Automatic Transmission
Road Test (cont'd)
7. Testtrive the vehicle on a flat road in the Bi position. Check for abnormal noise and clutch slippage. While driving,
‘check that the shift points occur at the proper speeds by monitoring the throttle position sensor voltage and
‘comparing your shift point spoods and voltage to those in the table. (The throttle position sensor voltage
represents the throttle opening.)
Upshift Biposition
[“Thettie Opening” | “Unit of Speed [ist ~ 2nd | “and =3d [Sed ath | Lockcup oN)
Throtile position mph o11 | 21-23 |~ 26-30 7-0 |
sensor voltage: 0.8 keh 36-17 | 33-37 [eas 75-79
Throttle position mph 21-23 | 39-43 | 5062 8-72
sensor voltage: 2.25 ¥ sees 3-9 83-69 | 98100. io=n6
Fully-opened throttle, | _mph 34-38 52-85] 98100 7101
Throtte position we 5561 | 88108 | 155-161) 186-162
sensor voltage. 45V |
Downshitt-i position
Title Opening | Unit of Speed_[ Lock-up OFF ath 3ed[_srd> Bad_|_~dnd— 16
Throttle position | mph|a5a8_ 19-21 | | 8-7 ed tal
sensor voltage: 0.8 V ker 73-71” | 30-38 8 1s
Sante postion tmp [aaa tT
sonsorvoltage: 2.25V | kmh | 94100 ——— ——
Fully-opened throne, | -mph | 81=94 8-6 | 4-88 25-30
Throttle position kwh) 186=182 ] 137-14 [87-93 08
sonsorvoltage:&5V 4) a Eee
8. Accelerate to about 35 mpl (57 kirvht) su the transtnissioi is in 4th, then shift from B¥ position to Z] posit
Tho vehicle should immediately begin slowing down from engine braking
9. Check for abnormal noise and clutch slippage in the following positions.
{1st Gear) Position
‘Accelerate from a stop at full throttle. Check that there is no abnormal noise or clutch slippage. Upshifts should
‘not occur with the shift lever in this pasition.
[2] (2nd Gear) Position
Accelerate {rom a stop at full throttle. Check that there is no abnormal noise or clutch slippage. Upshifts and
‘downshifis should not occur with the shift lever in this position,
[Ri (Reverse) Position
‘Accelerate from a stop at full heart, and check that there is ne abnormal noise or clutch slippage.
10. Test in B) Park) Position.
Park the vehicle on a slope (approx. 16°), apply the parking brake, and shift into[P! position, Release the brake:
vehicle should not move.
14-102