STR GON Ss
FOR OPERATING AND MAINTAINING
THE PORTABLE TYPEWRITER
HERM
MANUFACTURED AND GUARANTEED BY
PAILLARD LTD
YVERDON AND STE-CROIX (swiTZERLAND)
ESTABLISHED IN 1814THE SPACE BAR
d for spacing between words
SHIFT LOCK KEY
Whon writing consecutive capital letter or upper case characters, depress the shift
key. This wil lock the cartage nthe capital sposion To telecre the conte
ito the normal position, press left hond shift ey (3 oe
LEFT HAND SHIFT KEY
night hand shift key (2 ¥P a win tie tar or
MARGIN RELEASE KEY
At the finishing end of the line the carriage is locked automancally 7 spaces after
the bell has rung. {fis requited to waite beyond this point in ordef te knseh eg
ord ot “dopes the maria tleane Vay ance Gnd typing can be conned tothe
nd of the platen, The same key enabled also writing beyond the ish hand merges
without moving the margin stop (10) * i
RIBBON SPOOL COVER, left and right
For changing the ribbon, ft these covers by the narrow end,
WRITING ON DRAWN LINES
To write on drawn lines such as orders, ruled paper. etc, turn the left platen knob
wards you, holding the right platen knob firmly. This releases the platen clear of
{it can be turned to the exact line. To reset the platen make the
LINE SPACE LEVER
For waiting release the line space leve
Lift the arm of the lever to make it longer
To lock the lever when closing the carrying case, fold down the line space lever
arm, and close the lever towards the platen knob. Lock st i this position by push
{ng the. locking knob (8) backwards. Center the cartlage proceeding as’ shown
under 13,
drawing locking knob (8) towards you.
THE 2 LINE SPACINGS
Make sure fst that the loft hand platen knob (6) is well locked, For single spacing
face the locking knob (8) in iront of figure +1» and for double spacing place tte
[ont of figure «2» The required spacing 4s oblained automatically by returning the
triage with a linger af the left hand. Press the finger against the lino space lever
Suving the camiage as far as it will go to the right. For returning the carrioge to
the felt and for wiiting on drawn lines, see 16 and 6
LEFT HAND PAPER RELEASE LEVER
Ifthe pgper needs adjusting, pul this lever towards you. Hold the lever, edjust the
per. then, release lever (See also under 15).
MARGIN STOPS
the length of the writing line. Move the margin stops by pressing
on the Enob and sliding them to right of eft so that the red crow on
® with the mark on the papet plate you have chosen. Another
wyins ia to place the carriage in the position for writing the
OPENING OF CARRYING CASE
ber feet flat 0
‘enobs with your thumbs Lit
aaing st from the 2 hooks at the rea!
the desk Put your hen
ih
CLOSING OF CARRYING CASE
Knob (
a
fe centre (13) fold
aby te now ready for carrying.
CARE OF THE MACHINE
Kee
the
MACHINE NUMBER
The machine number is stamped behind the night hand si
uot
RIBBONS
ven by moving the cariage
seation regarding
cs porible, Alseo
is ured, move the cami
sor dust falling into mechanism
‘the extreme lett Th
his machineHERMES (uv
LINE SPACE LEVER
14
16.
18.
20
a
2
first he line, and sliding the left hand margin stop t
auiomatically. Then move the carriage to the position where '
finish, and slide the right hand margin stop to the left until st st
required to
s automaueally.
RAPID UNDERLINING AND DRAWING OF COLUMNS
Pata pe point throug the hole inthe line nda. move the camnage sideways
thon yholelinas cup be undetined quickly. To draw columas, put the pene point
Tiough the hole an the card grip, move the camage sideways when a horizontal
Ine il be Grawa. For varie! ines tom the platen knob
PAPER SUPPORT ARM
Botore writing put this support into vertical position,
CENTERING OF THE CARRIAGE
Before iting the ease on the machine move the carriage so that the red notch on
the margin fail registers with the carriage centre stop at the rear of the rail
LINE INDICATOR .
This indicates the base of the writing line and the small graduated scale on the
right hos lines corresponding with the centre of the characters (important for finding
exact writing position when making corrections, additions, etc
RIGHT HAND PAPER RELEASE LEVER
If the paper needs adjusting, pull this lever towards you. This will release the paper
table and hold it in this position until the lever is pushed back.
CARRIAGE RELEASE LEVER
Tass allows 1
movement of the carriage to left or right. Operate it with your index
finger by pressing your thumb again platen knob.
PAPER BAIL LEVER
Lilt paper bail by this lever when introducing the sheet, ot when making corrections
RIGHT HAND PLATEN KNOB
by means of this knob the platen can be turned and the camage moved to left or
right operated a: thown under 16, : “ _
MANUAL RIBBON REVERSE LEVER
Wheo the ond of th bon reached the ren i automatic
At winds om th lull spool onto the empty spool If for any
Pi
reverse the ribbon by hand, push one of the two hand reverse lever
yy reverted t0 that
on it is desired to
towards the
RIBBON SPOOL COVER
BACK SPACE KEY
It you wish to move the carnage backwards, depress this key ax many times es
RIGHT HAND SHIFT KEY
For w: apital
FoLulias capttal lottes or upper ease characters, hold down either this key or leftopENENG OF CARRYING CASE
mn the desk. Put your hands as sho
thumbs. Lit
the cove upwords ced
Herm
CLOSING OF CARRYING CASE
ioe or and presing it against plate
CARE OF THE MACHINE
Rel work iTnove the sither to thee
a into mechani
MACHINE NUMBER
pe machine 2 amped behind the right hand side of the carriage and con
: a He carriage to the extreme left This number should
rding this machine.
RIBBONS
: ce should be given to the original Hermes Bob
E Fon im ribbo ded itis fitted with eyelets at each
CHANGING THE RIBBON
ns of the
Ps on when one spool
: ribbon between th
dnd insert from behind
e te nt lock (2) may then be released
CLEANING THE TYPE
Use @ hard
use pins or other metallic instrumen
fall int the mechantne
CLEANING THE PLATEN
The platen must bo cleaned only with methylated spirt, Never use patio orb
which tend to destroy the rubber P
ominG
i i not advisable to oll the machine too frequently as this vends to collect dust
ad actually does nore horn than good: Never in any cutrumstonces ol the type
ban ord sogment Its well fo have your mectine cleane ve .
a year by one of our Hermes agent Pas Hermes Baby i trviced in ev