You are on page 1of 2

68 Operator’s Manual Vehicle Maintenance CXU,

CHU, GU, TD, MRU and LEU


Fuel Filters
A primary fuel filter can be located on the engine or remote mounted on the frame
rail. This filter consists of a filter cartridge, a water separation bowl and may have a
fuel heater built in.

The secondary fuel filter is located on the left hand side, below the engine electronic
control unit (EECU). The filter is a spin-on filter.
MACK MP engines utilize a spin-on primary and secondary fuel filters. Both filters
are located on the right-hand side of the engine.

W0054019

Fuel Filters MACK MP Engine

1. Secondary Fuel Filter 2. Primary Fuel Filter

The primary fuel filter on MACK MP engines incorporates a plastic water separator
bowl. Additionally, the plastic bowl includes a water-in-fuel sensor. A warning lamp
on the instrument panel illuminates when water is detected in the fuel. Refer to
Fuel/Water Separator section.
Note: There are optional fuel filter systems (such as Davco, Conmet, etc.) available
for MACK MP engines. These fuel filter systems use a single remote-mounted
filter, eliminating the spin-on primary and secondary filters. For service information
concerning these filters, refer to the specific fuel filter manufacturers service literature.
Operator’s Manual Vehicle Maintenance CXU,
CHU, GU, TD, MRU and LEU 69
Primary Fuel Filter Replacement Procedures
MACK MP Engines
At each specified oil and filter change interval, change the primary fuel filter as
follows:

W0054023

MACK MP Primary Fuel Filter

1. Primary Filter 3. Water-in-Fuel Sensor Harness


2. Water Separator Bowl 4. Drain Assembly

You might also like