This document contains 10 multiple choice questions about surveying topics like chain surveying, plane tabling, angles, bearings, and accessories. The questions test knowledge of technical surveying terms and procedures. Some key points covered are that metallic tapes contain steel wires and varnished linen, the baseline is measured accurately in chain surveying, triangles with angles less than 30 degrees are considered ill-conditioned, and the trial and error method for solving three point problems in plane tabling is also known as Lehman's method.
This document contains 10 multiple choice questions about surveying topics like chain surveying, plane tabling, angles, bearings, and accessories. The questions test knowledge of technical surveying terms and procedures. Some key points covered are that metallic tapes contain steel wires and varnished linen, the baseline is measured accurately in chain surveying, triangles with angles less than 30 degrees are considered ill-conditioned, and the trial and error method for solving three point problems in plane tabling is also known as Lehman's method.
This document contains 10 multiple choice questions about surveying topics like chain surveying, plane tabling, angles, bearings, and accessories. The questions test knowledge of technical surveying terms and procedures. Some key points covered are that metallic tapes contain steel wires and varnished linen, the baseline is measured accurately in chain surveying, triangles with angles less than 30 degrees are considered ill-conditioned, and the trial and error method for solving three point problems in plane tabling is also known as Lehman's method.
Civil Engineering Surveying MCQ Questions and Answers Pdf
1. Metallic tapes are made with
a. Varnished linen b. Varnished line with steel wires c. Steel d. Invar Ans; B 2. The line to be measured accurately in a chain survey is a. Main line b. Base line c. Check line d. Detail line Ans: B 3. In chain survey a triangle with any angle less than ____ is considered as ill conditioned triangle. a. 25° b. 30° c. 35° d. 40° Ans: B 4. Which one of the following is not used in setting perpendicular a. Line ranges b. Cross staff c. Optical square d. Prism square Ans: A 5. The horizontal angle between the true meridian and magnetic meridian is known as a. Magnetic dip b. Declination c. Local attraction d. Magnetic bearing Ans: B 6. In whole circle bearing system, the back bearing of N 20 W line is a. 160° b. 200° c. 340° d. 20° Ans: A 7. Which one of the following is not an accessory of plane table? a. Plumbing fork b. Trough compass c. Telescopic alidade d. Prismatic compass Ans: D 8. Which one of the following is not a method of plane tabling? a. Orientation b. Radiation c. Intersection d. Resection Ans: A 9. Three point problem in plane tabling may be solved by a. Tracing paper method b. Graphical method c. Trial and error method d. All of the above Ans: D 10. Trial and error method of solving three point problems in plane tabling is also known as a. Tracing paper method b. Bessel’s method c. Lehman’s method d. All the above Ans; C
Pad. DR.D Y Patil Institute of Engineering, Management & Research Akurdi Pune Department of Civil Engineering S. E. (Civil) Unit Test Examination-I Set A Sub: Surveying