4063
Security Settings Help
Confidential Print General Settings Print All Guides
Disk Wiping Flash Drive Menu Print Quality
Security Audit Log Print Settings Printing Guide
Set Date and Time Media Guide
Print Defects Guide
Menu Map
Information Guide
Connection Guide
Moving Guide
Supplies Guide
' Depending on the printer setup, this menu item appears as Network Setup Page or Network [x] Setup Page.
2 Depending on the printer setup, this menu item appears as Standard Network or Network (x)
Diagnostics menu
Entering the Diagnostics menu
1 Turn off the printer.
2 Press and hold 3 and 6 while turning on the printer.
Release the buttons when the splash screen appears,
REGISTRATION
‘These settings adjust the margins of the black plane.
To set the Registration:
1 Print a Quick test page.
a From the Diagnostics menu, navigate to:
REGISTRATION > Quick Test
b Retain this page to determine the changes you need to make to the margin settings. The alignment
diamonds in the margins should touch the margins of the page.
The Quick test page contains the following information:
* Printer registration settings
* Code levels
* Alignment diamonds at the top, bottom, and each side
* Horizontal lines for skew adjustment
* General printer information, including current page count, installed memory, processor speed, serial
number, engine ID, and controller board ID
2 Change the value of any of the margin settings.
Service menus
4014063
Top Margin “2510 +25 Increasing the value moves the image down the page. Always adjust
the top before the bottom margin.
Bottom Margin |-20t0 120 Increasing the value moves the image toward the top of the page.
Left Margin -25 10 425 Increasing the value moves the image toward the right margin. Always
adjust the left before the right margin,
Right Margin 15 to +15 Increasing the value moves the image toward the right of the page.
PRINT TESTS
This test determines if the printer can print on paper from any of the input trays. Each installed tray is available
within the Print Tests menu,
The content of the test page varies depending on the paper in the selected input tray.
«Ifthe selected tray contains paper, then a page similar to the Quick Test page is printed but without the print
registration diamonds information
‘Ifthe selected tray contains envelopes, then an envelope print test patter is printed. If Continuous is
selected, then the envelope print test pattern is printed on the first envelope and the rest of the envelopes
are blank.
The Print Test page always prints one-sided, regardless of the duplex setting or the presence of the duplex
option
1 Enter the Diagnostics menu, anc then select PRINT TESTS.
2 Select the paper source.
3 Select any of the following:
* Single—This option prints a single Print Test page (no buttons are active while the test page is printing).
* Continuous—This option continuously prints the Print Test page until X is pressed,
Print Quality Pages
This setting lets you view the values of a broad range of the printer settings and test the printer ability to gener
an acceptable printed output.
Enter the Diagnostics menu, and then navigate to:
PRINT TESTS >
it Quality Pages
HARDWARE TESTS
Ifthe hardware test fails, replace the failing part.
Panel Test
This test verifies the function of the control panel display.
1 Enter the Diagnostics menu, and then navigate to:
Hardware Tests > Panel Test
2 Exit the test.
Service menus
402