Professional Documents
Culture Documents
Main
body
Avionics
section
Bottom
section
Engine
section
Main Body
The connecting tube comes with an extra
“skin” that will make it thicker for a better fit
once is glued on the top of the ATV.
Building the bottom section
This photo shows the reverse side of this This line will help gluing the long rectangular
part. Use a pen and draw a line from end to strip that will be used as a support for the “aft
end, about 1 mm parallel to the edge. section enforcers”.
Putting together the Avionics, bottom and Engine sections
Cut the 4 holes
Building the drogue and docking mechanism
Use wire or copper wire 22 cm in length (8.75 inches) with a width of approximately 1
mm for the ATV 1:100 scale.
Use a thinner wire for the ATV 1:144 scale with a length of 14.8 cm.
Use glue stick when gluing both sides of the solar panels and “crazy glue” when gluing
the wire to the panels.
Enjoy this model!!
www.axmpaperspacescalemodels.com