLVSHQVLQJWLPH (dispensing time in seconds.).
25 EN
.H\PHQX6WHDPDQGDLUVHOHFWLRQ
À.(<0(18
+
type steam and air
T stop steam 060°C
emulsion level 050
7KHIROORZLQJSDUDPHWHUVFDQEHPRGL¿HG
7VWRSVWHDP (“xxx°C” temperature for hot milk or frothed milk).
Setting options:
VHWWLQJ
• manual steam stop
$Q\QXPEHUEHWZHHQ&·&)·)
• automatic steam stop
2))VHWWLQJ
• steam stop disabled
26 EN English
The water doses for coffee and the hot water doses can also During this phase, the setting for the volumetric dosage
be set using the "SELF-SETTING' function: pulses (top right of display) is increased. When the key is
#
released, the setting reached is memorized and appears
under the programmed key.
3 - Starting from step 1, continue programing, as desired, on
all the coffee buttons.
#
1 - Press the button to be programed and keep it pressed until
the desired level is reached in the cup.
press and hold the STOP button for at least 8 seconds or until
you hear a buzzer sound that will keep sounding throughout
the programing. The menu below will appear on the display,
OK 1 2
showing the keys with the relative quantities for water for the
coffee.
SELF-LEARNING During this phase the time in seconds (top right of display)
STOP
LVLQFUHDVHGZKHQWKHNH\LVUHOHDVHGWKHVHWWLQJUHDFKHG
Group 1 DV: 000 is memorized and appears below the programmed
key.
STOP
SELF-LEARNING
#
:KHQ¿QLVKHGSUHVVWKH6723EXWWRQ7KHEX]]HUZLOOWXUQ
RIIWKXVFRQ¿UPLQJWKDWWKHSURJUDPLQJKDVEHHQFRPSOHWHG
27 EN
28 EN English