Professional Documents
Culture Documents
LC-32SV21L
MODEL LC-42SV31L
In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its orig-
inal condition and only parts identical to those specified should be used.
CONTENTS
SAFETY PRECAUTION CHAPTER 6. BLOCK DIAGRAM/WIRING DIAGRAM
IMPORTANT SERVICE SAFETY PRECAUTION ..................2 [1] BLOCK DIAGRAM ..........................................................62
PRECAUTIONS FOR USING LEAD-FREE SOLDER ...........3 [2] WIRIGN DIAGRAM ……..................................................64
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with specified ones for maintaining the
safety and performance of the set.
1
LC-32SV21L&LC-42SV31L
SAFETY PRECAUTION
IMPORTANT SERVICE SAFETY PRECAUTION
■ Service work should be performed only by qualified service technicians who are thoroughly familiar with all safety checks and the
servicing guidelines which follow:
• Use an AC voltmeter having with 5000 ohm per volt, or higher, sen-
■ WARNING sitivity or measure the AC voltage drop across the resistor.
1. For continued safety, no modification of any circuit should be • Connect the resistor connection to all exposed metal parts having a
attempted.
return to the chassis (antenna, metal cabinet, screw heads, knobs
2. Disconnect AC power before servicing.
and control shafts, escutcheon, etc.) and measure the AC voltage
drop across the resistor.
CAUTION:
All checks must be repeated with the AC cord plug connection
FOR CONTINUED PROTECTION AGAINST A
reversed. (If necessary, a nonpolarized adaptor plug must be used
RISK OF FIRE REPLACE ONLY WITH SAME
TYPE FUSE. only for the purpose of completing these checks.)
F901/F902 (5A/250V) Any reading of 1.05 V peak (this corresponds to 0.7 mA peak AC.)
or more is excessive and indicates a potential shock hazard which
■ BEFORE RETURNING THE RECEIVER must be corrected before returning the monitor to the owner.
(Fire & Shock Hazard)
Before returning the receiver to the user, perform the following
safety checks: DVM
3. Inspect all lead dress to make certain that leads are not pinched, AC SCALE
and check that hardware is not lodged between the chassis and
1.5k ohm
other metal parts in the receiver. 10W
4. Inspect all protective devices such as non-metallic control knobs,
insulation materials, cabinet backs, adjustment and compartment
covers or shields, isolation resistor-capacitor networks, mechanical 0.15 µF
insulators, etc. TEST PROBE
5. To be sure that no shock hazard exists, check for leakage current in
the following manner.
TO EXPOSED CONNECT TO KNOWN
• Plug the AC cord directly into a 220~240 volt AC outlet. METAL PARTS
EARTH GROUND
• Using two clip leads, connect a 1.5k ohm, 10 watt resistor paralleled
by a 0.15µF capacitor in series with all exposed metal cabinet
parts and a known earth ground, such as electrical conduit or
electrical ground connected to an earth ground.
//////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////////
SAFETY NOTICE
Many electrical and mechanical parts in LCD color television have For continued protection, replacement parts must be identical to those
special safety-related characteristics. used in the original circuit.
These characteristics are often not evident from visual inspection, The use of a substitute replacement parts which do not have the same
nor. safety characteristics as the factory recommended replacement parts
can protection afforded by them be necessarily increased by using shown in this service manual, may create shock, fire or other hazards.
replacement components rated for higher voltage, wattage, etc.
Replacement parts which have these special safety characteristics
are identified in this manual; electrical components having such
2
LC-32SV21L&LC-42SV31L
PRECAUTIONS FOR USING LEAD-FREE SOLDER
■ Using lead-free wire solder
• When fixing the PWB soldered with the lead-free solder, apply lead-free wire solder. Repairing with conventional lead wire solder may cause damage or
accident due to cracks.
As the melting point of lead-free solder (Sn-Ag-Cu) is higher than the lead wire solder by 40 °C, we recommend you to use a dedicated soldering bit, if
you are not familiar with how to obtain lead-free wire solder or soldering bit, contact our service station or service branch in your area.
Soldering
• As the melting point of lead-free solder (Sn-Ag-Cu) is about 220 °C which is higher than the conventional lead solder by 40 °C, and as it has poor solder
wettability, you may be apt to keep the soldering bit in contact with the PWB for extended period of time. However, Since the land may be peeled off or
the maximum heat-resistance temperature of parts may be exceeded, remove the bit from the PWB as soon as you confirm the steady soldering
condition.
Lead-free solder contains more tin, and the end of the soldering bit may be easily corroded. Make sure to turn on and off the power of the bit as required.
If a different type of solder stays on the tip of the soldering bit, it is alloyed with lead-free solder. Clean the bit after every use of it.
When the tip of the soldering bit is blackened during use, file it with steel wool or fine sandpaper.
• Be careful when replacing parts with polarity indication on the PWB silk.
3
LC-32SV21L&LC-42SV31L
LCD Screen Size 42” Class (42” Diagonal) 32” Class (31 1/2” Diagonal)
Audio Out 8W x 8W 5W x 5W
75 ohm Unbalance,
75 ohm Unbalance,
Antenna F Type x 1 for Analog
F Type x 1 for Analog (VHF/UHF/CATV)
Cable (VHF/UHF/CATV) and Digital
and Digital (AIR/CABLE)
(AIR/CABLE)
Input 3 15-pin mini D-sub female connector 15-pin mini D-sub female connector
Rear
Input 4 HDMI in with HDCP HDMI in with HDCP
170 W 90 W
Power Consumption
(< 1 W Standby with AC 120 V) (< 1 W Standby with AC 120 V)
Dimension*1 TV + Stand 1015 x 706 x 270 (mm) 790 x 570 x 240 (mm)
(W / H / D)
TV Only 1015 x 655 x 97 (mm) 790 x 527 x 91 (mm)
• As a part of policy of continuous improvement, SHARP reserves the right to make design and specification changes for product improvement without
prior notice. The performance specification figures indicated are nominal values of production units. There may be some deviations from these values in
individual units.
4
LC-32SV21L&LC-42SV31L
[2] OPERATION MANUAL
Remote Control
• If you want to adjust the sleep timer again, you can press
this button repeatedly then change the time setting.
15
1 POWER: Switch the power on or enter standby mode. 22 MENU: Display the menu screen.
2008-03-14
5
LC-32SV21L&LC-42SV31L
TV (Front)
TV (Side/Rear)
6
LC-32SV21L&LC-42SV31L
Preparation
Supplied Accessories
Note
• Always use the AC cord supplied with the TV.
• The illustrations above are for explanation purposes and may vary slightly from the actual accessories
Note
• To attach the stand neck, perform the steps in reverse order.
• Do not over tighten the screws and install the TV set without the stand cover.
Wall Mounting
Preparation
Installing Batteries in the Remote Control Unit
1 Remove the battery compartment from the remote control.
2 Insert two "AAA" size batteries (supplied with the product).
• Place the batteries with their terminals corresponding to the (+) and (-) indications in the battery compartment.
Cautuion
Improper use of batteries can result in chemical leakage or explosion. Be sure to follow the instructions below.
• Do not mix batteries of different types. Different types of batteries have different characteristics.
• Do not mix old and new batteries. Mixing old and new batteries can shorten the life of new batteries or cause chemical leakage of old batteries.
8
LC-32SV21L&LC-42SV31L
• Remove batteries as soon as they are worn out. Chemicals that leak from batteries come in contact with skin can cause a rash. If you find any chemical
leakage, wipe thoroughly with a cloth.
• The batteries supplied with this product may have a shorter life expectancy due to storage conditions.
• If you will not be using the remote control unit for an extended period of time, remove batteries from it.
• The batteries (batteries installed) shall not be exposed to excessive heat such as sunshine, fire or the like.
2008-03-14
9
LC-32SV21L&LC-42SV31L
Appendix
Troubleshooting
Acknowledgements
The following open source software components are included in this product:
Linux kernel/Modutils/Glibc/Zlib/Libpng
10
LC-32SV21L&LC-42SV31L
[3] DIMENSIONS
2008-03-14
11
LC-32SV21L&LC-42SV31L
CHAPTER 2. REMOVING OF MAJOR PARTS
[1] ASSY/PANEL REMOVAL
LC-32SV21L
Note: Please put your mechine on soft material to avoid to scrape panel when disassembly.
Front View
Fig 1
Back View
Fig 2
Fig 3
12
LC-32SV21L&LC-42SV31L
B. Remove 4 screws as Fig 4 to detach the base _neck.
Fig 4
Fig 5
2008-03-14
13
LC-32SV21L&LC-42SV31L
Fig 6
Fig 7
14
LC-32SV21L&LC-42SV31L
Step 5. Remove the speakers(L/R).
Remove 4 screws as Fig 8 and Fig 9
Fig 8
Fig 9
Fig 10
2008-03-14
15
LC-32SV21L&LC-42SV31L
Step 7. Separate the panel and bezel.
Remove 2 screws as Fig 11
Fig 11
Fig 12
16
LC-32SV21L&LC-42SV31L
LC-42SV31L
Note: Please put your mechine on soft material to avoid to scrape panel when disassembly.
Front View
Fig 1
Back View
Fig 2
Fig 3
2008-03-14
17
LC-32SV21L&LC-42SV31L
B. Remove 4 screws as Fig 4 to detach the base _neck.
Fig 4
Fig 5
18
LC-32SV21L&LC-42SV31L
Step 3. Remove the power board.
Remove 5 screws and unplug 2 cables as Fig 6
Fig 6
2008-03-14
19
LC-32SV21L&LC-42SV31L
Step 4. Remove the scaler board.
Remove 5 screws and unplug 4 cables as Fig 7
Fig 7
Fig 8
20
LC-32SV21L&LC-42SV31L
B. Remove 15 screws as Fig 9
Fig 9
2008-03-14
21
LC-32SV21L&LC-42SV31L
Step 6. Separate the panel and bezel.
Remove 2 screws as Fig 10
Fig 10
Fig 11
22
LC-32SV21L&LC-42SV31L
[2] SET RE-ASSEMBLY
To re-assemble the whole set, execute all processes in reverse order.
Note
a. While re-assembling, make sure that all cables are placed and connected in their original position.
b. Pay special attention not to damage the EMC foams at the SSB shielding. Check that EMC foams are put
correctly on their places.
2008-03-14
23
LC-32SV21L&LC-42SV31L
24
LC-32SV21L&LC-42SV31L
Sound
On/Off
Surround
Equalizer Off/Rock/Pop/Live/Dance/Techno/Classic/Soft
Subwoofer Off/Low/Medium/High
1. if "CEC ARC Func" in factory meny is YES
=> Auto (CEC)/On/Off
Speaker
2. if "CEC ARC Func" in factory meny is NO
=> On/Off
SPIDIF Type
=> Digital Off/PCM/Dolby Digital
Output Type
Auto Volume
On/Off
Control
Wall Mount
Yes/No
Audio Setup
TV
Tuner Mode Cable/Air
Auto CH
Search
Update CH
CH Skip Channel list
Analog CH
Name Edit
Analog CH
Fine Tune
Digital CH Major
Tuning Major & Minor
Stereo
Audio Mode SAP
Mono
Main + Sub
Digital Dual
Main
Mono
Sub
Favorite
Channels
A Channel list
B Channel list
C Channel list
D Channel list
All Data Clear
GINGA
Settings
Application On/Off
Auto Startup On/Off
Application List
Network if RJ45 connector exist
Configuration
=> Network
Setup
Internet Connection On/Off
Connection Type
Wireless Setup =>
Wireless Setting
Scan Show current access point
Manual
Auto
PIN
PBC
Information
IP Setting => IP
Setup
Address Type Auto/Manual
IP Address
Subnet Mask =>
Netmask
Default Gateway
=> Gateway
Primary DNS
Secondary DNS
Connection Test
Applications
DLNA On/Off
Netflix
Deactivate
ESN
Vudu
Deactive
My Network Places On/Off
Software
Update
Setup 2008-03-14
Language
View Mode Stretch
25
LC-32SV21L&LC-42SV31L
Side bar
Smart stretch
Zoom
Dot by Dot
Automatic
DPMS On/Off
Blue Mute On/Off
DivX(R)
Registration
Time Setup
As Broadcaster/GMT+ 0:00/GMT+ 1:00/ GMT+
2:00/GMT+ 3:00/GMT+ 3:30/GMT+ 4:00/ GMT+
4:30/GMT+ 5:00/GMT+ 5:30/GMT+ 5:45/GMT+
6:00/GMT+ 6:30/GMT+ 7:00/GMT+ 8:00/GMT+
Time Zone 9:00/GMT+ 9:30/GMT+ 10:00/GMT+ 11:00/GMT+
12:00/GMT+ 12:45/GMT+ 13:00/GMT- 12:00/GMT-
11:00/GMT- 10:00/GMT- 9:00/GMT- 8:00/GMT-
7:00/GMT- 6:00/GMT- 5:00/GMT- 4:00/GMT- 3:30/GMT-
3:00/GMT- 2:00/GMT- 1:00
Time
Auto
On/Off
Synchronization
Date
Time
Power On Timer On/Once/Off
Power On
Channel
Timer
Power Off Timer On/Once/Off
Timer
Sleep Timer Off/10/20/30/40/50/60/90/120 Minutes
Auto Sleep Off/1/2/5 Hours
Caption Setup
Caption Off/On/On-Mute
Analog Closed
CC1/CC2/CC3/CC4/TEXT1/TEXT2/TEXT3/TEXT4
Caption
Digital Closed
Language 1 - 8
Caption
Superimpose Setup Off/Language1/Language2
Digital Caption Style
Caption Style As Broadcaster/Custom
Font Size Large/Small/Medium
Font Style Style1-3
Font Color Black/White/Green/Blue/Red/Cyan/Yellow/Magenta
Font Opacity Solid/Translucent/Transparent
Background Color Black/White/Green/Blue/Red/Cyan/Yellow/Magenta
Background
Solid/Translucent/Transparent
Opacity
Window Color Black/White/Green/Blue/Red/Cyan/Yellow/Magenta
Window Opacity Solid/Translucent/Transparent
Location Store/Home
DCR Demo Off/On
Input Label Input list
Program Title
Yes/No
Display
FAV APP Key
Assign
APP 1 Netflix/USB Media/Home Network
APP 2 Netflix/USB Media/Home Network
APP 3 Netflix/USB Media/Home Network
Reset
Icon Light Up
Off/On
Setting
Demo Mode
Demo Mode Select Connected TV/Feature Demo/Auto Play
Auto Play Setting Continuous/10 min./20 min.
Power Control
Audio Only Off/On
No Signal Off Enable/Disable
Power Saving Off/On
No Operation Off Enable/Disable
No Operation To
Off/1/2/4 Hours
Sleep
Version Info
Reset
Parental
Password
Channel Block Channel list
Digital Rating
Program Block
Rating Enable On/Off
U.S. TV Ratings None/TV-Y/TV-Y7/TV-G/TV-PG/TV-14/TV-MA
U.S. Movie Ratings None/G/PG/PG-13/R/NC-17/X
26
LC-32SV21L&LC-42SV31L
Canadian English
E/C/C8+/G/PG/14+/18+
Ratings
Canadian French
E/G/8 ans+/13 ans+/16 ans+/18 ans+
Ratings
Age Rating Off/Below 10/Below 12/ Below 14/Below 16/Below 18
Off/Drugs/Violence/Sex/Violence & Drugs/Sex &
Content Rating
Drugs/Violence & Sex/Violence, Sex & Drugs
Input Block Input list
Change
Password
New Password
Confirm Password
Clean All
USB
Multi-Media
Option
DivX(R)
Registration
DivX(R)
Deactivation
CEC Setup
CEC Function On/Off
Auto Turn Off On/Off
Multi-Media
2008-03-14
27
LC-32SV21L&LC-42SV31L
2. ADC Adjustment and White Balance Adjustment
It’s no need to do the white balance for this model, do ADC only.
1. Turn on the TV, press “Menu”, then press number key 1 + 9 + 9 + 9 and “RETURN”, it will achieve the factory mode. Select the item of Current source
and press right key to choose computer
2. Select the item of WD Pat, choose 80(80IRE), fix the item of Scalar G Gain, adjust the item of Scalar R B Gain, choose Color temp. and press right key
to continue adjustment; Choose 20(20IRE), fix the item of Scalar G Offset, adjust the item of Scalar R B Offset, choose Color temp. and press right key to
continue adjustment.
Color Temp.
Normal Warm Cool
x (center) 0.2850 ± 0.0090 0.3130 ± 0.0090 0.2740 ± 0.0090
y (center) 0.2930 ± 0.0090 0.3210 ± 0.0090 0.2740 ± 0.0090
28
LC-32SV21L&LC-42SV31L
[2] SOFTWARE UPGRADE PROCEDURE
FW Upgrade
Take LC-32SV21L for example
Step 1: Ready for F/W Upgrade
1.1 Change the software file name to ” upgrade.pkg” ,eg:
After change:
1.2 Prepare a USB memory (The file system of USB memory must be FAT16 or FAT 32).
1.3 Copy the file (upgrade.pkg) from your computer to the USB memory root directory, and remove it from computer’s USB port!
Note: 1) Note the version of this F/W before you change the software file name.
2) The software file name must be changed, or TV can’t detect the F/W.
2008-03-14
29
LC-32SV21L&LC-42SV31L
30
LC-32SV21L&LC-42SV31L
The Writing VGA & HDMI EDID
Take other model for example
Step1. Ready for writing EDID
Tool: 715G089-B/C
Cable: a USB cable, a VGA cable, and a DVI to HDMI cable.
2008-03-14
31
LC-32SV21L&LC-42SV31L
Step2. Connection for VGA EDID writing and turn on the TV
Connect to TV
VGA port by
VGA cable.
Connect to PC
USB port by USB
cable.
1. Double click this icon to install. 2. Double click this icon to run.
32
LC-32SV21L&LC-42SV31L
3.2 Select “FtdiUSB” communication type. And test the EDID.
2008-03-14
33
LC-32SV21L&LC-42SV31L
3.4 Click “Read EDID”.
Step4. Click “FPD” to open another interface as follows to check the whether the info is the same as you loaded previously.
34
LC-32SV21L&LC-42SV31L
Step5. When the tool displays “NG” in the yellow blank, which represent writing failly. Please check the whether the connection of tool and cables is nomal
and retry. Another way is to change a new ISP board and retry.
Connect to PC
USB port by USB
cable.
2008-03-14
35
LC-32SV21L&LC-42SV31L
2. Because the TV has three HDMI ports, please connect the “DVI to HDMI” cable to corresponding HDMI port and load correct EDID file one by one.
HDMI one.
3. The other steps are the same as VGA EDID writing. Please refer to the above steps to write EDID for HDMI port.( HDMI2, written steps are the same
with HDMI1)
36
LC-32SV21L&LC-42SV31L
LINE_FILTER_UNIT: ↓ YES
Is F901/F902 normal? LINE_FILTER_UNIT:
Isn't NR901,IC901,L9901,L9902,etc. out of order? Moreover,
whether the short-circuit with the circumference circuit is
NO checked.
POWER_UNIT:
BD901, FB9902, D9802, etc. out of order?
Moreover, whether the short-circuit with the circumference circuit
is checked.
POWER_UNIT ↓YES
Is C9801(for 32″)/C9824(for 42″) (+390V) output? (Set the main NO Does the PFC circuit operate normally?
(IC9801, Q9801, L9801(for 32″)/L9804(for 42″) and etc. And, the
power SW to ON.) circuit around the protection circuit etc. is checked.)
↓YES
Is a voltage of +5V applied to pin (12,13) of connector (CN902)? NO Does the switching circuit operate normally?
(Set the main power SW to ON.) Check circuit around the primary side (IC9301, T9301,
D9335,etc.), the secondary side (D9350, L9350, ZD9301, etc.),
and the protection circuit.
↓YES
Are 12 and 24V output as for the power on/off switch when it is on? Does the inverter circuit operate normally?
NO Check circuit around the primary side (T9101, Q9101, Q9102,
etc.), the secondary side (D9151, D9153, D9152(for 42″) etc.),
and the protection circuit.
The sound is not emitted from the speaker though the picture has come out.
↓
No sound output in all modes?
TERMINAL UNIT: ↓
Is the audio signal output of IC U401 normal? NO Check IC U401 and its peripheral circuits.
↓YES
Is audio signal input to pin (27/28/29/30) of IC U602 (AMP)? NO Check the line between IC U401 and IC U602.
↓YES
Is MUTE circuit [AMP_MUTE_LINE, POWERUP_LINE] normal? NO Check the AMP_MUTE_LINE and POWERUP_LINE. (Q605,
Q610 etc.)
↓YES
Is the audio signal output of pin (1,2) (R) and pin (3,4) (L) of NO Check IC U602 and its peripheral circuits.
CN601(AOUDIO-CONNECTOR) normal?
↓YES
Check Speaker (right and left) and wire harness.
2008-03-14
37
LC-32SV21L&LC-42SV31L
↓YES
NO
Is the IF signal sent to pin (AD17/AE17) of IC U401? Check IC U401 its peripheral circuits.
↓YES
Refer to “No sound output in all modes”.
↓YES
Is the audio signal properly sent to pin (AC20) (YPbPr_L_In) and Check the line between CN111 and IC U401.
pin (AE23) (YPbPr_R_In) of IC U401? NO
↓YES
Refer to “No sound output in all modes”.
↓YES
Is the audio signal properly sent to pin (AC21) (AV2_L_In) and pin NO Check the line between CN128 and IC U401.
(AE24) (AV2_R_In) of IC U401?
↓YES
Refer to “No sound output in all modes”.
38
LC-32SV21L&LC-42SV31L
↓YES
Is the audio signal properly sent to pin (AD22) (VGA_L_In) and pin NO Check the line between CN102 and IC U401.
(AC25) (VGA R In) of IC U401?
↓YES
Refer to “No sound output in all modes”.
↓YES
Refer to “No sound output in all modes”.
↓NO
YES Check IC U401 and its peripheral control circuits.
Is the above-mentioned LVDS signals output to connector NO
CN409(for32″), CN408(for 42″)?
Check the line between IC U401 and CN409, CN408.
↓YES
Is LCD controller's control signal normal? Control signals BRIGHT_ADJ, INVERTER_ON_OFF,
NO PANEL_VCC_ON/OFF, and it peels off and whether normality is
checked.
PANEL_UNIT: ↓YES
Similarly, is the LVDS signal input to connector of the panel NO Wire harness is checked. (Main board to Panel module )
module?
↓YES
Check the panel module.
2008-03-14
39
LC-32SV21L&LC-42SV31L
MAIN_UNIT: ↓YES
Is picture signal input from pin TUNER (TU101) to IC U401? NO Check the line between IC U401 and TU101.
↓YES
↓YES
Is IF signal output from pin (1/2/4/5) of TUNER (TU101) to pin NO Check the tuner, IC U401 and their peripheral circuits. Replace
(AD17/AE17) of IC U401? as required.
MAIN_UNIT: ↓YES
Do X400 (27MHz) oscillate? NO Check X400 and its peripheral circuits.
↓YES
Is Component Y/Pb/Pr signal sent to pin (2)/Y, (4)/Pb, (6)/Pr of NO Check the setting of an external input device that connects of
AV1(CN111) ? CN111.
MAIN_UNIT: ↓YES
Is Component Y/Pb/Pr signal sent to pin (AB13)/Y, (AB14)/Pb, NO Check the line between IC U401 and CN111
(AC14)/Pr of IC U401?
↓YES
Refer to “The picture doesn't appear in all modes.”
40
LC-32SV21L&LC-42SV31L
MAIN_UNIT: ↓YES
NO
Is CVBS signal sent to pin (A17) of IC U401? Check the line between IC U401 and CN128.
↓YES
↓NO
Check the connection and setup with the external HDMI devices.
YES
Is TMDS signal input into pin ((41,42)/( RR1X0), (44,45)/( RR1X1), NO Check the line between IC U501 and CN502.
(47,48)/( RR1X2), (38,39)/( RR1XC)) of IC U501?
↓YES
Is TMDS signal output from pin ((1/2/4/5/7/8/10/11)/(M_RX1) of IC NO Check IC U501 and peripheral circuits.
U501?
↓YES
Refer to “The picture doesn't appear in all modes.”
↓NO
Check the connection and setup with the external HDMI devices.
YES
Is TMDS signal input into pin ((21,22)/(RR0X0), (24,25)/(RR0X1), NO Check the line between IC U501 and CN503.
(27,28)/(RR0X2), (18,19)/(RR0XC)) of IC U501?
↓YES
Is TMDS signal output from pin ((1/2/4/5/7/8/10/11)/(M_RX1) of IC NO Check IC U501 and peripheral circuits.
U501?
↓YES
Refer to “The picture doesn't appear in all modes.”
2008-03-14
41
LC-32SV21L&LC-42SV31L
MAIN_UNIT: ↓YES
Is R/G/B/H/V signal sent to pin (AC10)/R, (AC9)/G, (AD9)/B, NO Check the line between IC U401 and CN101.
(W12)/H, (W11)/V of IC U401?
↓YES
42
LC-32SV21L&LC-42SV31L
CHAPTER 5. MAJOR IC INFORMATIONS
[1] MAJOR IC INFORMATION
2.1 U401(MT5366RVNG)
General Description
The MediaTek MT5365/66 family is a backend decoder and a TV controller and offers high integration for advanced applications. It combines a transport
de-multiplexer, a high definition video decoder, an AC3 audio decoder, a dual-link LVDS/mini-LVDS transmitter, and an NTSC/PAL/SECAM TV decoder
with a 3D comb filter (NTSC/PAL). The MT5365/66 enables consumer electronics manufactures to build high quality, low cost and feature-rich DTV.
World-Leading Audio/Video Technology: The MT5365/66 supports Full-HD MPEG1/2/4/DiviX/VC1/RM/H.264/AVS video decoder standards, and JPEG.
The MT5365/66 also supports MediaTek MDDiTM de-interlace solution can reach very smooth picture quality for motions. A 3D comb filter added to the
TV decoder recovers great details for still pictures. The special color processing technology provides natural, deep colors and true studio quality video.
Also, the MT5365/66 family has built-in high resolution and high-quality audio codec.
Rich Features for High Value Products: The MT5365/66 family enables true singlechip experience. It integrates high-quality HDMI1.3 (partial HDMI1.4),
high speed VGA ADC, dual-channel LVDS, USB2.0 receiver, Ethernet, TCON and panel overdrive.
Key Features
1. Worldwide multi-standard analog TV demodulator
2. A transport demultiplexer
3. A muti-standard video decoder
4. An AC3/MPEG2 audio decoder
5. HDMI1.3 receiver (cover HDMI1.4 partial Spec)
6. Audio codec
7. TCON
8. Ethernet
9. Panel overdrive control
10. Local dimming
General Features
Host CPU
ARM1176JZS-756MHz
16K I-Cache and 16K D-Cache
14K Boot ROM
JTAG ICE interface
Watch Dog timers
Transport Demultiplexer
New generation 2 demux design
Supports two serial transport stream input with one serial transport stream output, or one parallel transport stream input
Supports ATSC, DVB-T, DVB-C transport stream input
Support DES / 3-DES / DVB / AES / Multi-2 de-scramblers
Up to 8 even/odd keys for descrambling
Supports 32 PID filters and 32 section filters
Supports 32 PID filters for recording
Supports hardware CRC-32 check
Supports PCR recovery function
2008-03-14
Supports a micro-processor for stream process and video start code detection
43
LC-32SV21L&LC-42SV31L
MPEG2 Decoder
MPEG MP@ML, MP@HL
Supports de-blocking filter
MPEG1 Decoder
MPEG4 Decoder
ASP@L5
H.264 (MPEG4.10) HD Decoder (AVC)
MP@L4.0, HP@L4.0, constrained BP@L3 video standard
VC-1 (SMPTE421M)
MP@HL, AP@L3(Partial Support, support up to 1920x1080)
WMV9 decoder MP@HL
DivX (XviD) Decoder
DIVX3 / DIVX4 / DIVX5 / DIVX6 / DIVX HD
AVS Decoder
Jizhun profile @Level 6.0.1
RMVB Decoder
RealVideo8/9/10
Soreson H.263
Still Image decoding
JPEG (base-line or progressive)
De-mosquito engine
2D/3D for all AV inputs
2D Graphics
Supports multiple color modes
Point, horizontal/vertical line primitive drawings
Rectangle fill and gradient fill functions
Bitblt with transparent options
Alpha blending and optional pre-multiplied alpha composition Bitblt.
Stretch Bitblt
YCbCr to RGB color space conversion
Support index to direct mode bitblt
Image Resizer
Supports 16bpp/32bpp direct color format.
Supports 420/422 video format.
Supports 420/422/444 JPEG format.
Arbitrary ratio vertical/horizontal scaling of video, from 1/128X to 128X
Simple DMA.
OSD Plane
Three linking list OSDs with multiple color mode and two of them has up-scaler
Video Plane
Supports video freeze and over scan.
Flesh tone management
Gamma correction
Color Transient Improvement (CTI)
2D Peaking
Saturation/hue adjustment
Brightness and contrast adjustment
Black and White level extender
Adaptive Luma management
Automatic detect video, film and mixed-mode source
3:2/2:2 pull down source detection
44
LC-32SV21L&LC-42SV31L
Supports FHD motion-adaptive de-interlace in 32bit dram interface
Supports excellent low angle image processing
Brilliant boundary shaping for moving object
Advanced non-linear panorama scaling.
Programmable zoom viewer
Progressive scan output
Supports alpha blending for OSD on video plane.
Dithering processing for flat panel display
Frame rate conversion.
Supports FHD panel and VGA dot-to-dot
Supports PIP/POP, (dual de-interlace, one HD and one SD)
OD
Support 60Hz Full-HD and WXGA panel over drive.
TCON
Flexible timing control with programmable timing
i. Horizontal timing control
ii. Vertical timing control
iii. Multi-line timing control
iv. Multi-frame timing control
Support gate power modulation timing
Support 1/2/4/8 frame inversion, 1-line inversion, 2-line inversion, and could up to 255-line dot inversion
Local Dimming
Block division: up to 800 total blocks, up to 100 horizontal blocks
Support 50K ~ 50M SPI clock rate
LVDS
Support 6/8/10/12-bit one-link, or 6/8/10-bit dual-link LVDS transmitter,
Built-in spread spectrum for EMI performance
Programmable panel timing output
Mini-LVDS
Single port 6/8-bit 6 pairs mini-LVDS output for WXGA 60Hz panel
Single port 6/8-bit 3 pairs mini-LVDS output for WXGA 60Hz panel
Dual port 6/8-bit 3 pairs mini-LVDS output for WXGA 60Hz panel
Single port 8bit 6 pairs mini-LVDS output for FHD 60Hz panel
Dual port 8 bit 6 pair mini-LVDS output for FHD 60Hz panel
Dual port 8bit 3 pairs mini-LVDS output for FHD 60Hz panel
CVBS In
On-chip 54 MHz 10-bit video ADC
Supports PAL (B,G,D,H,M,N,I,Nc), NTSC, NTSC-4.43, SECAM
NTSC/PAL supports 3D/2D comb filter
Built-in motion-adaptive 3D Noise Reduction
VBI data slicer for CC/TT decoding
Supports 2 S-Video.
MT5366RVNG support 3-channel CVBS. MT5365 support 2-channel CVBS.
Supports SCART connector
VGA In
Supports VGA input up to UXGA 162 MHz
Supports full VESA standards
Component Video In
Supports two component video inputs
2008-03-14
Supports 480i / 480p / 576i / 576p / 720p / 1080i / 1080p
45
LC-32SV21L&LC-42SV31L
Audio ADC
MT5366RVNG support 7-pair L/R input, MT5365 support 1-pair L/R input
Audio digital input
MT5366RVNG support 5 bit (10 channel) I2S audio input (muxed with GPIO), MT5365 support 2 bit (4 channel) I2S audio input (muxed with GPIO).
HDMI Receiver
One channel HDMI1.4
v. Maximum data rate can be up to 3.3 GHz
vi. Support 3D video format
vii. Audio Return channel
EIA/CEA-861B
CEC
Video bypass
TV bypass
CVBS Monitor (any AV input)
TV audio demodulator
Supports BTSC / EIA-J / A2 / NICAM / PAL FM / SECAM world-wide formats
Standard automatic detection
Stereo demodulation, SAP demodulation
Mode selection (Main/SAP/Stereo)
Audio DAC
MT5366RVNG support 4-pair audio DACs, MT5365 support 2-pair audio DACs
DRAM Controller
16/32-bit DDR2/DDR3 interface, (MT5365 only support 16-bit DRAM)
MT5365 Support DDR2 1026 MHz, DDR3 1188MHz. MT5366RVNG Support DDR2 1026MHz, DDR3 1242MHz.
Supports 512Mb or 1 Gb DDR2 DRAM device and 1Gb or 2Gb DDR3 device. MT5365 has 16-bit data bus offers up to 256MB space (one x16 DRAM
device), and MT5366RVNG has 32-bit data bus offers up to 512MB space (two x16 DRAM device).
Supports DDR2-800/DDR2-1066/DDR3-1333/DDR3-1600 device
Audio DSP
Supports Dolby Digital AC-3 decoding (ATSC)
MPEG-1 layer I/II decoding
Support WMA / HE-AAC
Dolby Prologic II
Audio output: 5.1ch + 2ch (down mix) + 2ch(bypass)
Pink noise and white noise generator
Equalizer
Bass management
3D surround processing with virtual surround
Audio and video lip synchronization
Supports bass/treble
Automatic volume control
MT5366RVNG supports 5-bit (10-channel) main audio I2S output interface, MT5365 support 2-bit (4-channel) main audio I2S output interface: each of
these channels is up to 24-bit resolution.
S/PDIF interface
Support SPDIF in bypass
One SPDIF out
Analog TV IF Demodulator
Supports world-wide analog TV standard
Accept Low IF frequency
Full digital AGC control and carrier recovery
Embedded SAW filter and IF Amplifier. Cost effective TV front-end structure and no more costs on
viii. External analog SAW filters (Video/Audio)
46
LC-32SV21L&LC-42SV31L
ix. External analog IF demodulator
x. Extra peripheral circuit on CVBS signal data path
xi. External SAW filter and IF VGA on tuner
Peripherals
MT5366RVNG support three built-in UARTs with Tx and Rx FIFO, MT5365 support two UART (one is muxed with GPIO).
MT5366RVNG support MII/RMII interface (built-in Ethernet MAC), MT5365 support RMII only.
Seven basic serial interfaces; one is for the tuner, one is the master for general purpose, and one is the slave for VGA DDC, the other four extra slave
serial interfaces used for HDMI EDID data (three are muxed with GPIO).
MT5366RVNG support three PWMs, MT5365 support two PWMs (one is muxed with GPIO).
IR receiver
Real-time clock and watchdog controller
Built-in 2-link USB2.0/1.1,USB port0 supports external hub,
Built-in uP for standby mode
Support SDIO interface pin muxed with smart card
Supports two serial flash or one serial and one NAND flash
MT5366RVNG supports six-input low-speed ADC, MT5365 support five-input low-speed ADC.
Supports boundary scan (JTAG)
IC Outline
The MT5366RVNG is 21x21mm PBGA Package, MT5365 is 256-pin LQFP package with EPAD
3.3V/1.12V/1.2V and 1.8V for DDR2 or 1.5V for DDR3
2.2 U703(AT1529F11U)
General Description
The AT1529 high-efficiency, DC/DC buck converter delivers up to 3.2A of output current. The device operates from an input voltage of 2.5V to 6V and
provides an output voltage from 0.8V to VIN, making the AT1529 ideal for on-board post-regulation applications.
The AT1529 operate at a fixed frequency of 1MHz with an efficiency of up to 94%. The high operating frequency minimizes the size of external
components. Internal soft-start control circuitry reduces inrush current. Short-circuit and thermal-overload protections improve design reliability.
The AT1529 are available in a space-saving SOP-8 and TDFN3X3-8 package.
Features
Ceramic Input and Output Capacitors
Efficiency Up to 94%
Operate from 2.5V to 6V supply
Adjustable Output from 0.8V to VIN
Internal Soft-Start
Short-Circuit and Thermal-Overload Protection
Input Over Voltage Protection
RoHS Compliant
Applications
ASIC/DSP/µP/FPGA Core and I/O Voltages
Set-Top Boxes
Cellular Base Stations
Networking and Telecommunications
2.3 U602(STA339BWTR)
General Description
The STA339BW is an integrated solution of digital audio processing, digital amplifier control, and FFX-power output stage, thereby creating a high-power
single-chip FFX® solution comprising high-quality, high-efficiency, all digital amplification.
STA339BW is based on FFX (fully flexible amplification) processor, a STMicroelectronics proprietary technology. FFX is the evolution and the enlargement
2008-03-14
of the ST ternary technology: the new processor can be configured to work in ternary, binary, binary differential and phase shift PWM modulation schemes.
STA339BW contains the ternary, binary and binary differential implementations, a subset of the full capability of the FFX processor.
47
LC-32SV21L&LC-42SV31L
The STA339BW is part of the Sound Terminal™ family that provides full digital audio streaming to the speaker, offering cost effectiveness, low power
dissipation and sound enrichment.
The STA339BW power section consists of four independent half-bridges. These can be configured via digital control to operate in different modes. 2.1
channels can be provided by two half-bridges and a single full-bridge, providing up to 2 x 9 W + 1 x 20 W of power output. Two channels can be provided
by two full-bridges, providing up to 2 x 20 W of power. The IC can also be configured as 2.1 channels with 2 x 20 W provided by the device and external
power for FFX power drive.
Also provided in the STA339BW are a full assortment of digital processing features. This includes up to 8 programmable 28-bit biquads (EQ) per channel
and bass/treble tone control. Available presets enable a time-to-market advantage by substantially reducing the amount of software development needed
for certain functions. This includes audio preset volume loudness, preset volume curves and preset EQ settings. There are also new advanced AM radio
interference reduction modes. Dual band DRC dynamically equalizes the system to provide speaker linear frequency response regardless output power
level. This feature independently processes the two bands, controlling, dynamically, the output power level in each band and so providing a better sound
quality.
The serial audio data input interface accepts all possible formats, including the popular I2S format. Three channels of FFX processing are provided. This
high-quality conversion from PCM audio to FFX PWM switching waveform provides over 100 dB SNR and dynamic range.
Features
■ Wide voltage supply range
– 5 V to 26 V (operating range)
– 30 V (absolute maximum rating)
■ 3 power output configurations
– 2 channels of ternary PWM (stereo mode) (2 x 20 W into 8 Ω at 18 V)
– 3 channels - left, right using binary and LFE using ternary PWM (2.1 mode) (2 x 9 W + 1 x 20W into 2 x 4 Ω, 1 x 8 Ω at 18 V)
– 2 channels of ternary PWM (2 x 20 W) + stereo lineout ternary
■ 2.1 channels of 24-bit FFX®100 dB SNR and dynamic range
■ Selectable 32 to 192 kHz input sample rates
■ I2C control with selectable device address
■ Digital gain/attenuation +48 dB to -80 dB with 0.5 dB/step resolution
■ Soft volume update with programmable ratio
■ Individual channel and master gain/attenuation
■ Two independent DRC configurable as a dualband anti-clipper (B2DRC) or independent limiters/compressors
■ EQ-DRC for DRC based on filtered signals
■ Dedicated LFE processing for bass boosting with 0.5 dB/step resolution
■ Audio presets:
– 15 preset crossover filters
– 5 preset anti-clipping modes
– Preset night-time listening mode
■ Individual channel and master soft/hard mute.
■ Independent channel volume and DSP bypass
■ Automatic zero-detect mute
■ Automatic invalid input-detect mute
■ 2-channel I2S input data interface
■ Input and output channel mapping
■ Up to 8 user-programmable biquads per channel with 28-bit resolution
■ 3 coefficients banks for EQ presets storing with fast recall via I2C interface
■ Bass/treble tones and de-emphasis control
■ Selectable high-pass filter for DC blocking
■ Advanced AM interference frequency switching and noise suppression modes
■ Selectable high- or low-bandwidth noise-shaping topologies
■ Variable max power correction for lower full-power THD
■ Selectable clock input ratio
■ 96 kHz internal processing sample rate, 24 to 28-bit precision
48
LC-32SV21L&LC-42SV31L
■ Thermal overload and short-circuit protection embedded
■ Video apps: 576 x Fs input mode supported
■ Fully compatible with STA339BWS.
2.4 U501(SiI9185ACTU)
General Description
Features
2008-03-14
49
LC-32SV21L&LC-42SV31L
2.5 U606(MAX9728AETC+)
General Description
The MAX9728A/MAX9728B stereo headphone amplifiers are designed for display and notebook applications or portable equipment where board space is
at a premium. These devices use a unique, patented DirectDrive™ architecture to produce a ground-referenced output from a single supply, eliminating
the need for large DC-blocking capacitors, saving cost, board space, and component height. The MAX9728A offers an externally adjustable gain, while the
MAX9728B has an internally preset gain of -1.5V/V. The MAX9728A/MAX9728B deliver up to 60mW per channel into a 32Ω load and have low 0.02%
THD+N. An 80dB at 1kHz power-supply rejection ratio (PSRR) allows these devices to operate from noisy digital supplies without an additional linear
regulator. Comprehensive clickand-pop circuitry suppresses audible clicks and pops on startup and shutdown.
The MAX9728A/MAX9728B operate from a single 4.5V to 5.5V supply, consume only 3.5mA of supply current, feature short-circuit and thermal-overload
protection, and are specified over the extended -40°C to +85°C temperature range. The devices are available in tiny 12-pin Thin QFN (3mm x 3mm x
0.8mm) and 14-pin TSSOP packages (5mm x 4.4mm x 1.1mm).
Features
♦ No Bulky DC-Blocking Capacitors Required
♦ Low-Power Shutdown Mode, < 0.1µA
♦ Adjustable Gain (MAX9728A) or Fixed -1.5V/V Gain (MAX9728B)
♦ Low 0.02% THD+N
♦ High PSRR (80dB at 1kHz) Eliminates LDO
♦ Integrated Click-and-Pop Suppression
♦ 4.5V to 5.5V Single-Supply Operation
♦ Low Quiescent Current (3.5mA)
♦ Available in Space-Saving Packages
12-Pin Thin QFN (3mm x 3mm x 0.8mm)
14-Pin TSSOP (5mm x 4.4mm x 1.1mm)
Applications
Notebook PCs
DVD Players
LCD/PDP Displays
CRT TVs
Multimedia Monitors
2.6 U116(MAX3232ECPWR)
General Description
The MAX3232E device consists of two line drivers, two line receivers, and a dual charge-pump circuit with ±15-kV IEC ESD protection pin to pin (serial-
port connection pins, including GND). The device meets the requirements of TIA/EIA-232-F and provides the electrical interface between an asynchronous
communication controller and the serial-port connector. The charge pump and four small external capacitors allow operation from a single 3-V to 5.5-V
supply. The devices operate at data signaling rates up to 250 kbit/s and a maximum of 30-V/ms driver output slew rate.
Features
· ESD Protection for RS-232 Bus Pins
– ±15 kV (HBM)
– ±8 kV (IEC61000-4-2, Contact Discharge)
– ±15 kV (IEC61000-4-2, Air-Gap Discharge)
· Meets or Exceeds the Requirements of TIA/EIA-232-F and ITU v.28 Standards
· Operates With 3-V to 5.5-V VCC Supply
· Operates up to 250 kbit/s
· Two Drivers and Two Receivers
· Low Supply Current . . . 300 mA Typ
· External Capacitors . . . 4 ´ 0.1 mF
· Accepts 5-V Logic Input With 3.3-V Supply
· Pin Compatible to Alternative High-Speed Device (1 Mbit/s)
– SNx5C3232
50
LC-32SV21L&LC-42SV31L
Applications
· Battery-Powered Systems
· PDAs
· Notebooks
· Laptops
· Palmtop PCs
· Hand-Held Equipment
2.7 U406(CXD2828ER)
General Description
The Sony CXD2828ER is an ISDB-T and SBTVD-T demodulator that conforms to the ARIB STD-B31 standards. It receives signal from the tuner and
outputs signal in TS format after demodulation.
Features
・ All internal clocks derived from signal fixed 41MHz/20.5MHz frequency crystal (<±100ppm).
・ High performance differential ADC
・ Fast 400kHz I2C compatible bus interface
・ Gateway I2C interface for dedicated tuner control
・ Automatic IF AGC and optional programmable GPIO interface
・ Configurable parallel and serial MPEG-2 TS outputs
・ Built-in de-interleave memory(No external memory required)
・ 3.3V, 2.5V, 1.2V supplies
・ Temperature range -20 to +85℃
・ 48 pin VQFN 7mm x 7mm package (0.5mm pin pitch)
・ Very low operating power consumption (Clear channel)
ISDB-T:180mW (typ.)
・ Power standby mode (Shutdown: Clock stop mode)
Sleep:25mW(typ.)
Shutdown:under 1mW(typ.)
Features ISDB-T
・ Conforms to ARIB STD-B31
・ Supports Low-IF, 57MHz-IF tuner.
・ Excellent phase noise resistance
・ Excellent multipath equalization performance
・ Automatic detection of mode/guard internal lengths.
・ EWS (Emergency Warning System) flag output
・ Read function of AC Carrier information corresponding to the earthquake broadcasting. (ARIB STD-B31 v1.8)
Applications
・ Set Top boxes
・ PC TV
・ PVRs and recordable DVD players
2.8 U407(M24C02)
General Description
These I²C-compatible electrically erasable programmable memory (EEPROM) devices are organized as 2048/1024/512/256/128 x 8 (M24C16, M24C08,
M24C04, M24C02 and M24C01).
In order to meet environmental requirements, ST offers these devices in ECOPACK® packages. ECOPACK® packages are Lead-free and RoHS
compliant.
2008-03-14
ECOPACK is an ST trademark. ECOPACK specifications are available at: www.st.com.
I²C uses a two-wire serial interface, comprising a bidirectional data line and a clock line. The devices carry a built-in 4-bit Device Type Identifier code (1010)
51
LC-32SV21L&LC-42SV31L
in accordance with the I²C bus definition.
The device behaves as a slave in the I²C protocol, with all memory operations synchronized by the serial clock. Read and Write operations are initiated by
a Start condition, generated by the bus master. The Start condition is followed by a device select code and Read/Write bit (RW), terminated by an
acknowledge bit.
When writing data to the memory, the device inserts an acknowledge bit during the 9th bit time, following the bus master’s 8-bit transmission. When data is
read by the bus master, the bus master acknowledges the receipt of the data byte in the same way. Data transfers are terminated by a Stop condition after
an Ack for Write, and after a NoAck for Read.
Features
■ Two-wire I²C serial interface Supports 400 kHz protocol
■ Single supply voltage:
– 2.5 V to 5.5 V for M24Cxx-W
– 1.8 V to 5.5 V for M24Cxx-R
– 1.7 V to 5.5 V for M24Cxx-F
■ Write Control input
■ Byte and Page Write (up to 16 bytes)
■ Random and Sequential Read modes
■ Self-timed programming cycle
■ Automatic address incrementing
■ Enhanced ESD/latch-up protection
■ More than 1 million write cycles
■ More than 40-year data retention
■ Packages
– ECOPACK® (RoHS compliant)
2.9 U409(M24C32)
General Description
2
These I C-compatible electrically erasable programmable memory (EEPROM) devices are organized as 8192x8 bits (M24C64) and 4096x8 bits (M24C32),
and operate down to 2.5 V (for the –W version of each device), and down to 1.8 V (for the -S version of each device).
The M24C64 and M24C32 are available in Plastic Dual-in-Line, Plastic Small Outline and Thin Shrink Small Outline packages.
Features
Compatible with I2C Extended Addressing
Two Wire I2C Serial Interface Supports 400 kHz Protocol
Single Supply Voltage:
– 4.5V to 5.5V for M24Cxx
– 2.5V to 5.5V for M24Cxx-W
– 1.8V to 3.6V for M24Cxx-S
Hardware Write Control
BYTE and PAGE WRITE (up to 32 Bytes)
RANDOM and SEQUENTIAL READ Modes
Self-Timed Programming Cycle
Automatic Address Incrementing
Enhanced ESD/Latch-Up Behavior
More than 1 Million Erase/Write Cycles
More than 40 Year Data Retention
52
LC-32SV21L&LC-42SV31L
[2] DETAILED ICS INFORMATION
3.1 U401(MT5366RVNG)
Block Diagram
2008-03-14
53
LC-32SV21L&LC-42SV31L
Pin Connections and Short Description
54
LC-32SV21L&LC-42SV31L
2008-03-14
55
LC-32SV21L&LC-42SV31L
3.2 U703 (AT1529F11U)
Block Diagram
56
LC-32SV21L&LC-42SV31L
3.3 U602(STA339BWTR)
Block Diagram
2008-03-14
57
LC-32SV21L&LC-42SV31L
3.4 U501(SiI9185ACTU)
Block Diagram
58
LC-32SV21L&LC-42SV31L
3.5 U606(MAX9728AETC+)
Block Diagram
3.6 U116(MAX3232ECPWR)
Pin Connections and Short Description
2008-03-14
59
LC-32SV21L&LC-42SV31L
3.7 U406(CXD2828ER)
Block Diagram
60
LC-32SV21L&LC-42SV31L
3.8 U407(M24C02)
Pin Connections and short description
3.9 U409(M24C32)
Pin Connections and Short Description
DIP Connections SO and TSSOP Connections
2008-03-14
61
LC-32SV21L&LC-42SV31L
62
LC-32SV21L&LC-42SV31L
2008-03-14
63
LC-32SV21L&LC-42SV31L
[2] WIRING DIAGRAM
LC-32SV21L
095G176J30NM03
095G 82513XM04
095G 82513XM03
095G8013 4XM16
CN407
095G801413XM21
CN016
CN001
64
LC-32SV21L&LC-42SV31L
LC-42SV31L
095G801851XM26
095G 82513XM02
CN903 CN902 095G 82513XM05
CN601 CN701
095G801413XM22
CN407
CN016
CN001
2008-03-14
65
LC-32SV21L&LC-42SV31L
CN601 CN701
X3
X1
X4 SCREW1
C481 X2
R271 R270
R263 R264
C651 C662 R17
C1149
C1148
C1147
C647
FB701
FB704
C705
R706
R705
CN409
R14
RP262
C655 C658 C664
R267
R283
FB267
C650 C659
Q403 Q404
R262
R282
R4002
R4005
R273
FB266
C490
L63 L64 L65 L66 U262
FB404
R286
C489
R261
RP400 RP401 R277 RP261
R278 R265
CN408
R4122
RP402 RP403
R4125
C262 R12 R269
R653 R656
C415
C654 C663 R296
R4124
RP404 RP405 C402
FB268 R281
FB263
C273C274
R4008
R4009
FB262
R295 C263
R288 R289
R292 R287
R274 R290
R294 R291
RP406 RP407
R407
R403
C416R4121 C400
C401
U402 R402
C283
C284
C418
C665 C666
RP409 TP401
TP400
U415 RP411
R4120
C270 X402
R4113
C409 R4114 R6
R4119
C281
C282
C404
R412
C669 C670
R4055 R4054
C672
C671
C408
U411
R4116
C471
CN106
C421 R414
R416 C405 R4112 C422
C626 C632
HS1 C428
U405 FB264
U403
R475 R479
C272
C483
FB707
U602
C470
C707
R280
R285
R425
S1 L701
C621
C622
R628
C634
C269
C4011
ZD116 C709 R11
C406
R401
C407 R406 C623
C424
R622
R619 R631
C289
R624
U401
R415
C2103 C2102
U606
R709 C708 R413 C624 R626
C620 R629
C292
R4115
Q613 Q612
C715
C668
FB64 C615 R630
R674
C637
C613
C625
C712
FB605 C643
FB606 C645
FB607 C644
C631
C630
R4111
U703 C457
C713 C496 R621
C617
C618
R627
C635
C721 R625 C614 C619 R620
C667
FB604
R634
R632
R633
R714
R623
C628 C718 FB66
C716
R735
R715
C714
C555C484
R712
R424 R498 R10
R713 C717 R423 R556
FB61
FB62
C627
C646
C450 FB602
C455
CN602
C633 Q605 C640
R668 U607 FB601
R1
R644
R7 C641
C642
C464
C1124
R649R651 R4106 C454 R459
R1147
R660
FB603
D103
R609
R670
R461 C447C448
Q609
C129C127
R480
R665
R667
Q607
R664
R659
R669
R661
C115
C118
C120
C122
C124
C136
C135
C141
C1143
C150
ZD127
R1150
R732
R176
Q608
C673
R1149
R1148
Q606
R663
R658
Q610
R662
D104
R150
R156
R158
R166
X400
R122
R127
R133
R137
R141
C727
R666 D102
C1116 C1114
C728
R177
CN410
R1154
R1153
C151
R505
U705
C1144
ZD128
C501 R514
R4127
R4128
C719
R445
R444
R530
R502
U701
R529
R429
R430
R534
R181 C148
R443
R533
R515 R447 C159C160
R1116
R1117
C174
C176
R516
R503 C510 R1120 FB115
R9
U501
R525 C525 R119 FB119
C119
C117
C512 C186
C518
FB507
FB506
R1112
U111 U110
R523 C515
R707
FB126
C530 Q103 C185
CN128
R513 C511 C177 C133
C165
R131
R126
C184
U406
C507
FB112
C529
Q703
C706
R1105 C181
C130
R120
C720 R522 R121
C502 R1111
X100
ZD510 R509
ZD511 R508
ZD111
ZD110
R524
ZD108
C517
R3 R1109
U502
D101 D100
C164
R704
R703
R1113
ZD513
ZD512
ZD503
R1104
R1163 R1164
R1165 R1166
R1155
C1102
R1161
C514
R548
C509
C180
C188
C524
C505
C704
C528
R1114 R1115
U504 U505 R4 C1109C1111 C132
C134
C533
C702
C731
Q702
C516
U113
FB116
R143
C126
C710
C198 R1160R1157
C199 R1159R1158
FB117
C158
C195
C1103R1162
C1104R1174
R136
C495 C711 FB129 FB111
C1105
C1106
R492 C121
R353
R519
R520
ZD115
ZD114
FB505
ZD423 C492
D501 R501 C503
C493 FB125 R477 D503 U702 C1146 C1145
C116
R125
CN103
ZD514
ZD518
CN407
ZD502
ZD426 D504
FB100
U506 U507
ZD517
C494 R491
CN101 CN105
C521
ZD130
C154 ZD129
R541
R542
R544 C520
C155
C152
R545 R540
R178
R179
U112
R180
R16
R8 CN111
SCREW4
SCREW3
FB105
FB107
C1141
C1142
C138
C139
ZD118
ZD120
R165
R163
R169
R171
X5 Q1 SCREW2 X6
66
LC-32SV21L&LC-42SV31L
MAIN UNIT(Side-B)
R4006
R4004
FB401
FB402
C488
C726
C725
R733 R15
R734
R4007
C660 C656
R279 Q402 R728
Q705
R720
C261 C648
C2105
C652
C271
C278 C295C294
R657
R655
C661
C657
R724
C277 C296C293
R652
C653
C649
R4000
R654
C275
R723
R722 R725 R731
C2104 C280
C285 R721
FB265 C276
C288
C286
C264
C487
C287 FB261
Q400
R4130
C265
C279
Q704
Q706
C266
R411
C403
R275 C267
R410
R276 R4129
C411
R4001 R400
C268
R284
C414
C417 R730
R726
C413
R4123
RP408
RP410
R427
C427 C4007
C436 C430
C4006
U404
R4053
C4008
TP490 C429
R436 TP485 C482 R496 C432
TP492 R417
U409
R432
R431
R434 R421 C433 C410 C419
TP496
C485
TP489 TP402 R419
C486
R433
R499 C449
C435
C423
TP484 C420
R422
R4118
TP491 C426
C446 C425
TP495
C431
R420 R418
C4009
C434
C453
C442
C443C441
C445
C1108 R1156
R1173 R4117
C439
R463 C299 C291
C440
C290
R4020
C451
C444
C298 C297
C458
R426
C452
R465 R470TP423
R4107
R457
R472
R467
C460R458 R449R448
C466
C468 C438
C2100
TP409
C463 R497
C467
R471
C462
R560 C556
ZD124
TP494
R469
C461
C465
R473 C469
R474
C147
C149
R173
R175
R468
R462
R454 R4105
C456
R446
C437
R460 R4104
R442
R440
R439
R438
R441
R437
R450
R451
R453
R455
R456
CN406
R408
R452
U408
C1121
C1119
C1122
Q109
R118
C523
U407 C142
C527
C531
R512
R170
U116
R160
R161 R167
C1123
C506
R4126 R164 R168
C113
R111 R107
C1120
FB140
R1145
R1137
ZD131 R1139
R1140
R1138
Q108
C114
R1142
ZD132
ZD134
R1144
R1141R1146
R1136
C526 C508 C504
ZD133
R13
R5
2008-03-14
67
LC-32SV21L&LC-42SV31L
[2] POWER UNIT PRINTED WIRING BOARD
POWER UNIT (for 32″) (Side-A)
SCR3
CN903 CN902 SCR5
J9122 ZD952
D9153
C9160
J9118
D9156 J9119
ZD951
C9153
FB9105
J9120
C9354
IC9352
FB9104
HS9103
C9155
C9156
R9360
HS9105
FB910 D9151
HS9104
L9350
D9350
C9151 J9121
C9353
J9124
T9101
FB908 C928
IC9103
IC9102
IC950
IC9351
C932
C929
PIN5
T9301
PIN3 PIN10
PIN4
PIN9
C9115
PIN6
Q9102 Q9101
C933
C9329
C9128
J9109
D9335
HS9102
C9124
S1
J9110
C9331
C9119
ZD9101
D9330
C9814
C9333
SCR6
J9115
D9105 IC9301
J9116
J9111
J9105
R9348
C9337
J9112
J9106
ZD9301
J9114
C9108
J9101
R9801
HS9802
J9102
J9113
Q9801
J9103
RV9904 J9104
FB9909
SCR2
C9823
FB9907
D9802 C9801
J9107
C9811
HS9801 RV9903
D9804
NR901
J9108
RV9905
RV9901
D9301
C901
C9901
C931
RV9907
SG9907
C9902
F901
L9801
FB9902
L9901 PIN2
L9902
HS9901
F902
C930
BD901
PIN1
J9117
C9810
FB909
RV9906
C9904
RV9908
CN901
FB9901
SCR1 SCR4 C9903 C9905 JR1
68
LC-32SV21L&LC-42SV31L
POWER UNIT (for 32″) (Side-B)
C9154
PIN16
C9157
R981 D955
R9162
R982
R983
R9359
C978
R9358
R9357
Q970
R9151
R9354 JR901
C9355 R9356 R9154
JR9301 C9374
R9153
R9152
C9351
R9363
R9361
JR9102
R9351
C9350
R9350 R9159 R9161
R9155
C9356
Q9350
R9160
D9154
R9156
Q907
C9158
R9157
R9355
C9159 R9158
R9309
R9307
R9123
R9339
R9125
R9331
R9308
R9310
C9812
R9824
R9811
D9303 R9111 C9118 R9119 R9117
D9102
D9103
R9110
R9116
C9308 R9810
JR9802
C9813
IC9801
C9309
C9819
R9105 R9106 R9107
R9819
R9823
R9301
R9302
C9321 R9818
Q9321
R9311
IC9101 JR9801
C9818
C9817
C9816
R9817
C9815
R9815
JR9101
C9117
R9337
R9822
C9109
R9832
R9121
R9821
C9107
R9109
C9127
C9114
C9126
R9122
C9116
D9805
R9814
R9813
R9306 R9820
R903
R9305 R9304
IC901
R902
R901
PIN15
2008-03-14
69
LC-32SV21L&LC-42SV31L
POWER UNIT (for 42″) (Side-A)
SCREW3
MH3 MH4
CN903 CN902
SCREW4
ZD951
C9160
PIN29 J9121
ZD952
D9153
J9123
D9156 J9122
C9155
D9151
J9124
C9354
R981
J9116
C9153
HS22
L9104 L9105
C9156
HS21 J9112 IC9352
D9152
L9350
J9111
C9152 C9151
D9350
J9115
J9108
C9353
R9360
HS20
PIN8 PIN13 PIN12
PIN9 PIN11
FB910
PIN10 PIN14 PIN15
IC9103
T9101 FB909 C930
PIN16 PIN17
IC9351
IC9350
PIN19 PIN18 PIN20
IC9102
C931
C932
PIN5 PIN7
PIN4
T9301 PIN6
PIN3
PIN24
C9115
J9120
PIN21
C9329
PIN26
C933
PIN22
D9335 J9128
Q9102 Q9101
C9331
C9124
C9119
C9814
HS13 D9330
C9333
Q1
IC9301
J9126
J931
ZD9101 ZD9301
J9113
J9109
D9105
C9128
J945
J9105
C9337
R9104
R9348
J9106
J9101
J9103 J9110
J9125
C9108
J9102
R9802 J9104
RV9904
PIN27
J9114
FB9909
PIN1
C9823 C9824
PIN2
J9107
FB9907
D9802
C9826
HS11 C9825
D9804
J9127 NR901
NR902 RV9903
RV9905
D9301
C901
SG9907
FB9902
RV9901
RV9907
L9804 HS10
F901
PIN25
J9118
J9117
BD901
L9901
C9810
C9902
PIN23
J9119
C9901
L9902 F902
C929
RV9906
C9903
C9904
FB9901
SCREW2C928
FB908
CN901
PIN28
SCREW1
C9905
MH1 RV9908 MH6
70
POWER UNIT (for 42″) (Side-B)
2008-03-14
R9363
R9339
R982
C978
Q9350 Q970
C9356
R9361
R983
Q9321
S19
R9355
R9358
R9354
D955
R9359
C9355 R9356
C9309 C9308
R9357
D9303
R9337
R9331
C9321
R9350
R9351
R9311
IC901
C9351 C9350
R9301 C9374
R901 R902 R903
R9302
R9310 R9309
R9308 R9307
C9157
R9105
R9306
R9106
JR9101
D9102
R9305
R9110
R9111
R9107
C9109
R9304
R9109 C9118
C9107
R9119
C9114
C9116
R9116
R9122
71
R9162
C9117
R9125
R9123
C9127
R9157
R9156
R9820
C9813
R9819
R9823 Q907
R9821 R9822
JR9801
C9818
D9154
R9818
C9817
C9816
JR9102
IC9801 R9154
R9817
R9153
C9815
S16
C9159 R9158
R9160
R9159
R9815
R9161
R9814
R9151
R9813 R9832
C9812 R9152
D9805
R9824
R9810
R9811
S17
LC-32SV21L&LC-42SV31L
LC-32SV21L&LC-42SV31L
[3] KEY UNIT PRINTED WIRING BOARD
KEY UNIT (Side-A)
C024
CN10
CN21
CN11
C023
SW021
SW022
SW016
SW019
SW020
SW017
SW018
C016
R020
C017
R021
C018
R022
C019
R016
C020
R017
C021
R018
C022
R019
CN20 CN9 CN6 CN5 CN8 CN7 CN4 CN3
R1
R005
C002
U001
Q002
R007
M5 R006
TP6
Q001
R008
R003
C001
M7
R002 C003
R004
R001
LED001 TP5 TP2 TP4
TP004 TP002
72
LC-32SV21L&LC-42SV31L
CHAPTER 8. SCHEMATIC DIAGRAM
[1] MAIN SCHEMATIC DIAGRAM
02 SYSTEM POWER
INVERTER_ON_OFF
H:7.7mm BRIGHT_ADJ +5V Switch
CN701 +5VSB +5V_SW
MAIN POWER (+16V) for 22"
+12V
1 C1147
5
6
7
8
2 EMI solution 09/01/11"
3 FB704 120R/6000mA
S
D
D
D
4 1N 50V Q702
G
D
D
D
6 C1148 C731 1uF25V
7
4
3
2
1
8 24V 10N 50V
9 1N 50V R704
10 R705 51K 1/10W
STANDBY 13
11 +5VSB VCCK
12 1K 1/10W R707 + C704
HI = > POWER_ON
13 1 2 C705 Q703 220uF 16V
120R/6000mA R706 2.7K 1/10W BC847C
FB701
100K 1/10W LO = > POWER_OFF SMD H=7.7
1uF 25V C706
CONN C1149 NC/4U7 6V3
1N 50V
11 +24V +24V
5,7,10,12,13,14,15,16,17 +5V_SW +5V_SW
1 FB707
2
+5VSB U702 3V3SB +5VSB
80OHM 4A
3,4,6,9,17 +5VSB
14,17 +12V
+5VSB
+12V
2
6,7,9,13,17 3V3SB 3V3SB
3 2 C707 ZD116 C708 C709 4,5,7,8,9,10,11,12,13,14,15,16,18 DVDD3V3 DVDD3V3
VI VO 1uF 25V 1uF 25V 10uF 10V
4,5,7,8,9,10,11,12,13,14,15,16,18 AVDD3V3 AVDD3V3
RLZ6.8B 7,8,9,12,14,15 AVDD1V2 AVDD1V2
GND
1
100UF 16V R709
4
C712
H:7mm 0.1uF 50V U703 VCCK 3,4,5,6,7,8,9,10,11,12,13,14,15,16,17,18 GND
9
1 E-PAD 8
VCC VIN Vout = 0.8x(R1+R2)/R2
2 7 L701 4.7uH
3 REF
GND PGND
LX 6 Control Interface
C713 4 5 C714 NC/1nF 50V OPWRSB
U701 DVDD3V3 AVDD3V3 0.1uF 50V FB EN C716 C717 C718 + C715
9 OPWRSB
+5V_SW G1084-33TU3Uf R712 R713 100UF 16V BL_DIMMING
AT1529F11U 13 BL_DIMMING
3 2 0.1uF 50V 10uF 10V 10uF 10V
VIN VOUT 3V3SB 1K8 1/10W 1%100R 1/10W 5% BL_ON/OFF
13 BL_ON/OFF
C721 R1
GMT
GND
H:7.7mm R735
OPWRSB 10K 1/10W
NC/15K 1/10W
Bright_Adj
NC/4K7 1/10W
R720
R721 R722
M ax:3.3V
R723
R724 INVERTER ON/OFF NC/4K7 1/10W 2K 1/10W
R725 1K 1/10W M in: 0V
4.7K 1/10W H: OFF R726
R728 L: ON 10K 1/10W INVERTER_ON_OFF
BRIGHT_ADJ
R730
08/30 change 100R 1/10W 5% BL_ON/OFF Q704
BL_DIMMING Q705 MMBT3904 C725
to 10*9 MMBT3904 R733 C726 4.7K 1/10W R734 10uF 10V
R731 NC/1K 1/10W NC/22 10V NC/1K 1/10W
1.2 x (1+ 0/110) = 1.2V 4.7K 1/10W
AVDD1V2
2
DVDD3V3 U705
G912T63U 26",32",40" 1 NC/MMBT3906 PNP
Q706
3
VI VO
2 R732 BKL CONTROL R119 R120 R123 R624 C127 REMARK INVERTER
TYPE R721 R722
3
0R05 4A 1/4W
ON/OFF
GND
2008-03-14
73
LC-32SV21L&LC-42SV31L
03 VGA
19
17
12 VGASDA
6 R119 VSY NC
VGA11 11 1 RED 10K 1/10W U110 Video Input 12 VSY NC
12 HSY NC
HSY NC
7 G_G D101 6 1 VGASCL BP
VGASDA# GRN +5VSB S B1 12 BP SOG
12 2 BAV70 5 2
UART_SW 1 VGASCL# VCCGND 12 SOG GP
8 D100 BC847C 4 3
HSY NC# BLU A B0 U0RX 12 GP VGACOM
13 3 1 BAV70 Q103
12 VGACOM RP
9 3 R120
VSY NC# 12 RP
14 4 3 VGA_PLUGPWR 1K 1/10W NC7SB3157P6X
10 VGA11 2 R107 10K 1/10W 0.1uF 50V
VGASCL# 15 5 2 C114 Other Control Interface
CN101
1
D-SUB 15P U111 9,17 U0TX
U0TX
18
16
NC7SB3157P6X VGA_EEPROM_WP
VGA_PLUGPWR 13 VGA_EEPROM_WP
L:B0 connected to A
R111 10K 1/10W H:B1 connected to A
1
68 OHM +-5% 1/16W
VSY NC# VSY NC C116
15PF50V
1
ZD109 R125
TVM1G5R5M100R 75R 1/10W 1%
ZD110 R126 C117
2
TVM1G5R5M100R NC/2.2K 1/10W NC/5pF
2
FB101 80 OHM
ZD111 R131 C119 GRN 1 2 R133 C120 GP
TVM1G5R5M100R NC/2.2K 1/10W NC/5pF 10N 50V VGA EEPROM VGA_PLUGPWR
1
68 OHM +-5% 1/16W
C121
2
R134 15PF50V
ZD112
R160
R161
R164
TVM1G5R5M100R 75R 1/10W 1% C142
R137 100N 16V
2
10K 1%
10K 1%
10K 1%
0R01 100R 1/16W 5% U407
1 8
2 E0 VCC 7 VGADDCWP
3 E1 WC 6 R167 33R 1/16W 5% VGASCL
80 OHM 4 E2 SCL 5 R168 33R 1/16W 5% VGASDA
RED FB102
1 2 R141 C124 RP VSS SDA
10N 50V M24C02-WDW6P
1
Q109 VGA_EEPROM_WP
BC847C
2.2K 1/16W
R118
4K7 1/16W 5%
74
LC-32SV21L&LC-42SV31L
04 YPBPR
CN111 SOY 0 12
1 C127
A R149 1.5nF 50V
2 Y _IN_1 1 2 R150 C129
Y 0P 12
3 FB10380 OHM 10N 50V
1
B 18R 1/10W 5% 68 OHM +-5% 1/16W
4 PB_IN_1 C131
5 ZD117 15PF50V
C
6 PR_IN_1 TVM1G5R5M100R R153
7 56R 1/10W 1%
2
D R156 C136
COM0 12
8 R159 10N 50V
9 0R01 1/16W 68 OHM +-5% 1/16W
E 10
11
R157
RCA JACK 1 2 18R 1/10W 5% R158 C135
PB0P 12
1
H:8.5mm FB10580 OHM 10N 50V
68 OHM +-5% 1/16W
ZD118
C138
TVM1G5R5M100R 15PF50V
R162
2
56R 1/10W 1%
2
R163
ZD120 56R 1/10W 1% C139
TVM1G5R5M100R 15PF50V
1N 50V C1141
1N 50V
2,3,5,6,7,8,9,10,11,12,13,14,15,16,17,18 GND
2008-03-14
75
LC-32SV21L&LC-42SV31L
05 SIDE AV/USB/PC AUDIO IN
1
C148 C147 47N 16V 2 VGA_Audio_L_In C123 R172 VGA_L_In
A
1 100OHM1/16W 10uF 10V 30K 1/10W 5%
47pF 50V
4 SIDE_AudioLIN Side AV Video & Audio
75R 1/10W 1% 3 VGA_Audio_R_In C125 R143 VGA_R_In
B
3 R174 R181 10uF 10V 30K 1/10W 5% CVBS_COM
12 CVBS_COM
2
ZD126 0R05 1/16WR175 C149 CVBS_COM PHONE JACK CVBS1P
12 CVBS1P
1
7 SIDE_AudioRIN TVM1G5R5M100R 47N 16V AV2_L_In
12 AV2_L_In AV2_R_In
C 6 100R 1/16W 5% H:8.4mm 12 AV2_R_In
5
R176 C1146 ZD114 ZD115
JACK C150 AV2_L_In 1N 50V TVM1G5R5M100R TVM1G5R5M100R
1
H:8.5mm 10uF 10V C1145
Near CONN. USB
2
30K 1/16W 1N 50V USB_DP0
14 USB_DP0 USB_DM0
ZD127
14 USB_DM0 USB_PWR_EN0
C1143 TVM1G5R5M100R
13 USB_PWR_EN0 USB_OC_COM
13 USB_OC_COM
1N 50V 2
R177
C151 AV2_R_In
1
6
Switch 4
4 3 2 1
U112 USB_DP0 3
G5250K1T1U USB_DM0 2
4 5 1
IN OUT
GND
10K 1/10W
TVM1G5R5M100R
TVM1G5R5M100R
2
R179
100R 1/10W 1%
USB_OC_COM
HI = > NORM AL
LO=> OC
76
LC-32SV21L&LC-42SV31L
06 HDMI CONNECTOR
27K 1/10W 5%
7 OPWR1_5V OPWR1_5V
D501 R501
3V3SB HD_CEC 7 7 OPWR0_5V OPWR0_5V
BAS316
CEC_A1 2,7,9,13,17 3V3SB 3V3SB
1 2 FB50030R/700mA
2,3,4,9,17 +5VSB +5VSB
CEC_A0 2,3,4,5,7,8,9,10,11,12,13,14,15,16,17,18 GND
1 2 FB50230R/700mA
1
ZD502 ZD503 HDMI 2 7 RR1X0-
RR1X0-
RR1X0+
7 RR1X0+ RR1X1-
7 RR1X1- RR1X1+
7 RR1X1+ RR1X2-
7 RR1X2-
2
RR1X2+
7 RR1X2+ RR1XC-
7 RR1XC- RR1XC+
NC/TVM1G5R5M100R
7 RR1XC+
NC/TVM1G5R5M100R
DDC_SCL1
7 DDC_SCL1 DDC_SDA1
7 DDC_SDA1
HPD1
7 HPD1
HDMI 1 7 RR0X0-
RR0X0-
RR0X0+
7 RR0X0+ RR0X1-
7 RR0X1- RR0X1+
7 RR0X1+ RR0X2-
7 RR0X2- RR0X2+
7 RR0X2+ RR0XC-
7 RR0XC- RR0XC+
7 RR0XC+
DDC_SCL0
7 DDC_SCL0 DDC_SDA0
7 DDC_SDA0
HEC+
7 HEC+ HEC-
7 HPD0
ZD511
ZD512
ZD513
ZD514
ZD515
ZD516
ZD517
ZD518
2
2
H:7.8mm H:7.8mm
U504 U505 U506 U507
RR1XC- 1 10 RR1XC- RR1X1- 1 10 RR1X1- RR0XC- 1 10 RR0XC- RR0X1- 1 10 RR0X1-
RR1XC+2 IN1 OUT1 9 RR1XC+ RR1X1+ 2 IN1 OUT1 9 RR1X1+ RR0XC+2 IN1 OUT1 9 RR0XC+ RR0X1+ 2 IN1 OUT1 9 RR0X1+
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
TVM1G5R5M100R
IN2 OUT2 IN2 OUT2 IN2 OUT2 IN2 OUT2
1
1
RR1X0- 4 7 RR1X0- RR1X2- 4 7 RR1X2- RR0X0- 4 7 RR0X0- RR0X2- 4 7 RR0X2-
GND
GND
GND
GND
GND
GND
GND
GND
RR1X0+ 5 IN3 OUT3 6 RR1X0+ RR1X2+ 5 IN3 OUT3 6 RR1X2+ RR0X0+ 5 IN3 OUT3 6 RR0X0+ RR0X2+ 5 IN3 OUT3 6 RR0X2+
IN4 OUT4 IN4 OUT4 IN4 OUT4 IN4 OUT4
NC/RClamp0524P.TCT NC/RClamp0524P.TCT NC/RClamp0524P.TCT NC/RClamp0524P.TCT
8
3
2008-03-14
77
LC-32SV21L&LC-42SV31L
07 HDMI SWITCH
3V3SB_9185
2,8,9,12,14,15 AVDD1V2 AVDD1V2
2,4,5,8,9,10,11,12,13,14,15,16,18 AVDD3V3 AVDD3V3
AVCC1V8 AVCC1V8 AVCC1V8
2,5,10,12,13,14,15,16,17 +5V_SW +5V_SW
R514
2,3,4,6,9,17 +5VSB +5VSB
10K 1%
1K 1/16W 5%
2,6,9,13,17 3V3SB 3V3SB
HDMISW_SDA#
HDMISW_RST#
HDMISW_SCL#
R512 3V3SB_9185 3V3SB_9185 DVDD3V3
2,4,5,8,9,10,11,12,13,14,15,16,18 DVDD3V3
R505
M_RX1_CB
HDMISW_RST# HDMI_SW_RST
M_RX1_0B
M_RX1_1B
M_RX1_2B
M_RX1_C
6 OPWR1_5V OPWR1_5V
M_RX1_0
M_RX1_1
M_RX1_2
RR0XC+
RR0XC-
6 OPWR0_5V OPWR0_5V
TPWR
R533 NC/0R05 1/16W
HPD0
NC/10K 1/16W 5% C501
2,3,4,5,6,8,9,10,11,12,13,14,15,16,17,18 GND
1uF 25V
R502 HDMI 2 6 RR1X0-
RR1X0-
RR1X0+
6 RR1X0+ RR1X1-
6 RR1X1- RR1X1+
NC/0R05 1/16W R534 R515 R516
20
19
18
17
16
15
14
13
12
11
10
6 RR1X1+
9
8
7
6
5
4
3
2
1
U501 ARC_OE RR1X2-
4.7K 1/10W
10K 1%
10K 1%
6 RR1X2- RR1X2+
SiI9185ACTU
R0XC+
TXC+
TX0+
TX1+
TX2+
ExtSWING
AVCC18
HPD0
LSCL/PSEL1
RESET#
AVCC18
6 RR1X2+
R0XC-
TXC-
LSDA/PSEL0
TX0-
TX1-
TX2-
AGND
AGND
AGND
RR1XC-
DVDD3V3 6 RR1XC- RR1XC+
R545 R540 C521
RR0X0- 6 RR1XC+ HPD1
21 80 NC/10K+-5%1/16W 10K 1% 100N 16V
RR0X0+ R0X0- AGND 6 HPD1
22 79
23 R0X0+ TPWR/I2CADDR 78 HDMI_SCL U508
3V3SB_9185 RR0X1- AVCC33 TSCL HDMI_SDA
24 77 1 5
RR0X1+ 25 R0X1-
R0X1+
TSDA
HPDIN
76 HPDIN HDMI_HPD SPDIF_OUT 2 OE VCC
A
C520 HDMI 1 6 RR0X0-
RR0X0-
26 75 3 4 R541 HECC+ HEC+ RR0X0+
RR0X2- AGND TEST GND Y 6 RR0X0+ RR0X1-
27 74 R503 0R05 1/16W 180R 1/10W 1%
100K1/16W
RR0X2+ R0X2- DGND 6 RR0X1- RR0X1+
28 73 1uF 25V
R544
R0X2+ DVDD18 DVDD1V8 6 RR0X1+
29 72 SN74LVC1G125DBVR RR0X2-
AVCC1V8 DDC_SDA0 AVCC18 RPWR2 6 RR0X2- RR0X2+
30 71 R542
DDC_SCL0 DSDA0 DSCL2 6 RR0X2+ RR0XC-
31 70 HI = > Dis able 82R 1/10W 1%
RPWR0_5V DSCL0 DSDA2 6 RR0XC- RR0XC+
32 69 LO = > Enable
DVDD1V8
33 RPWR0
DVDD18
AVCC18
R2X2+
68
AVCC1V8
ARC 6 RR0XC+
6 HPD0
HPD0
34 67
R513 4.7K 1/10W 35 DGND R2X2- 66
3V3SB_9185 HPD1 I2CSEL/INT AGND OSDA1
36 65
HPD1 R2X1+ 9,11,14 OSDA1 OSCL1
37 64
AVCC1V8 RR1XC- AVCC18 R2X1- 9,11,14 OSCL1
38 63 3V3SB_9185 3V3SB 3V3SB_9185
RR1XC+ 39 R1XC- AVCC33 62 U502
40 R1XC+ R2X0+ 61 FB505 G1117T63Uf FB506 DDC_SDA1
AGND R2X0- 6 DDC_SDA1
AVCC33
AVCC18
AVCC33
AVCC18 DDC_SCL1
RPWR1
CEC_D
CEC_A
DSDA1
R2XC+
DSCL1
6 DDC_SCL1
R1X0+
R1X1+
R1X2+
R2XC-
AGND
AGND
DDC_SDA0
R1X0-
R1X1-
R1X2-
1 2 3 2 1 2
HPD2
GND
FB507
TH
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
4
0R01 0R01 120R 1% 1/10W 220R/2000mA HEC+
6 HEC+
DDC_SDA1
HEC-
DDC_SCL1
6 HPD0
RPWR1_5V
SPDIF_OUT
RR1X0+
RR1X1+
RR1X2+
RR1X0-
12 SPDIF_OUT
RR1X1-
RR1X2-
ARC_OE
13 ARC_OE
AVCC1V8
3V3SB_9185 AVCC1V8 3V3SB_9185
C533
EMI solution 09/01/11" U401G MT5366
RX_0
AE3 M_RX1_0
M_RX1_0B
Analog Power
AD3
HD_CEC RX_0B M_RX1_1
3V3SB_9185 10N 50V
RX_1
AE4 AVDD3V3 ( 17 mA )
AD4 M_RX1_1B
HDMISW_SCL# R529 0R01 RX_1B AE5 M_RX1_2 R556 AVDD33_HDMI
OSCL1 9,11,14 RX_2 AD5 M_RX1_2B 0R01
3V3SB_9185 DVDD1V8 HDMISW_SDA# R530 0R01 R528 RX_2B AE2 M_RX1_C
OSDA1 9,11,14 RX_C M_RX1_CB
0R05 1/16W AD2 C555
RX_CB 100N 16V
HDMI_CEC AB6 HDMI_CEC
HDMI_CEC AC6 HDMI_HPD
C504 C505 C506 C507 C508 C509 C510 C511 C512 HDMI_HPD AC5 HDMI_SCL
10uF 10V 10uF 10V 0.1uF 50V 0.1uF 50V 0.1uF 50V 0.1uF 50V 10uF 10V 0.1uF 50V 0.1uF 50V HDMI_SCL AB5 HDMI_SDA
HDMI_SDA TPWR
PWR5V
AD6 AVDD1V2 ( 61 mA )
C532
AE1 AVDD33_HDMI R560 AVDD12_HDMI
NC/22PF 50V AVDD33_HDMI 0R01
PCB LAYOUT: Place all decoupling capacitors (0.1uf)as close to the pin AA6 AVDD12_HDMI
AVDD12_HDMI C556
AVCC1V8 as possible. EMI solution 09/01/11" AC4 100N 16V
AVSS33_HDMI
MT 5366GSNG
78
LC-32SV21L&LC-42SV31L
08 DDR3 DRAM
DDR3#1 U402 U402 Damping for DDR#1 ADDR/CMD Damping for DDR#2 ADDR/CMD DDR3#2 U403 U403
MT5366 U401B U401B RDQ0 E3 N3 B_A0 NEAR BRANCH NEAR BRANCH RDQ16 E3 N3 A_A0
RDQ0 D13 C4 1_A0 RDQ1 F7 DQL0 A0 P7 B_A1 RDQ17 F7 DQL0 A0 P7 A_A1
RDQ1 D12 RDQ6//RDQ0 RCAS_//RA0 F9 1_A1 RDQ2 F2 DQL1 A1 P3 B_A2 RP400 100 OHM 1/16W RP401 100 OHM 1/16W RDQ18 F2 DQL1 A1 P3 A_A2
RDQ2 E13 RDQ0//RDQ1 RA6//RA1 C5 1_A2 RDQ3 F8 DQL2 A2 N2 B_A3 A_BA0 1 8 1_BA0 1_BA0 1 8 B_BA0 RDQ19 F8 DQL2 A2 N2 A_A3
RDQ3 D11 RDQ1//RDQ2 RBA0//RA2 A7 1_A3 RDQ4 H3 DQL3 A3 P8 B_A4 A_A5 2 7 1_A5 1_A5 2 7 B_A5 RDQ20 H3 DQL3 A3 P8 A_A4
RDQ4 D14 RDQ7//RDQ3 RA5//RA3 F8 1_A4 RDQ5 H8 DQL4 A4 P2 B_A5 A_A7 3 6 1_A7 1_A7 3 6 B_A7 RDQ21 H8 DQL4 A4 P2 A_A5
RDQ5 E12 RDQ4//RDQ4 RA4//RA4 D5 1_A5 RDQ6 G2 DQL5 A5 R8 B_A6 A_RST# 4 5 1_RST# 1_RST# 4 5 B_RST# RDQ22 G2 DQL5 A5 R8 A_A6
RDQ6 E14 RDQ5//RDQ5 RBA1//RA5 D7 1_A6 RDQ7 H7 DQL6 A6 R2 B_A7 RDQ23 H7 DQL6 A6 R2 A_A7
RDQ7 E11 RDQ3//RDQ6 RA13//RA6 A6 1_A7 RDQ8 D7 DQL7 A7 T8 B_A8 RP402 100 OHM 1/16W RP403100 OHM 1/16W RDQ24 D7 DQL7 A7 T8 A_A8
RDQ8 B10 RDQ2//RDQ7 RA10//RA7 E6 1_A8 RDQ9 C3 DQU0 A8 R3 B_A9 A_A9 1 8 1_A9 1_A3 8 1 B_A3 RDQ25 C3 DQU0 A8 R3 A_A9
RDQ9 B15 RDQ13//RDQ8 NC//RA8 B7 1_A9 RDQ10 C8 DQU1 A9 L7 B_A10 A_A13 2 7 1_A13 1_A2 7 2 B_A2 RDQ26 C8 DQU1 A9 L7 A_A10
RDQ10 A10 RDQ11//RDQ9 RA3//RA9 E8 1_A10 RDQ11 C2 DQU2 A10/AP R7 B_A11 A_A2 3 6 1_A2 1_A13 6 3 B_A13 RDQ27 C2 DQU2 A10/AP R7 A_A11
RDQ11 A15 RDQ10//RDQ10 RA12//RA10 F7 1_A11 RDQ12 A7 DQU3 A11 N7 B_A12 A_A3 4 5 1_A3 1_A9 5 4 B_A9 RDQ28 A7 DQU3 A11 N7 A_A12
RDQ12 C11 RDQ12//RDQ11 RA11//RA11 D6 1_A12 RDQ13 A2 DQU4 A12/BC# T3 B_A13 RDQ29 A2 DQU4 A12/BC# T3 A_A13
RDQ13 C15 RDQ15//RDQ12 RA0//RA12 B6 1_A13 RDQ14 B8 DQU5 NC RP404 100 OHM 1/16W RP405 100 OHM 1/16W RDQ30 B8 DQU5 NC
RDQ14 C10 RDQ9//RDQ13 RA1//RA13 RDQ15 A3 DQU6 J1 A_A0 1 8 1_A0 1_A0 1 8 B_A0 RDQ31 A3 DQU6 J1
RDQ15 C14 RDQ8//RDQ14 B4 1_WE# DQU7 NC_0 J9 A_BA2 2 7 1_BA2 1_BA2 2 7 B_BA2 DQU7 NC_0 J9
RDQ16 G5 RDQ14//RDQ15 RCKE//RWE_ A3 1_ODT NC_1 L1 3 6 3 6 NC_1 L1
RDQ17 J5 RDQ22//RDQ16 RODT//RODT B3 1_CAS# RDQS1 C7 NC_2 L9 A_WE# 4 5 1_WE# 1_WE# 4 5 B_WE# RDQS3 C7 NC_2 L9
RDQ18 H5 RDQ23//RDQ17 RRAS_//RCAS_ A4 1_CS# RDQS1# B7 UDQS NC_3 M7 RDQS3# B7 UDQS NC_3 M7
RDQ19 J4 RDQ17//RDQ18 RWE_//RCS_ A2 1_RAS# RDQS0 F3 UDQS# NC_4 T7 0R05 1/16W 0R05 1/16W RDQS2 F3 UDQS# NC_4 T7
RDQ20 H4 RDQ16//RDQ19 RCS_//RRAS_ D9 1_CKE RDQS0# G3 LDQS NC_6 A_CS# R4129 1_CS# 1_CS#R4130 B_CS# RDQS2# G3 LDQS NC_6
RDQ21 K4 RDQ20//RDQ20 RA9//RCKE RDQM1 D3 LDQS# M2 B_BA0 RDQM3 D3 LDQS# M2 A_BA0
RDQ22 G4 RDQ21//RDQ21 E7 1_BA0 RDQM0 E7 UDM BA0 N8 B_BA1 RP406 100 OHM 1/16W RP407 100 OHM 1/16W RDQM2 E7 UDM BA0 N8 A_BA1
RDQ23 K3 RDQ19//RDQ22 RA8//RBA0 E9 1_BA1 LDM BA1 M3 B_BA2 A_ODT 1 8 1_ODT 1_ODT 1 8 B_ODT LDM BA1 M3 A_BA2
RDQ24 J1 RDQ18//RDQ23 RA2//RBA1 C7 1_BA2 BA2 J7 CLK0 A_CAS# 2 7 1_CAS# 1_CAS# 2 7 B_CAS# BA2 J7 CLK1
RDQ25 D2 RDQ26//RDQ24 RA7//RBA2 B_RST# T2 CK K7 CLK0# A_RAS# 3 6 1_RAS# 1_RAS# 3 6 B_RAS# A_RST# T2 CK K7 CLK1#
RDQ26 J2 RDQ27//RDQ25 E3 RVREF5 RESET# CK# L2 B_CS# A_A11 4 5 1_A11 1_A11 4 5 B_A11 RESET# CK# L2 A_CS#
RDQ27 C1 RDQ29//RDQ26 RVREF ZQ1 L8 CS# K3 B_CAS# ZQ2 L8 CS# K3 A_CAS#
RDQ28 H3 RDQ28//RDQ27 R400 ZQ CAS# K1 B_ODT RP408 100 OHM 1/16W RP409 100 OHM 1/16W R401 ZQ CAS# K1 A_ODT
RDQ29 D1 RDQ31//RDQ28 C16 240 OHM +-5% 1/16W ODT J3 B_RAS# A_A1 1 8 1_A1 1_A8 1 8 B_A8 240 OHM +-5% 1/16W ODT J3 A_RAS#
RDQ30 RDQ25//RDQ29 VCC2IO DDRV RAS# B_WE# A_A4 1_A4 1_A6 B_A6 RAS# A_WE#
J3 B16 L3 2 7 2 7 L3
RDQ31 E2 RDQ24//RDQ30 VCC2IO A16 WE# K9 B_CKE A_A6 3 6 1_A6 1_A4 3 6 B_A4 WE# K9 A_CKE
RDQ30//RDQ31 VCC2IO F15 DDRV CKE A_A8 4 5 1_A8 1_A1 4 5 B_A1 DDRV CKE
VCC2IO RVREF_as closed to U402
RDQS0 B13 E15 RP411 100 OHM 1/16W
RDQS0# A13 RDQS0//RDQS0 VCC2IO D15 DDRV A1 B1 1_BA1 1 8 B_BA1 A1 B1
RP410 100 OHM 1/16W
RDQS0_//RDQS0_ VCC2IO H14 R402 A8 VDDQ_0 VSSQ_0 B9 A_CKE 1 8 1_CKE 1_A12 2 7 B_A12 2_DDRV_A8 A8 VDDQ_0 VSSQ_0 B9
RDQS1 A12 VCC2IO H13 RVREF1 1_DDRV_C1 C1 VDDQ_1 VSSQ_1 D1 A_A10 2 7 1_A10 1_A10 3 6 B_A10 2_DDRV_C1 C1 VDDQ_1 VSSQ_1 D1
RDQS1# B12 RDQS1//RDQS1 VCC2IO C2 1K 1/16W 1% C9 VDDQ_2 VSSQ_2 D8 A_A12 3 6 1_A12 1_CKE 4 5 B_CKE 2_DDRV_C9 C9 VDDQ_2 VSSQ_2 D8
RDQS1_//RDQS1_ VCC2IO D3 C400 D2 VDDQ_3 VSSQ_3 E2 A_BA1 4 5 1_BA1 D2 VDDQ_3 VSSQ_3 E2
RDQS2 F2 VCC2IO K8 C401 R403 E9 VDDQ_4 VSSQ_4 E8 E9 VDDQ_4 VSSQ_4 E8
RDQS2//RDQS2 VCC2IO VDDQ_5 VSSQ_5 Damping and Termination for CLK Damping and Termination for CLK VDDQ_5 VSSQ_5
RDQS2# F1 J8 100N 16V 100N 16V 1_DDRV_F1 F1 F9 2_DDRV_F1 F1 F9
RDQS2_//RDQS2_ VCC2IO H8 1K 1/16W 1% H2 VDDQ_6 VSSQ_6 G1 H2 VDDQ_6 VSSQ_6 G1
RDQS3 VCC2IO 1_DDRV_H9 VDDQ_7 VSSQ_7 Near MT5366 NEAR DRAM Near MT5366 NEAR DRAM 2_DDRV_H9 VDDQ_7 VSSQ_7
G1 B1 H9 G9 H9 G9
RDQS3# G2 RDQS3//RDQS3 VCC2IO F6 VDDQ_8 VSSQ_8 RCLK1 CLK1 RCLK0 CLK0 VDDQ_8 VSSQ_8
RDQS3_//RDQS3_ VCC2IO E5 B2 A9 B2 A9
RDQM0 C12 VCC2IO D4 D9 VDD_0 VSS_0 B3 D9 VDD_0 VSS_0 B3
RDQM1 C13 RDQM0//RDQM0 VCC2IO C3 G7 VDD_1 VSS_1 E1 R406 R407 G7 VDD_1 VSS_1 E1
RDQM2 G3 RDQM1//RDQM1 VCC2IO B2 K2 VDD_2 VSS_2 G8 100R 1/16W 5% 100R 1/16W 5% K2 VDD_2 VSS_2 G8
RDQM3 RDQM2//RDQM2 VCC2IO RVREF_as closed to U402 VDD_3 VSS_3 VDD_3 VSS_3
E1 A1 K8 J2 K8 J2
RDQM3//RDQM3 VCC2IO E4 DDRV N1 VDD_4 VSS_4 J8 2_DDRV_N1 N1 VDD_4 VSS_4 J8
RCLK0 A9 VCC2IO F5 R410 1_DDRV_N9 N9 VDD_5 VSS_5 M1 RCLK1# CLK1# RCLK0# CLK0# N9 VDD_5 VSS_5 M1
RCLK0# B9 RCLK0//RCLK0 VCC2IO G6 RVREF2 1_DDRV_R9 R9 VDD_6 VSS_6 M9 R9 VDD_6 VSS_6 M9
RCLK0_//RCLK0_ VCC2IO F14 1K 1/16W 1% 1_DDRV_R1 R1 VDD_8 VSS_7 P1 2_DDRV_R1 R1 VDD_8 VSS_7 P1
RCLK1 K1 VCC2IO VDD_7 VSS_8 P9 VDD_7 VSS_8 P9
RCLK1# K2 RCLK1//RCLK1 L3 C402 R411 C403 VSS_9 T1 VSS_9 T1
RCLK1_//RCLK1_ DVSS VSS_10 RVREF_as closed to U403 VSS_10
L4 100N 16V 100N 16V T9 RVREF_as closed to U403 T9
1_RST# C6 DVSS L5 1K 1/16W 1% VSS_11 VSS_11
RBA2//RRESET_ DVSS L6
AVDD12_MEMPLL H9 DVSS 2,4,5,7,9,10,11,12,13,14,15,16,18 DVDD3V3 DVDD3V3
K6 DDRV DDRV
AVDD12_MEMPLL DVSS RVREF1 RVREF2 RVREF3 RVREF4 2,7,9,12,14,15 AVDD1V2 AVDD1V2
H10 C9 H1 M8 R412 R413 H1 M8
AVSS12_MEMPLL DVSS VREFDQ VREFCA RVREF3 RVREF4 VREFDQ VREFCA 2,3,4,5,6,7,9,10,11,12,13,14,15,16,17,18 GND
F11
MEMTP D8 DVSS F12
MEMTN C8 MEMTP
MEMTN
DVSS
DVSS
E10 DRAM POWER DDRV H5TQ1G63DFR-H9C
1K 1/16W 1% 1K 1/16W 1%
H5TQ1G63DFR-H9C
J6 C404 R414 C405 C406 R415 C407
DVSS F10 100N 16V 100N 16V 100N 16V 100N 16V
DVSS H11 1K 1/16W 1% 1K 1/16W 1%
DVSS K7
DVSS H12
DVSS DVDD3V3 U415
DDRV For 2 layer Layout
3 2 R416 DDRV
VIN VOUT
For 2 layer Layout
ADJ/GND
C426
100N 16V
C427
100N 16V
C428
100N 16V
C429
100N 16V
C430
100N 16V
C431
C4009
MT5366 DE-CAP. 10uF 10V
DDRV
RVREF_as closed to MT5363 DRAM DE-CAP. DDRV
DDR#1 Bottom Side DDR#2 Bottom Side
DDRV
R417 AVDD1V2 AV1V2_MEMPLL
RVREF5
1K 1/16W 1% R418 AVDD12_MEMPLL C411 C4006 C413 C414 C417 C449 C4007 C4008 C419 C420
R419 0R05 1/16W 10UF 6.3V 10UF 6.3V
100N 16V 100N 16V 100N 16V 100N 16V 10UF 6.3V 10UF 6.3V 100N 16V 100N 16V
C432 C433 C434
1K 1/16W 1% 100N 16V 100N 16V
100N 16V
2008-03-14
79
LC-32SV21L&LC-42SV31L
09 FLASH/XTAL/JTAG/UART
JTCK U401A
R4
U401A
AB8 U0TX DVDD3V3
JTDI T1 JTCK
JTDI
U0TX
U0RX
AC7 U0RX NAND Flash 256MB
2nd I2C 2,4,5,7,8,10,11,12,13,14,15,16,18 DVDD3V3
DVDD3V3
2,3,4,6,17 +5VSB
DVDD3V3
+5VSB
JTDO
JTMS
R3
T3 JTDO U2 U1RX U405 U405 DVDD3V3
DVDD3V3
R423 R424
2,6,7,13,17 3V3SB 3V3SB
JTRST# JTMS U1RX U1TX 2 VCCK VCCK
R426 T2 U1 1 48 DVDD3V3
4.7K 1/16W
4.7K 1/16W
JTRST_ U1TX NC1 NC29 2,7,8,12,14,15 AVDD1V2 AVDD1V2
TP495 2 47
OSDA0 J22 J19 POWE# 3 NC2 NC28 46 R425
10K 1/10W
NC/4.7K 1/10W
OSCL0 POOE_ K22 POCE1# 5 NC4 NC26 44 PDD7
4.7K 1/10W
TP496 OSDA1 U4 POCE1_ J21 POCE0# 6 NC5 I/O7 43 PDD6 OSDA1
OSCL1 U3 OSDA1 POCE0_ K23 PDD7 PARB# 7 NC6 I/O6 42 PDD5 OSCL1
OSCL1 PDD7 L23 PDD6 POOE# 8 RY /BY 1 I/O5 41 PDD4
OSDA2 T22
OSDA2
PDD6
PDD5
L24 PDD5 POCE1#9 RE
CE1
I/O4
NC25
40 POCE0# Flash_WP# Control Interface
OSCL2 T23 L25 PDD4 10 39 DVDD3V3 OPWRSB
OSCL2 PDD4 K20 PDD3 DVDD3V3 11 NC7 NC24 38
3rd I2C DVDD3V3
2 OPWRSB
OXTAL_I AE19 PDD3 K19 PDD2 12 NC8 NC23 37 C435 DVDD3V3 DVDD3V3 OIRI
OXTAL_O AD19 XTALI
XTALO
PDD2
PDD1
L22 PDD1 13 VCC1 VCC2
VSS1 VSS2
36 100N 16V Serial U404
Flash 64Mb
13,17 OIRI
M23 PDD0 14 35 R429 R430 SY S_EEPROM_WP
AVDD33_XTAL_STB AC18 PDD0 PARB# NC9 NC22 POCE0# 13 SY S_EEPROM_WP
J20 15 34 1 8
4.7K 1/10W
4.7K 1/10W
AE18 AVDD33_XTAL_STB PARB_ J24 PACLE PACLE 16 NC10 NC21 33 PDD7 2 CS# VCC 7 R4053NC/4.7K 1/10W
AVSS33_XTAL_STB PACLE J25 PAALE PAALE 17 CLE NC20 32 PDD3 Flash_WP# 3 SO/SIO1 NC/SIO3 6 POOE#
PAALE POWE# 18 ALE I/O3 31 PDD2 4 WP#/SIO2 SCLK 5 PDD6 OSDA1
AVDD33_REG_STB OPWRSB Flash_WP# 19 WE I/O2 PDD1 GND SI/SIO0 OSDA2 7,11,14 OSDA1 OSCL1
AA7 AB9 30 C436
AVDD33_VGA_STB OPWRSB WP I/O1 PDD0 OSCL2 7,11,14 OSCL1 OSDA2
W8 20 29 NC/100N 16V
AVSS33_VGA_STB ORESET# NC11 I/O0 15 OSDA2 OSCL2
Y8 21 28 NC/MX25L6445EM2I-10G
ORESET_ NC12 NC19 15 OSCL2
22 27
AVDD12_PLL AB15 AC8 OIRI 23 NC13 NC18 26 DVDD3V3 OPCTRL5
AA17 AVDD12_PLL
AVSS12_PLL
OIRI 24 NC14 NC17
NC15 NC16
25 SYSTEM EEPROM 13 OPCTRL5
13 OPCTRL4
OPCTRL4
E23 FSRC_WR R431 TP402 AOSDATA1
FSRC_WR 12 AOSDATA1
3V3SB
AVDD10_LDOAA12 DVDD3V3
4.7K 1/10W
E-Fuse D efau lt 2G bit N AN D F lash u sedH27U2G8F2CTR-BC
R432 R433 R434
U409 U0TX
4.7K 1/16W
4.7K 1/16W
4.7K 1/16W
AVDD10_LDO LO = > WRITE 3,17 U0TX
MTK HI = > WP U409 U0RX
3,17 U0RX
A25 T8
B25 DVSS VCC3IO M18 DVDD3V3 DVDD3V3 8 1
R4104 Y 21 DVSS
DVSS
VCC3IO
VCC3IO
H19 JTAG Port SY S_EEPROM_WP R436 7 VCC
WC
E0
E1
2
Y 22 V8 OSCL0 0R01 1/16W 6 3
1.3K 1% AB22 DVSS VCC3IO U8 CN406 OSDA0 5 SCL E2 4 +5VSB 3V3SB
10K 1/10W
R437
10K 1/10W
R438
10K 1/10W
R439
10K 1/10W
R440
10K 1/10W
R441
AA23 DVSS VCC3IO N18 R442 R480 SDA VSS RESET Circuit
21
AB23 DVSS VCC3IO 1K 1/10W NC/0oHM R4103
820R 1/10W 1%
AC23 DVSS
DVSS
UART Port 0 M24C32-WMN6TP
TVTREF#1 1
C437 AB24 VCCK 2 R447
U408
NC/820R +-1%
DVSS 3V3SB I2C ADDRESS "A0"
AA20 JTRST# 3 4
DVSS JTDI U408
4.7UF 10V Y 20
W20 DVSS VCCK
M1
M2 JTMS
5
7
6
8 R444 R445
CN410 1
Y 19 DVSS VCCK M3 JTCK 9 10 3 GND R408
CN410
W19 DVSS VCCK M4 R446 11 12 4.7K 1/16W 4.7K 1/16W Vcc 2
DVSS VCCK JTDO
UART Port 1 RESET
M9 M5 13 14 DVDD3V3
H6 DVSS VCCK M6 15 16 U0TX 1
DVSS VCCK AZ809ANSTR-E1100R 1/16W 5%
N9 N1 33R 1/10W 5% JTAG_DBGRQ 17 18 2 R443
L12 DVSS VCCK N2 JTAG_DBGACK 19 20 U0RX 3 R448 R449
NC/1K8 +-1%
L13 DVSS VCCK N3 R450 ORESET#
DVSS VCCK
1
L14
P9 DVSS VCCK
N4
N5
10K 1/10W R451
10K 1/10W
CN406 CONN
4.7K 1/16W 4.7K 1/16W
100K 1/10W
DVSS VCCK
22
R10 N6 NC/CONN U1TX ZD124 R452
W21 DVSS VCCK K10 U1RX C438
DVSS VCCK FOR CODE DOWNLOAD AND DEBUG
AC24 K11 TVM1G5R5M100R 15pF 50V
AB25 DVSS VCCK K9
DVSS VCCK
2
M11 L9 ZD124 and C438 near U401 should be
M12 DVSS VCCK R9 VCCK
M13 DVSS VCCK K15 very close to U401
M14 DVSS VCCK K16
DVSS VCCK 27MHz CRYSTAL
M15 L10 X400 R453 NC/10K 1/10W R454 10K 1%
DVSS VCCK 3V3SB OPCTRL5
M16 T9 C439 C440 C441 C442 2 4
N11 DVSS VCCK T10 4.7UF 10V 10uF 6.3V 100N 16V 100N 16V OXTAL_I 1 3 OXTAL_O
N12 DVSS VCCK T11 R455 NC/10K 1/10W R456 10K 1/10W
N13 DVSS
DVSS
VCCK
VCCK
T12 STRAPPING OPCTRL4
N14 T13 27MHz
N15 DVSS VCCK T14 VCCK R457 10K 1% R458 NC/10K 1%
DVSS VCCK DVDD3V3 AOSDATA1
N16 T15 R459
P11 DVSS VCCK T16 NC/100K 1/10W
P12 DVSS VCCK L11
P13 DVSS VCCK L15 C443 C444 C445 C446 C447 C448
P14 DVSS VCCK R15 100N 16V 100N 16V 100N 16V 100N 16V 27P 50V 27P 50V
P15 DVSS VCCK L16
P16 DVSS VCCK R16
R11 DVSS VCCK R17
DVSS VCCK
R12
DVSS VCCK
T17 ( 42 mA )
R13 AVDD1V2 DVDD3V3
R14 DVSS AVDD12_PLL
K12 DVSS R460
K13 DVSS 0R01 C451
M10 DVSS C450 C452 C453
N10 DVSS 100N 16V 100N 16V 100N 16V
4.7UF 10V
P10 DVSS
K14 DVSS 3V3SB
DVSS 3V3SB
K17
DVSS
( 10 mA ) ( 13 mA )
L17 AVDD33_XTAL_STB AVDD33_REG_STB
N17 DVSS R461
DVSS R462
P17 0R01 0R01
W17 DVSS C454 C455
DVSS C456
V19 100N 16V 100N 16V
DVSS 10uF 10V
MT 5366GSNG
80
LC-32SV21L&LC-42SV31L
10 PREAMP/HEADPHONE OUT
2,4,5,7,8,9,11,12,13,14,15,16,18 DVDD3V3 DVDD3V3
2,4,5,7,8,9,11,12,13,14,15,16,18 AVDD3V3 AVDD3V3
2,5,7,12,13,14,15,16,17 +5V_SW +5V_SW
2,3,4,5,6,7,8,9,11,12,13,14,15,16,17,18 GND
AR0O
12 AR0O AL0O
12 AL0O
HP_PWR FB66
R620
10K 1/10W 1 2 +5V_SW
120R/3000mA
Q612 C619 1uF 25V
MMBT3906 PNP Q613
V_MUTE 2 3 MMBT3904 C614
2U2 16V
R674
R626 4K7 1/10W 5%
1
DVDD3V3
L:MUTE 47K 1/10W 5% R624
C1P
C1N
PGND
10K 1/10W 13
H:UN-MUTE TH1
R609 A_MUTE 4 12 R619
47K 1/10W 5% PVss VDD 0 OHM 1/8W
FB60130R/600mA 5 CN602 R623 5 11 HPOUT_LT
4 18K 1/10W C615 R627 SHDN OUTL
HPOUT_RT 1 2 3 AL0O 6 10
FB602 2 IN_L OUTR
SGND
30R/600mA 6 1uF 16V 43K 1/10W 1% C613 R621
SVss
IN R
HPOUT_LT 1 2 7 C617 C618 330pF 50V 47K 1/16W 5%
1 NC/330pF 50V 330pF 50V U606
FB603
9
HPDET#
1 2 30R/600mA CONN MAX9728AETC+ R631
R625 0 OHM 1/8W
18K 1/10W C620 R628 HPOUT_RT
AR0O C623
C640 C641 C642
2.2NF 2.2NF 0.1uF 50V 1uF 16V 43K 1/10W 1% 1uF 25V
R670 C624 R622
NC/470K 1/16W 5% C621 C622 330pF 50V 47K 1/16W 5%
NC/330pF 50V 330pF 50V
C634 47pF 50V
Near MT5366 R629 20K 1/10W
EMI 09/03
C635 47pF 50V change R619,R631 from 150 to 0 for
change R623,R625 from 20K to 10 for 6dB Gain output loss
R630 20K 1/10W
2008-03-14
81
LC-32SV21L&LC-42SV31L
11 AUDIO AMP
DVDD3V3
AMP3V3 2,4,5,7,8,9,10,12,13,14,15,16,18 DVDD3V3
+12V
Audio Amp 2,14,17 +12V
2 +24V
+24V
SPK_INT
13 SPK_INT
R632 AOBCLK
12 AOBCLK
10K 1% AOLRCK
12 AOLRCK
R633 AOMCLK
C625 12 AOMCLK
0R01 1/16W AOSDATA0
12 AOSDATA0
AMP3V3 PLL_Vdd I2S_MUTEB# AMP24V
U602 I2S_MUTEB#
FB61 AMP3V3 C637 19 18 13 SP_Amp_MUTE AMP_RESETN
2K2 1/16W 5% 100N 16V 1N 50V 20 EAPD/OUT4B OUT3A 17 13 AMP_RESETN A_MUTE
1 2 R634 21 TWARN/OUT4A OUT3B 16 10,17 A_MUTE
120R/3000mA PLL_FILTER 22 VDD_DIG CONFIG 15 C626 100nF 50V OSCL1
PLL_GND 23 GND_DIG VDD 14 7,9,14 OSCL1 OSDA1
C627 FB62 C628 C630 C631 24 PWRDN GND_REG 13 LOUT+ 7,9,14 OSDA1
PLL_Vdd VDD_PLL OUT1A
100N 16V 100N 16V 4N7 50V 680pF 50V FB605 1 2 120R/3000mA 25 12
1 2 26 FILTER_PLL GND1 11 2,3,4,5,6,7,8,9,10,12,13,14,15,16,17,18 GND
120R/3000mA AOMCLK FB606 1 2 120R/3000mA 27 GND_PLL VCC1 10 LOUT-
AMP3V3 FB604 AOBCLK 28 XTI OUT1B 9 ROUT+
U607 AOLRCK FB607 1 2 120R/3000mA 29 BICKI OUT2A 8
AOSDATA0 1 5 1 2120R/3000mA 30 LRCKI VCC2 7
SPK_MUTE 2 B VCC AMP_RESET# R640 0R01 1/16W 31 SDI GND2 6 ROUT-
3 A 4 SOUND_INT SPK_INT R641 100R 1/16W 5% SPK_INT_A 32 RESET OUT2B 5 C632 100nF 50V
GND Y OSDA1 R642 100R 1/16W 5% OSDA1_A 33 INT_LINE VCC_REG 4
74LVC1G08GW OSCL1 R643 100R 1/16W 5% OSCL1_A 34 SDA VSS 3
35 SCL TEST_MODE 2
C633 AMP3V3 36 GND_DIG SA 1
R644 NC/47K 1/16W 100N 16V 37 VDD_DIG
Thermal Pad
GND_SUB Speaker out
C639
C638 STA339BWTR
100N 16V 100N 16V C645
NC/10PF 50V
C643
AMP3V3 NC/10PF 50V C644
NC/10PF 50V AMP3V3
R648
10K R668
R649 LOUT+
NC/10K 1/16W 5% AMP_RESET# 10K 1/10W L63
22UH R652
SPK_MUTE
AMP_RESETN Q605 C648 6.2 OHM 1/4W C647
MMBT3904 R669 R653 1N 50V
C650
R651 C646 A_MUTE Q610 22 OHM 1/4W C649 0.1UF50V
1K 1/16W NC/2.2U10V 0.1UF50V C651
PMBS3906 C652 1N 50V
10K 1/10W C653 0.1UF50V
0.22uF 50V
C654 CN601
L
6
330P 50V 0.1UF50V C655 CONN
R654 1N 50V
SPK_INT_A L64 22UH 6.2 OHM 1/4W LOUT1+ 4 L+
LOUT- LOUT1- 3 L-
ROUT+ ROUT1+ 2 R+
L65 R655 ROUT1- 1 R-
OSDA1_A 22UH
C656 6.2 OHM 1/4W
R656 R
C659
5
22 OHM 1/4W C657 0.1UF50V C658
OSCL1_A 0.1UF50V 1N 50V
C660
C661 0.1UF50V C662
0.22uF 50V
C663 1N 50V
330P 50V 0.1UF50V R657 C664
C676 C675 C674 6.2 OHM 1/4W 1N 50V
NC/1N 50V NC/1N 50V 1N 50V ROUT-
L66
22UH
+24V
DVDD3V3 AMP3V3 AMP24V
FB64
1 2
120R/3000mA
+ +
C667 C668 C665 C669 C670 C671 C672 C666
10UF 6.3V 0.1UF50V 330UF 35V 1uF 50V 1uF 50V 0.1UF50V 0.1UF50V 330UF 35V
H:10.5mm H:10.5mm
82
LC-32SV21L&LC-42SV31L
12 A/V INTERFACE
U401F U401F
AE25
AIN0_R_AADC AR0_ADAC
Y 23 AR0O
AL0O
Analog Power 2,4,5,7,8,9,10,11,13,14,15,16,18 AVDD3V3
AVDD3V3
AB21
AIN0_L_AADC AL0_ADAC
AA25 ADAC_PWR ( 1 mA ) 2,7,8,9,14,15 AVDD1V2 AVDD1V2
AD25 2,5,7,10,13,14,15,16,17 +5V_SW
AIN1_R_AADC AVDD33_DAC AVDD33_DAC1 +5V_SW
AE22 W23
VGA_R_In AIN1_L_AADC AR1_ADAC ADAC_PWR ADAC_PWR
AC25 AA24 R463 R465 0R01
VGA_L_In AD22 AIN2_R_AADC AL1_ADAC 47ohm 1/10W +/-1% SPDIF_OUT
AIN2_L_AADC 7 SPDIF_OUT
AD23 V24 + C457 C458 C460
AB20 AIN3_R_AADC AR2_ADAC Y 25 470UF 16V 100N 16V 100N 16V AR0O
AIN3_L_AADC AL2_ADAC 10 AR0O
AV2_R_In AE24 AL0O
AIN4_R_AADC 10 AL0O
AV2_L_In AC21 V25
Y PbPr_R_In1 AE23 AIN4_L_AADC AR3_ADAC Y 24
Y PbPr_L_In1 AIN5_R_AADC AL3_ADAC H:9mm
AC20
AD24 AIN5_L_AADC V22 AVDD33_DAC
AC22 AIN6_R_AADC AVDD33_DAC V23 AVDD33_DAC1 VGA_R_In
AIN6_L_AADC AVDD33_DAC1 5 VGA_R_In
VGA_L_In
5 VGA_L_In
AVDD33_AADC AA19
AA21 AVDD33_AADC AA22
AVSS33_AADC AVSS33_DAC W22
AVSS33_DAC1
VMID_AADC TP409 AV2_R_In
AA18 5 AV2_R_In
VMID_AADC V21 AU_DIN AV2_L_In
ALIN 5 AV2_L_In
V20 R4126 SPDIF_OUT Y PbPr_R_In1
ASPDIF 4 Y PbPr_R_In1
C461 C462 T21 AOBCLK AVDD3V3 ( 13 mA ) Y PbPr_L_In1
AOBCK 4 Y PbPr_L_In1
100N 16V 1uF 10V U24 AOLRCK 0R05 4A 1/4W
AOLRCK U25 AOMCLK AVDD33_AADC
AOMCLK R21 R467
AOSDATA4 R20 0R01 AOBCLK
AOSDATA3 11 AOBCLK
T19 C463 AOLRCK
AOSDATA2 11 AOLRCK
U23 AOSDATA1 100N 16V AOMCLK
AOSDATA1 11 AOMCLK
T20 AOSDATA0 AOSDATA0
AOSDATA0 11 AOSDATA0
AOSDATA1
U401C U401C 9 AOSDATA1
FAT_IN+ AD17 W12 HSY NC HSY NC
ADCINP_DEMOD HSY NC 3 HSY NC
FAT_IN- AE17 W11 VSY NC VSY NC
ADCINN_DEMOD VSY NC
RP
AC10 RP Analog Power 3
3
VSY NC
RP
RP
AVDD33_DEMOD AC19 AC9 GP GP
AVDD33_DEMOD GP 3 GP
AVDD33_IFPGA AB19 AD9 BP AVDD1V2 ( 86 mA ) AVDD3V3 ( 9.5 mA ) BP
AVDD33_IFPGA BP 3 BP
Y 18 AB10 VGACOM VGACOM
AVSS33_DEMOD COM 3 VGACOM
AE9 SOG AVDD12_RGB AVDD33_DEMOD SOG
SOG 3 SOG
AC11 VGASDA R468 R469
AVDD12_DEMOD AB18 VGA_SDA AB12 R4127 NC/0R05 1/16W VGASCL 0R01 0R01
Y 16 AVDD12_DEMOD VGA_SCL R4128 NC/0R05 1/16W C464 C465 VGA_EEPROM_WP
AVSS12_DEMOD 3,13 VGA_EEPROM_WP
AE11 100N 16V 100N 16V
COM1 AD12 VGASCL
IF_AGCT PB1P 3 VGASCL VGASDA
R19
IF_AGC PR1P
AE12 ( 20 mA ) 3 VGASDA
P23
RF_AGC Y 1P
AD11 AVDD3V3 ( 65 mA )
AB11 CVBS1P
SOY 1 5 CVBS1P
AD20 AVDD33_CVBS AVDD33_IFPGA
AE20 LOUTN AC13 COM0 R470 R471 CVBS_COM
LOUTP COM0 5 CVBS_COM
AB14 PB0P 0R01 0R01
PB0P AC14 PR0P C466 C467
AD15 PR0P AB13 Y 0P 100N 16V 100N 16V COM0
SC0 Y 0P 4 COM0
AC15 AC12 SOY 0 PB0P
SC1 SOY 0 4 PB0P
AE15 PR0P
SY 0 4 PR0P
AB16 AD14 AVDD12_RGB Y 0P
SY 1 AVDD12_RGB 4 Y 0P
AC16 Y 14 AVDD3V3 ( 42 mA ) AVDD1V2 ( 37 mA ) SOY 0
CVBS2P AVSS12_RGB 4 SOY 0
CVBS1P AC17
AB17 CVBS1P AVDD33_VDAC AVDD12_DEMOD
CVBS_COM Y 15 CVBS0P AA15 VDAC_FS R472 R473
CVBS_COM FS_VDAC W13 0R01 0R01 FAT_IN-
VDAC_OUT1 MONITOR_OUT 16 FAT_IN-
AVDD33_CVBS W14 Y 12 C468 C469 FAT_IN+
AVDD33_CVBS VDAC_OUT2 TP423 16 FAT_IN+
W16 R474 100N 16V 100N 16V
AVSS33_CVBS AA14 AVDD33_VDAC 560R IF_AGCT
AVDD33_VDAC 16 IF_AGCT
W15
AVSS33_VDAC
R4020
MT 5366GSNG AVDD3V3
75 OHM 1/16W R479 NC/0R01
+5V_SW U411
G1117-33T63Uf R475 ADAC_PWR
3 2
VI VO 0R01
GND
C471 C470
1UF 10V 10uF 6.3V
4
2,3,4,5,6,7,8,9,10,11,13,14,15,16,17,18 GND
1
2008-03-14
83
LC-32SV21L&LC-42SV31L
13 GPIO INTERFACE
U401E
UART_SW E25 R25 DEMOD_TSCLK
ARC_OE G24 GPIO0 DEMOD_TSCLK R24 DEMOD_TSVAL
TP490 GPIO1 DEMOD_TSVAL DEMOD_TSSY NC DEMOD_RST
F23 R22
SY S_EEPROM_WP H25 GPIO2 DEMOD_TSSY NC N19 DEMOD_TSDATA0 15,16 DEMOD_RST
G23 GPIO3 DEMOD_TSDATA0 UART_SW
GPIO4 3 UART_SW
LVDS_PWR_EN E24 P25 SPK_INT
GPIO5 CI_TSCLK 11 SPK_INT
H20 N20 AMP_RESETN
GPIO6 CI_TSVAL 11 AMP_RESETN
GPIO_7 G21 P21
TP491 GPIO_8 H21 GPIO7 CI_TSSY NC P24
TP492 GPIO9 GPIO8 CI_TSDATA0
E22
TP489 GPIO9 SP_Amp_MUTE
F22 P22 DVDD3V3 11 SP_Amp_MUTE
F21 GPIO10 PVR_TSCLK M21
GPIO_12 G20 GPIO11 PVR_TSVAL M20 LVDS_PWR_EN
TP484 GPIO12 PVR_TSSY NC 14 LVDS_PWR_EN
HPDET# H24 M19 MUTE_CTL
TP485 GPIO13 PVR_TSDATA0 17 MUTE_CTL
USB_PWR_EN0 G25 R4111 HPDET#
GPIO14 10 HPDET#
G22 N22 NC/10K 1/16W SY S_EEPROM_WP
GPIO15 PVR_TSDATA1 9 SY S_EEPROM_WP
P6 ARC_OE
GPIO16 7 ARC_OE
R6 N21 VGA_EEPROM_WP
GPIO17 SPI_CLK 3 VGA_EEPROM_WP
HDMI_SW_RST P5 M22 STANDBY
GPIO18 SPI_DATA 2 STANDBY
SP_Amp_MUTE P4 M25 USB_PWR_EN0
GPIO19 SPI_CLE 5 USB_PWR_EN0
SPK_INT P3 M24 USB_OC_COM
TP494 GPIO20 CI_INT 5 USB_OC_COM
LED_POWER_GREEN P2 R23 DEMOD_RST
STANDBY P1 GPIO21 DEMOD_RST
AMP_RESETN R5 GPIO22 AA3 ETCOL C496 OPCTRL1
GPIO23 ETCOL 17 OPCTRL1
VGA_EEPROM_WP U5 W5 ETTXEN NC/100N 16V OPCTRL4
GPIO24 ETTXEN 9 OPCTRL4
BL_ON/OFF U6 Y5 ETTXD3 OPCTRL5
GPIO25 ETTXD3 9 OPCTRL5
V6 Y3 ETTXD2
PHY RST# U7 GPIO26 ETTXD2 Y2 ETTXD1
ADIN1_SRV ADIN0_SRV ADIN4_SRV GPIO27 ETTXD1 Y1 ETTXD0
AD8 ETTXD0 W2 ETTXCLK_REF_CLK DEMOD_TSCLK
OPCTRL0 ETTXCLK 15 DEMOD_TSCLK
OPCTRL1 AE8 Y4 ETRXDV DEMOD_TSVAL
OPCTRL1 ETRXDV 15 DEMOD_TSVAL
AA8 W3 ETRXD3 DEMOD_TSSY NC
OPCTRL2 ETRXD3 15 DEMOD_TSSY NC
R4106 R4105 R4107 MUTE_CTL AE6 W4 ETRXD2 DEMOD_TSDATA0
OPCTRL3 ETRXD2 15 DEMOD_TSDATA0
10K 1% 10K 1% 10K 1% OPCTRL4 AB7 V3 ETRXD1
OPCTRL5 Y7 OPCTRL4 ETRXD1 V4 ETRXD0
OPCTRL5 ETRXD0 W1 ETRXCLK_C50M_O OIRI
ETRXCLK 9,17 OIRI
ADIN0_SRV AA9 AA4 PHY _REFCLK_E
ADIN1_SRV AA11 ADIN0_SRV ETPHY CLK V5 ETMDIO
USB_OC_COM Y 10 ADIN1_SRV ETMDIO W6 ETMDC
KEY _MENU_L_R_SOURCE W9 ADIN2_SRV ETMDC
ADIN4_SRV W10 ADIN3_SRV T6 BL_DIMMING
ADIN4_SRV OPWM2 2 BL_DIMMING
KEY _UP_DN_DCSW Y 11 T5 BL_DIMMING BL_ON/OFF
ADIN5_SRV OPWM1 2 BL_ON/OFF
R7
OPWM0
MT 5366GSNG HDMI_SW_RST
7 HDMI_SW_RST
1
14 LVDSVDD LVDSVDD
2K2 1/10W 1%
12 ADAC_PWR ADAC_PWR
R477 R495 FB125
2K2 1/10W 1% +5V_SW
4.7K 1/10W 220R/2000mA
CN407
2
SMD/0402
2,3,4,5,6,7,8,9,10,11,12,14,15,16,17,18 GND
1
LED_POWER_GREEN R493 SMD/0402
100R 1/16W 5% LED_G 2
OIRI R478 SMD/0402OIRI_IRboard
100R 1/16W 5% 3
4
5
6 MII Interface
7 ETCOL
18 ETCOL
KEY _UP_DN_DCSW R491 22 OHM 1% Key 1 8 ETTXEN
18 ETTXEN
KEY _MENU_L_R_SOURCE SMD/0402 Key 2 9 ETTXD3
18 ETTXD3
R490 22 OHM 1% KEY _EN 10 ETTXD2
18 ETTXD2
SMD/0402 11 ETTXD1
18 ETTXD1
12 ETTXD0
18 ETTXD0
C491 C495 13 ETTXCLK_REF_CLK
18 ETTXCLK_REF_CLK
1
1
R492 100N 16V 100N 16V ETRXDV
18 ETRXDV
NC/10K 1/16W 5% SMD/0402 SMD/0402 ETRXD3
18 ETRXD3
SMD/0402 C494 C492 C493 ETRXD2
18 ETRXD2
100N 16V 10N 50V ZD421 ZD422 ZD423 ZD424 ZD425 ZD426 100N 16V CONN ETRXD1
18 ETRXD1
SMD/0402 SMD/0402 TVM1G5R5M100R TVM1G5R5M100R TVM1G5R5M100R SMD/0402 ETRXD0
18 ETRXD0
TVM1G5R5M100R TVM1G5R5M100R TVM1G5R5M100R ETRXCLK_C50M_O
18 ETRXCLK_C50M_O
2
PHY _REFCLK_E
18 PHY _REFCLK_E
ETMDIO
18 ETMDIO
ETMDC
18 ETMDC
PHY RST#
18 PHY RST#
84
LC-32SV21L&LC-42SV31L
14 LVDS OUTPUT
U401D
AVDD33_USB_2P AB1
V7 AVDD33_USB_2P AVDD33_LVDSA
E18
E19
AVDD33_LVDSTX
Analog Power 2,17 +12V
2,4,5,7,8,9,10,11,12,13,15,16,18 AVDD3V3
+12V
AVDD3V3
AVSS33_USB_2P AVDD33_LVDSA
2,7,8,9,12,15 AVDD1V2 AVDD1V2
AVSS33_LVDSA
E16 AVDD3V3 ( 180 mA ) 2,5,7,10,12,13,15,16,17 +5V_SW +5V_SW
USB_VRT AC3 E17
USB_2P_VRT AVSS33_LVDSA AVDD33_LVDSTX 2,7,8,9,12,15 AVDD1V2 AVDD1V2
R496
LVDSVDD LVDSVDD
0R01 2,4,5,7,8,9,10,11,12,13,15,16,18 DVDD3V3 DVDD3V3
R497 USB_DP0 AB2 F19 AVDD12_VPLL AVDD3V3 ( ?? mA )
5.1K 1/16W USB_DM0 AC1 USB_2P_DP0 AVDD12_VPLL G19 C482 C483
USB_2P_DM0 AVSS12_VPLL 2,3,4,5,6,7,8,9,10,11,12,13,15,16,17,18 GND
R498 AVDD33_USB_2P 100N 16V 100N 16V
AC2 0R01
AD1 USB_2P_DP1 A24
USB_2P_DM1 TP_VPLL C484 AVDD1V2 ( 6.5 mA )
Close to 5366. D17 E0P 100N 16V LVDS_PWR_EN
AE0P 13 LVDS_PWR_EN
C17 E0N R499 AVDD12_VPLL
AE0N C19 E1P 0R01
AE1P D19 E1N
AE1N D20 E2P C485 C486
AE2P C20 E2N 100N 16V 100N 16V
AE2N C21 ECKP
AECKP D21 ECKN
AECKN D23 E3P
AE3P C23 E3N
AE3N C24 E4P USB_DP0
AE4P E4N 5 USB_DP0 USB_DM0
D24
AE4N 5 USB_DM0
D25
32
AE5P C25 Panel_12V
AE5N CN409
A17 O0P 30 OSDA1
AO0P O0N 7,9,11 OSDA1 OSCL1
B17 29 CONN
AO0N O1P 7,9,11 OSCL1
A18 28
AO1P B18 O1N 27
AO1N A19 O2P 26
AO2P B19 O2N 25
AO2N A20 OCKP 24
AOCKP B20 OCKN 23
AOCKN A21 O3P LVDS_f ormat 22
AO3P B21 O3N 21
AO3N A22 O4P 20
AO4P B22 O4N O0N 19
DVDD3V3 AO4N A23 O0P 18
AO5P B23 17
AO5N O1N 16
MT 5366GSNG O1P 15
14
O2N 13
O2P 12
11
OSDA1 OCKN 10
OCKP 9
Q403 NC/2N7002 8 +5V_SW FB401 NC/120R/6000mA
O3N 7
O3P 6 1 2
42
CN408 5
4 +12V LVDSVDD
OSCL1 LVDS_SDA 40 39 LVDS_SCL 3
E4N 38 37 E4P 2 FB402 1 2 120R/6000mA
Q404 NC/2N7002 E3N 36 35 E3P DVDD3V3 1
34 33
5
6
7
8
ECKN 32 31 ECKP
30 29 R4000 C487
S
D
D
D
31
E2N 28 27 E2P R4002 47K 1/10W 5% 330N 25V
E1N 26 25 E1P NC/0R05 1/16W
G
D
D
D
DVDD3V3 E0N 24 23 E0P
O4N 22 21 O4P Q400
4
3
2
1
O3N 20 19 O3P R4001 AON4421
18 17
FPC Connector
OCKN 16 15 OCKP
HI = > LVDS POWER ON
14 13 LO = > LVDS POWER OFF 47K 1/10W 5%
R4008 O2N 12 11 O2P R4005
NC/0R05 1/16W O1N 10 9 O1P NC/0R05 1/16W LVDSVDD
O0N 8 7 O0P
LVDS_f ormat 6 5 Panel_12V FB404
LVDS_PWR_EN
R4004 20K 1/10W LVDS POWER Control
4 3
Panel_12V 2 1 1 2 Q402
120R/6000mA BC847C
R4009
NC/0R05 1/16W CONN + R4006 R4007 C488
41
2008-03-14
85
LC-32SV21L&LC-42SV31L
15 SBTVD DEMOD
X100
41.0MHz
C164 C165
2
1 3 FB126 AVDD2V5_demod
2,4,5,7,8,9,10,11,12,13,14,16,18 DVDD3V3 DVDD3V3
120R/3000mA
2,7,8,9,12,14 AVDD1V2 AVDD1V2
12P 50V 12P 50V U113 2,5,7,10,12,13,14,16,17 +5V_SW +5V_SW
4
1 2 FB111 G1117T63Uf
T_AVDD1V2 AVDD1V2
FB119 1 2 3 2 2,3,4,5,6,7,8,9,10,11,12,13,14,16,17,18 GND
+5V_SW VIN VOUT
120R/3000mA
220R/2000mA
GND
16 AVDD2V5_tuner
R1105 1 2 AVDD2V5_tuner
TH
T_DVDD1V2
470R 1/10W 1% C158 + C134
FB115 1uF 16V 100UF 16V
4
R1114
R1120 2 1 120R 1% 1/10W
T_DVDD3V3 DVDD3V3
T_AVDD2V5_demod T_AVDD1V2 T_DVDD1V2 0R05 1/16W 120R/3000mA
C184
DEMOD_RST
C185 C186
C132 R1115
100N 16V NC/10U 10V 120R 1% 1/10W
100N 16V 100N 16V DEMOD_RST
13,16 DEMOD_RST
OSCL2
9 OSCL2 OSDA2
Vo=1.25 x (1+120R/120R) = 2.5V
36
35
34
33
32
31
30
29
28
27
26
25
9 OSDA2
U406
XTALO
PVSS
OSCMODE
RST_X
OSCEN_X
CVDD3
CVSS3
SLVADR0
XTALI
XVDD
PVDD
DEMOD_TSCLK
DEMOD_TSVAL DEMOD_TSCLK 13
FB116 220R/2000mA DEMOD_TSSY NC DEMOD_TSVAL 13
FAT_IN+_C 37 24 DEMOD_TSDATA0 DEMOD_TSSY NC 13
TAINM TESTMODE T_AVDD2V5_demod 1 2 AVDD2V5_demod DEMOD_TSDATA0 13
FAT_IN-_C 38 23 C174
TAINP CVSS2 100N 16V FB117 220R/2000mA
39 22 FAT_IN-_C
TAVSS CVDD2 T_DVDD1V2 16 FAT_IN-_C FAT_IN+_C
C180 AVDD2V5_tuner 1 2
T_AVDD2V5_demod 100N 16V 40 21 R1116 OSDA2 16 FAT_IN+_C
TAVDD SDA 0R05 1/16W IF_AGC
16 IF_AGC
41 20 R1117 OSCL2 TUNER_CLK_Demod
SLVADR1 SCL 16 TUNER_CLK_Demod TUNER_DATA_Demod
R1104 0R05 1/16W 16 TUNER_DATA_Demod
NC/0R05 1/16W 42 19
XTALSEL DVDD2 T_DVDD3V3
43 18 C176 C159 C160
C188 VSS3 VSS2 100N 16V NC/10PF 50V NC/10PF 50V
T_DVDD1V2 100N 16V 44 17
CVDD4 TSDATA7
TUNER_DATA_Demod 45 16
TTUSDA TSDATA6
TUNER_CLK_Demod 46 15
TTUSCL TSDATA5
47 14
GPIO1 TSDATA4
IF_AGC 48 13
TIFAGC TSDATA3 R1112 22R 1/10W 5% DEMOD_TSDATA0
TSDATA0
TSDATA1
TSDATA2
TSVALID
TSSYNC
49 FB112
DVDD1
CVDD1
TSCLK
CVSS1
E-Pad
GPIO0
GPIO2
R1111
VSS1
10
11
12
C177
C181 100N 16V
100N 16V
T_DVDD1V2
T_DVDD3V3
86
LC-32SV21L&LC-42SV31L
16 TUNER
Close to TUNER
FB129 220R/2000mA +5V_SW
DVDD3V3
+5V_T1 1 2
2,5,7,10,12,13,14,15,17 +5V_SW +5V_SW
12
13
14
15
16
17
2,4,5,7,8,9,10,11,12,13,14,15,18 DVDD3V3 DVDD3V3
C191 C192 Close to TUNER
100N 16V 10uF 10V
2,3,4,5,6,7,8,9,10,11,12,13,14,15,17,18 GND
CASE1
CASE2
CASE3
CASE4
CASE5
CASE6
R1157 R1158
3.3K 1/16W 3.3K 1/16W AVDD2V5_tuner
15 AVDD2V5_tuner
SMD/0402 SMD/0402
TU101
R1175
SUT-RB211T NC/0R01
R1174 R1156
Analog_IFAGC 4.7K 1/16W 10K 1% IF_AGCT
C1104 SMD/0402
TU102 10N 50V R1173
NC/SUT-RA217 SMD/0402 22K 1/16W C1108
47N 16V
1 Analog_IFOUT2P
IF_P
2 Analog_IFOUT2N
IF_N
3 Analog_IFAGC
AGC
4 T_SCL
I2C_SCL
5 T_SDA
I2C_SDA
6 A2.5V
A2.5V
7 DEMOD_RST
RESET
TH5
TH4
TH3
TH2
TH1
12
11
10
9
8
IFOUT1P R1151
IF BPF
NC/0R05 1/16W
C1114
47pF 50V C1109
C1112 C1105 82pF 50V
NC/47pF 50V C1113 1uF 25V
Analog_IFOUT2P FAT_IN2+ R1153 R1148 100R 1/16W 5% FAT_IN+ IFOUT1P FAT_IN1+ R1163 R1164 FAT_IN+_C
47 OHM 1/16W 47 OHM 1/16W
1uF 25V 0R05 1/16W
R1150
IFOUT1N FAT_IN1- R1165 R1166 FAT_IN-_C
C1117 150R 1/10W 5%
47 OHM 1/16W 47 OHM 1/16W
Analog_IFOUT2N FAT_IN2- R1154 R1149 100R 1/16W 5% FAT_IN- C1106
0R05 1/16W 1uF 25V C1111
1uF 25V 82pF 50V
C1118 C1116
NC/47pF 50V 47pF 50V
IFOUT1N
Close to TUNER Close to ISDB-T Demod
R1152
NC/0R05 1/16W
Close to MT5366
Close to TUNER
2008-03-14
87
LC-32SV21L&LC-42SV31L
17 RS-232
+5VSB C1119 2 1
1uF 25V
RS232 FB140
3V3SB
13 MUTE_CTL
MUTE_CTL
2
80 OHM 10 V_MUTE V_MUTE
1uF 25V U116
C1120
10,11 A_MUTE A_MUTE
R1136 ZD131 1 16
NC/1K 1/16W TVM1G5R5M100R 2 C1+ VCC 15
SMD/0402 3 V+ GND 14 TXD_12
CN105 4 C1- DOUT1 13 RXD_12
C2+ RIN1
1
11 1 R1137 100R 1/16W 5% 5 12 U0RX U0TX
C2- ROUT1 U0TX 3,9 U0TX U0RX
6 SMD/0402 6 11
TXD_12 V- DIN1 3,9 U0RX
2 R1138NC/100R 1/16W 5% 7 10
7 SMD/0402 1uF 25V 8 DOUT2 DIN2 9 OIRI
RIN2 ROUT2 9,13 OIRI
3 R1139NC/100R 1/16W 5% RXD_12 IR_LINK
1
D-SUB 9P
ZD132 ZD133 ZD134 3V3SB
H:8.5mm
2,3,4,5,6,7,8,9,10,11,12,13,14,15,16,18 GND
3V3SB +5VSB
2
R1146
4.7K 1/10W
R1141 R1142
TVM1G5R5M100R TVM1G5R5M100R 10K 1% NC/10K 1/16W 5% Q108
2N7002
NC/TVM1G5R5M100R
REMOTE_5V R1144100R 1/16W 5% R1145 OIRI
0R05 1/16W
IR_LINK
Mute Circuit
D103
BAV70
First Drop HI = > UN-M UTE
+12V
+12V +5V_SW +5VSB V_MUTE LO = > M UTE V_MUTE NC/BAS32L
+
C1124
NC/100uF 25V
R658 A_MUTE R659
R661 R662 10K 1/10W 10K 1/10W
R660 NC/10K 1/10W 10K 1/10W
NC/27K 1/10W
R663 Q606 Q607 R664 D104
LO = > M UTE
1K 1/10W 1% MMBT3904 MMBT3904 1K 1/10W 1% HI = > UN-M UTE
R665 +5V_SW
Q608 MUTE_CTL NC/BAS32L
MMBT3904 C673 Q609
220N 25V MMBT3904 1K 1/10W 1% R667
R666
4.7K 1/10W
2.2K 1/10W
Power Detect
88
LC-32SV21L&LC-42SV31L
18 ETHERNET
2,3,4,5,6,7,8,9,10,11,12,13,14,15,16,17 GND
ETTXD0 ETRXD0
DV33_MII R262 NC/1K5 1/16W 5% U262 ETTXD1 ETRXD1
2,4,5,7,8,9,10,11,12,13,14,15,16 DVDD3V3 DVDD3V3
FB262 ETTXD2 ETRXD2
ETMDC MDC
R263
NC/0R05 1/16W 25 32 REGOUT ETTXD3 ETRXD3
ETMDIO MDIO
R264
NC/0R05 1/16W 26 MDC PWFBOUT 36 1 2 DV33_MII
ETTXD0 8 1 TXD0 6 MDIO AVDD33 NC/120R/500mA
ETTXD1 7 2 TXD1 5 TXD0
ETTXD2 6 RP261 3 TXD2 4 TXD1
TXD2 AGND
29 C262 MII Interface
ETTXD3 5 NC/22R 4 TXD3 3 35 NC/100N 16V C297 C298 C299 C2100 C289 C290 C291 C292 ETCOL
TXD3 AGND 13 ETCOL
FB266 ETTXEN R265 NC/0R05 1/16W
TX_EN 2 NC/5PF 50V NC/5PF 50V NC/5PF 50V NC/5PF 50V ETTXEN
TXEN 13 ETTXEN
ETTXCLK_REF_CLK
1 2 TX_CLK 7 NC/5PF 50V NC/5PF 50V NC/5PF 50V NC/5PF 50V ETTXD3
TXC 13 ETTXD3
NC/120R/500mA ETRXDV R267 NC/0R05 1/16W
RX_DV 22 ETTXD2
RXDV 13 ETTXD2
ETRXD0 8 1RXD0 21 27 13 ETTXD1
ETTXD1
ETRXD1 RP2627 2RXD1 20 RXD0 NC ETTXD0
RXD1 13 ETTXD0
FB267 ETRXD2 NC/22R 6 3RXD2 19 13 ETTXCLK_REF_CLK
ETTXCLK_REF_CLK
NC/120R/500mA ETRXD3 5 4RXD3 18 RXD2 ETRXDV
RXD3 13 ETRXDV
ETRXCLK_C50M_O1 2 RX_CLK 16 30 MDI_RN TXD0 RXD0 ETRXD3
RXC TPRX- 13 ETRXD3
ETCOL R269 COL
NC/0R05 1/16W 1 31 MDI_RP TXD1 RXD1 ETRXD2
COL TPRX+ 13 ETRXD2
R270 NC/5.1K 1% CRS/LEDMOD23 TXD2 RXD2
13 ETRXD1
ETRXD1
CRS
NC/5.1K 1%
11
C2102 C2103 17 DGND
MII ETHERNET PHY
NC/120R/500mA
45 DGND
FB263
16
LED2/PHY AD2 R279 CN106
NC/5.1K 1% 1
SET PHY ADDRESS 00001
TH1
MDI_TP 2 TCT P1
LED0/PHY AD0 DV33_MII
LINKED IN 10BT/ACT(BLINKING) MDI_TN TD+ P2
R280 3
NC/5.1K 1% MDI_RP 4 TD- P3
LED3/PHY AD3 R281 MDI_RN 5 RD+ P4
LINK RD- P5
NC/5.1K 1% 6
LED1/PHY AD1 R282 7 RCT P6
LINKED IN 100BT/ACT(BLINKING) NC P7
NC/5.1K 1% 8
9 NC P8
LED4/PHY AD4 R283 R286 R261 10 NC P9
FULL DUPLEX NC P10
NC/5.1K 1% NC/49.9 OHM 1% 1/16W NC/49.9 OHM 1% 1/16WC281 C282 C283 C284 11
NC/10PF 50V NC/10PF 50V NC/510R 1/16W 5% R284 12 NC P11
COLLIISON Y - P12
NC/10PF 50V NC/10PF 50V LED3/PHY AD3 13
DV33_MII 14 Y + P13
G- P14
TH2
LED0/PHY AD0 R285 15
NC/510R 1/16W 5% G+ P15
C271 Add EMI
17
X402 NC/100N 16V
solution(05/10)
2
DV33_MII
ISOL RPTR FB265
REGOUT 1 2 REGIN
R291 R292 R294 NC/120R/500mA
NC/5.1K 1% NC/5.1K 1% NC/5.1K 1%
C275 C280 C276 C277 C278
NC/10uF 10V NC/100N 16V
NC/10uF 10V NC/10N 50V NC/100N 16V
MII_SNIB
NEAR U261 NEAR U261
Pin32 Pin8
2008-03-14
89
LC-32SV21L&LC-42SV31L
[2] POWER SCHEMATIC DIAGRAM (for 32″)
B+_390V B+
C9823
D9804 220PF R9401,R9402,R9403,R9404
FB9902
BEAD
IN5408G-04 ! FB9909
BEAD R9348
100K 1/4W
0.1 ohm
1 2 1 2 1 2
10
1
6
BD901 R950,R951 100OHM 1/4W
KBJ1008 L9801 D9802 FB9907
C950,C951 0.001uF
+
300uH FMN-1106S BEAD R9307 R9309
RV9904 T9301
!
1
3 2 C9810 NC + POWER X'FMR R9350
1UF450V C9801 C9811 1 +5VS
100uF M 450V 10NF 1KV C9329 C9350
- FB9901 1NF R9351
R9308 R9310 CN902
1 2 2 6
4
3
7 D9350 C9351 ON/OFF 1
BEAD D9805 MBRF2060CT 2
PDIM
SS0520 9 2 3
+5V
2 1 R9820 D9330 3 10 L9350 4
1MOHM +-1% 1/4W PR1007 4 3.5uH 12V 5
R9832
2.5A 6
1
R9811 22OHM +-5% 1/8W Q9801 + C9353 + 7
2 3 R9810 10K 1/8W TK10A60D 330UF 16V C9354 C9374 8
FB_1 +24V
NC 5 470uF 16V 0.1uF 50V 9
RV9908 L9902 RV9907 R9813 R9331 10
PS_ON
DSPL201M-A21F 13mH DSPL201M-A21F 47 OHM R9337 2.4 OHM 1/4W 11
1 4 4.7 MOHM +-5% 1/4W
Vcc
! +5V
12
13
! Vcc_1 R9824
1K 1/8W R9814 IC9301
D9303
1N4148W
D9335
PR1007
10K 1/8W R9821 A6069H
C9812 1MOHM +-1% 1/4W 4 5 CONN
C9902 56PF 50V 3 FB/OLP VCC
! 0.47uF 305V 2
1
GND
BR D/ST
7
8
S/OCP D/ST
8
7
6
5
C9813
0.1uF 50V +
VCC
COMP OUT
RAMP GND
ZCD
+ C9309 C9331 R9354
24V 12V
C9903 C9904 C9814 IC9801 R9815 1N 50V R9302 100uF/50V 220 OHM 1/8W
! 470pF 250V ! 470pF 250V 22uF/50V LD7591GS 470 OHM 1/8W 2.4 OHM 1/4W C9333 + C9308
FB_1
INV
22uF/50V 0.1uF 50V FB909
CS
R9801 R9822 BEAD C930 C931
0.15R 1MOHM +-1% 1/4W 470pF 250V 470pF 250V
1
2
3
4
2
R9301 1 2 IC950 ZD952 ZD951
C9905 2.4 OHM 1/4W TLP781F GDZJ30B GDZJ16B
! 470pF 250V C9815
220PF ! ! ! 4 1
A5V
2 1
1 1
R9817 C9816 Vcc_1 Vcc +5VS 3 2 R9355
33K 1/8W 5% NC 1K 1/8W
D955
! R9818 Q9321
2SD1624T-TD-E
+5V A5V BAV70
3
RV9906 L9901 RV9905 PR1007 NC R9339 R9360 C9355 R9356
DSPL201M-A21F 13mH DSPL201M-A21F C9817 C9818 10K 1/8W 1K OHM 220N 50V 1K 1/8W
1 4 47N 50V 0.47UF 50V IC9351
+ TLP781F R9357 R981
C9337 4 1 2.4K 1% 1/8W Q970 R983 1K 1/8W
10uF/50V IC9352 PMBS3904 1K 1/8W
AS431AZTR-E1
C9901
0.47uF 305V
R9304 R9305 R9306 ! 3 2 Q9350
RK7002FD5T116 R9361
10K OHM +-5% 1/8W R982
!
2
R904,R905,R909 R9311
PS_ON
R9358 C978 10K 1/8W
C9321 560K 1/8W ZD9301 R9359 2K2 1/8W 1% 0.1uF 50V
R901 R902 R903
1.5M 1% 1/4W 0.47UF 50V GDZJ16B NC
300K 1/4W NC 300K 1/4W C9356
0.1uF 50V R9363
1
330K 1% 1/8W
B+
24V
IC901
CAP004DG
D9102
1 8 SS0520 T9101 FB9104 R912,R913,R914,R915
2
3
NC
D1
NC
D2
7
6 R9105
2 1 Q9101
TK10A50D
! POWER X''FMR D9151
FMEN-2308
C9151
1000UF 35V
BEAD
5.1K 1/4W
D1 D2
2
3
R9110
C901 47pF R9106 47 OHM 7 CN903
1MOHM +-1% 1/4W Vcc_1 FB R9111 2
1
1
1
3 16 9
C9107 C9114 4 FB VGH 15 D9103 Q9102 10
2 1 SG9907 0.1uF 50V 0.47UF 50V 5 GND VS 14 SS0520 TK10A50D 11
Css VB ON/OFF
DA38-622MT-A21F + 6 13 2 1 12 12
C9108 7 OC NC 12 13
RC NC PDIM
10uF/50V 8 11
CN901 9 Reg VGL 10
! SOCKET RV COM R9116
47 OHM C9115 FB9105 CONN
1
D9105 33NF D9153 BEAD
R9109 UF4007 MBRF2060CT
12V
13KOHM +-1% 1/8W C9109 2 1 2
100N 50V
R9119
HS9801 HS9105
HEAT SINK HEAT SINK 10R 1/8W 5% R9117
3
C9117 10K OHM +-5% 1/8W + C9155 + C9156 C9157
1 1 1U 25V 470UF 25V 100uF/50V 100N 50V +24V
2 2
C9119 D9156
10PF 3KV SR506
D9802 D9151 FB908 24V
BEAD C928 C929
470pF 250V 470pF 250V R9121
HS9802 HS9104 1 2 1K 1/8W
HEAT SINK HEAT SINK
1
2
1
2
! ! C9124
100PF 2KV FB D9154 R9155
24V
C9160
47UF 50V
+ R9162
HS9101
HEAT SINK R9159
R9123 56K 1/8W +/-1%
1 560OHM +-5% 1/8W IC9102
2 TLP781F R9161
4 1 R9157 Q907 20K5 1/8W 1%
FB910 R9125 3K 1/8W PMBS3906 C9158
Q9101,Q9102 BEAD C932 C933 24K 1/8W 470NF 50V
470pF 250V 470pF 250V 3 2
1 2
HS9901 HS9103 C9127
HEAT SINK HEAT SINK
! !
100N 50V !
1 1
2 2 +
C9128 C9159 R9158
4.7uF 50V 100N 50V 20K 1/8W 1%
BD901 D9153
R9160
2KOHM +-1% 1/8W
IC9103
AS431AZTR-E1
90
LC-32SV21L&LC-42SV31L
POWER SCHEMATIC DIAGRAM (for 42″)
B+_390V B+
D9804 C9823 R9401,R9402,R9403,R9404
FB9902 IN5408G-04 220PF FB9909
BEAD BEAD R9348
100K 1/4W
1 2 1 2
! 1 2
0.1R
11
12
1
7
8
BD901 R950,R951 100OHM 1/4W
GBJ1008 L9804 D9802 FB9907
C950,C951 0.001uF
+
170uH FMNS-1106S BEAD R9307 R9309
RV9904
3 2 C9810
1UF450V
! NC +
C9824
+
C9825 C9811
C9329
1NF 1
T9301
POWER X'FMR
R9350
+5VS
2
C9826 100uF M 450V 100uF M 450V 10NF 1KV C9350
FB9901 10NF 1KV R9351
-
3
7 D9350 C9351 ON/OFF 1
BEAD D9805 MBRF2060CT 2
PDIM
SS0520 9 2 3
+5V
2 1 D9330 3 10 L9350 4
R9820 PR1007 4 3.5uH 12V 5
R9832 1MOHM +-1% 1/4W
2.5A 6
1
R9811 22OHM +-5% 1/8W Q9801 + C9353 + 7
2
8
7
6
5
C9813
24V 12V
100NF 50V +
VCC
COMP OUT
RAMP GND
ZCD
+ R9822 C9309 C9331 R9354
C9903 C9904 C9814 IC9801 R9815 1MOHM +-1% 1/4W 1N 50V R9302 100UF 50V 220R 1/8W 5%
! 470pF 250V ! 470pF 250V 22uF/50V LD7591GS 470OHM +-5% 1/8W 2.4 OHM 1/4W C9333 + C9308
FB_1
INV
22uF/50V 100NF 50V FB909
CS
2
R9802 BEAD C930 C931 ZD951 ZD952
R9801 0.2 OHM +-5% 2WS 470pF 250V 470pF 250V GDZJ16B GDZJ30B
1
2
3
4
0.2 OHM +-5% 2WS R9301 1 2 IC9350
C9905 2.4 OHM 1/4W TLP781F
! 470pF 250V C9815 ! 4 1
! ! A5V
1
220PF
1
33K 1/8W 5% NC 1K 1/8W
D955
! R9818 Q9321
2SD1624T-TD-E
+5V A5V BAV70
3
RV9906 L9901 RV9905 PR1007 NC R9339 R9360 C9355 R9356
DSPL201M-A21F 13mH DSPL201M-A21F C9817 C9818 10K 1/8W 1K 1/6W 5% 220N 50V 1K 1/8W
1 4 47N 50V 470NF 50V IC9351
+ TLP781F R9357 R981
C9337 4 1 2.4K 1% 1/8W Q970 R983 1K 1/6W 5%
10uF/50V IC9352 PMBS3904 1K 1/8W
R9304 R9305 R9306 AS431AZTR-E1
C9901 ! 3 2
! 0.47uF 305V Q9350 R9361 R982
2
R9304,R9305,R9306 R9311 RK7002BM 10K 1/8W R9358 C978 10K 1/8W
C9321 560K +-5% 1/8W ZD9301 R9359 2K2 1/8W 1% 100NF 50V
R901 R902 R903
1.5M 1% 1/4W 470NF 50V MTZJ T-72 16B
PS_ON
NC
300K 1/4W NC 300K 1/4W
1
C9356 R9363
100NF 50V 330K 1% 1/8W
2
t R9104
B+ 0.1R
24V
IC901 NR902
CAP004DG
D9102 D9151
1
NC NC
8 SS0520 FMEN-2308 R912,R913,R914,R915
1
3
2 7 2 1 Q9101 C9151 C9152 L9104
3 D1 D2 6 R9105 TK10A50D T9101 1000UF 35V 1000UF 35V 3.0uH+-10%
5.1K 1/4W
D1 D2
2
1
C901 47pF R9106 47OHM +-5% 1/8W CN903
1MOHM +-1% 1/4W Vcc_1 FB R9111 10
!
1
10K 1/8W 9 1
+ + + R9151 R9152 R9153 R9154 2
R9107 2 C9153 C9154 3
1
3
FUSE FUSE Varistor-NC 1 18 1U 25V 7 FMEN-2308 7
CN901 2 Vsen NC 17 8
! ! Vcc NC
2
3 16 12 2 9
C9107 C9114 4 FB VGH 15 D9103 Q9102 11 10
2 1 SG9907 100NF 50V 470NF 50V 5 GND VS 14 SS0520 TK10A50D 11
Css VB ON/OFF
DA38-452MT-A21F-M-NC + 6 13 2 1 12
OC NC
1
C9108 7 12 13
RC NC PDIM
10uF/50V 8 11 14
Reg VGL
3
9 10
! AC SOCKET RV COM R9116
47OHM +-5% 1/8W C9115 D9153
CONN
3
D9105 18NF MBRF2060CT L9105
R9109 UF4007 3.5uH
12V
13KOHM +-1% 1/8W C9109 R9117 2
HS10 100NF 50V 10K 1/8W
R9119
HEAT SINK
10R 1/8W 5%
1
1 C9117 + C9155 + C9156 C9157
2 1U 25V 1000UF 35V 470UF 25V 100NF 50V +24V
C9119 D9156
BD901 10PF 3KV SR506
FB908 24V
BEAD C928 C929
HS11 HS20 470pF 250V 470pF 250V R9121
HEAT SINK HEAT SINK 1 2 470OHM +-5% 1/8W
1 1
2 2 ! ! C9124
100PF FB D9154 R9155
24V
C9160
47UF 50V
+ R9162
HS12 HS21
HEAT SINK HEAT SINK
R9159
1 1 R9123 56K 1/8W +/-1%
2 2 560OHM +-5% 1/8W IC9102
TLP781F R9161
4 1 R9157 Q907 20K5 1/8W 1%
Q9801 D9151,D9152 FB910 R9125 3K 1/8W PMBS3906
BEAD C932 C933 24K 1/8W
470pF 250V 470pF 250V 3 2 C9158
HS13 HS22 1 2 220N 50V
HEAT SINK HEAT SINK C9127
100NF 50V !
1
2
1
2
! !
+
C9128 C9159 R9158
Q9101,Q9102 D9153 4.7uF 50V 100NF 50V 5K1 +-5% 1/8W
R9160
2KOHM +-1% 1/8W
IC9103
AS431AZTR-E1
2008-03-14
91
LC-32SV21L&LC-42SV31L
[3] KEY SCHEMATIC DIAGRAM
SW016
4
CN016 SW022 SW021
1 Key 1 TACT SW FWRD H1.5MM TACT SW FWRD H1.5MM TACT SW FWRD H1.5MM
2 key 2
3
CONN C024
5
R022 R021
1K62 1/10W 1% 820R 1/10W 1%
SW018 SW017
腹ビ叫い R019
R016 R017 360R 1% R018
2.94K 1% 1K62 1/10W 1% 820R 1/10W 1%
92
LC-32SV21L&LC-42SV31L
[4] IR SCHEMATIC DIAGRAM
DV33SB
R001 R002
1KOHM +-5% 1/10W 220 OHM +-5% 1/10W
3
LED001
R G
GPTD1210RGC
4
R004 Q001
2.2KOHM +-5% 1/10W
BC847C
R008
NC/10K 1/10W 5%
Q002
R003
TP001
TP002
TP003
TP004
CN001
2.2KOHM +-5% 1/10W
BC847C
6
R007
DV33SB
1 NC/10K 1/10W 5%
1
1
1
1
2 RC6
LED_R
--------><------|
3
-------><-----|
4 DV33SB
5 LED_G
----><----|
R006
R005 100 OHM +-5% 1/10W
2.7KOHM +-5% 1/10W U001
7
C003 3
CONN 3P 1.25MM LOCK VS
--------><----|
100N 50V
1 OUT
----><----|
2 GND
KSM-603TM2M
C002 C001
NC/100P 50V
1U 10V
2008-03-14
93
LC-32SV21L&LC-42SV31L
CHAPTER 9. PARTS GUIDE
[1] SPARE PARTS LIST
MODEL: LC-32SV21L
94
LC-32SV21L&LC-42SV31L
MODEL: LC-42SV31L
2008-03-14
95
LC-32SV21L&LC-42SV31L
[2] CABINET PARTS
LC-32SV21L
96
LC-32SV21L&LC-42SV31L
2008-03-14
97
LC-32SV21L&LC-42SV31L
LC-42SV31L
98
LC-32SV21L&LC-42SV31L
[3] PACKING PARTS
LC-32SV21L
99
LC-32SV21L&LC-42SV31L
LC-42SV31L
100
LC-32SV21L&LC-42SV31L
SHARP
COPYRIGHT ○
c 2011 BY SHARP CORPORATION
SHARP CORPORATION
SHARP ELECTRONICS(Europe) GmbH
Sonnistraße 3, D-20097 Hamburg
2008-03-14
101