Professional Documents
Culture Documents
2. Make sure the Fiery E100 power switch is set to ON (|), and then press the power button once
to start the Fiery E100.
3. Wait approximately 1 minute as the Fiery E100 completes the startup sequence.
At first the LED display flashes sporadically and shows 00; then it flashes sporadically again
before reaching and remaining at 00.
4. If the Fiery E100 is connected to the printer, wait for the Start page to print.
CONNECTOR PANEL AND RISER/LED BOARD INTERFACE 14
Normal position
[not used]
[not used]
LAN port
[not used]
Interface connector
(for image transmission) For installing system
Riser/LED board components software from a USB drive.
• Service switches
• Service LEDs
Power button
Power switch
Power connector
N OTE : By default, the printer touch panel displays information in the New Version style
shown in the following procedure. If the New Version is not working and the message displays
“The server appears to be offline,” press Enable Legacy LCD to switch to a previous version
of the touch panel. (See “Figure 7: Printer touch panel, Legacy LCD” on page 17.)
If Printing in progress displays, the Fiery E100 is processing. You must wait until the system
finishes and reaches the Idle state.
2. Press the Controller button to access the Tools tab.
Machine tab
Touch
Restart Server
Touch
Shut Down System
SHUTTING DOWN AND ACCESSING THE FIERY E100 FOR SERVICE 17
N OTE : If the New Version display style illustrated in the previous procedure is not working
and the message displays “The server appears to be offline,” press Enable Legacy LCD to
switch to the Legacy LCD version shown below. (For more information, see Configuration and
Setup on the User Documentation CD.)