Corporation (TSC) has Standard Testing • 100% of our sensors are thoroughly tested. TSC dedicated eight years of R&D to perfecting the developed and • All sensors are checked for proper output at room temperature and at industry’s standard RTD. Testing was conducted manufactured quality RTDs to control industrial elevated temperatures. • Insulation resistance of all sensors is checked. at our in-house lab, at Oak Ridge National Laboratory, processes worldwide. • Every sensor is checked by QC personnel to assure it matches gross and at the University of Tennessee. Dedicated to employing specifications, e.g., sensor type, fitting options, lengths, etc. state-of-the-art techniques • Every passing sensor is given an engraved traceability number. TSC and the other independent labs which tested these RTDs were surprised that all RTDs survived the This number allows TSC to resurrect a unit’s material test report, six tests with no failures. In addition, to the best of our knowledge, there have never been more extensive and materials, TSC tests performed using the same RTDs for most of the tests. calibration data and part number. constantly strives for innovation and Advantages improvement in all its • Great insulation resistance due to highly compacted MGO along Test 1. Test 3. Test 5. with proprietary techniques performed during manufacturing. Time Response: RTDs plunged into Thermal Cycling: RTDs were cycled 284 High-temperature Vibration: RTDs products. A prime example TSC’s standard IR test is 100 volts’ input with a pass being greater 70ºC water flowing 3 fps. times between 26ºC and 480ºC. Each were tested on one axis with 20 g’s is our development of than 2,000 megohms. cycle took approximately 62 minutes. acceleration from 30 to 550 Hz at Result: Reliatemp, our lifetime Resistance data for the test articles was 540ºC. This test was continuous for • Wide span of temperature (-200 to +400ºC), with optional I-600 2.1-second response time average. recorded digitally eight times per minute two hours. moisture-free RTD sheath (-200 to +600ºC). for each RTD. Test 2. Result: with excellent vibration • Vibration-resistant due to encapsulation method of element. Result: Thermal Shock: RTDs were heated to No failures (power amplifier burned up, resistance, which • Improved time response due to moisture-free MGO compaction. No failures or intermittent behavior. but RTDs survived). 450ºC in air and plunged into room- addresses the industry’s • Less drift due to MGO compaction and iron-free backing power temperature water at 3 fps five times. in RTD tip. The average heating rate for the RTDs Test 4. Test 6. two main problems. We are was about 400ºC per minute, and the Vibration: RTDs were individually tested Insulation Resistance: RTDs were dedicated to continuing to cooling rate an average of 1300ºC per at room temperature on three axes with completely submerged in water for develop precision, high- minute. 3 g’s acceleration from 5 to 500 Hz. 2,000 hours. RTDs were then checked at 100 volts DC. quality products. Result: Result: No failures. No failures. Result: No failures (RTDs showed 2,000 megohms or greater).