1. It is an important characteristic that influence the behavior of soil.
It is the ratio of the
weight/mass of water to the weight/mass of dry soil. a. Moisture Content b. Specific Gravity c. Unit Weight d. Organic content 2. It is defined as the lowest moisture content at which the soil will flow upon the application of a very small shearing force. It gives a certain measure of the shearing resistance of a soil when mixed with water. a. Plastic Limit b. Plasticity Index c. Liquid Limit d. Shrinkage Limit 3. Since cement accounts for more than half the cost of concrete, the role of concrete mix design is to come up with the largest amount of cement that will satisfy the required properties of the hardened state of concrete. a. True b. False c. Sometimes true. d. Sometimes false 4. ___________________. It is the process of selecting a part (sample), which will be used to judge the whole (lot). It shall be in accordance with the Standard Sampling Procedures to obtained a true representative of a lot and based on the minimum testing requirements as prescribe for the item of works. Materials Sampling 5. The Purpose of taking sample in the Laboratory SOURCE OF APPROVAL 6. The Purpose of taking sample in the Laboratory JOB CONTROL 7. The Purpose of taking sample in the Laboratory ACCEPTANCE 13-15. Sampling, testing and inspection requirements of pre-fabricated structure or component structure materials if IMPORTED. 16. AASHTO stands for _______________________________. AMERICAN ASSOCIATION OF STATE HIGHWAY and TRANSPORTATION OFFICIALS. 17. It is a documented proof of the quality of materials indicating it meets or it fails the desired properties as called for in the specification requirements of an approved contract. MATERIALS TESTING 18. The prescribed tests on the construction materials to be used in a project based on approved contract quantities. Minimum Testing Requirements 19. It is a document with complete and accurate information about a project and duly signed by authorized representatives for the submission of samples in a laboratory. SAMPLE CARD 20. Samples are taken on a day-to-day basis during production or use of material, and include samples of material from approved sources, production plants and at the project site. Job Control samples are taken by the user to insure adequate quality control. JOB CONTROL The following are some of the specified quantities in a certain project. Aggregates used are rounded for Item 311 and Angular for Item 405. Use CF=11 for Item 311 and CF=12 for Item 405. (35 POINTS)