You are on page 1of 1

Std – 6th 6 - th

– Sci/Comm
8th | 9th -10th ICSE, CBSE, GSEB & 11th,12thSubject – Math
Max Marks – 25 Practical Geometry Time – 60 mins

A. Fill in the blanks: (1 mark each)


1. If diameter of a circle is 18cm, the radius is ___________.
2. The longest chord of a circle is ____________.
3. If the radius of a circle is 5.5 cm, then the diameter of the circle is ____.
4. Instrument used to measure an angle is known as __________.
5. Number of lines that can be drawn from one point is ___________.

B. (2 mark each)
1. Draw a circle of radius 5.6cm.
2. Draw a line segment of length 5cm and construct its perpendicular bisector.
3. Draw a right angle and construct its bisector.
4. Given line segment AB=3cm & CD=4cm, construct a line segment XY equal to sum of AB &CD.
5. Draw a line segment AB. Produce it to AC so that AC = 3AB. Verify by measurement.
6. Use a ruler and a compass to draw the following angles:
(a) 30°
(b) 45°

C. (3 mark)
1. Draw any circle and mark points P, Q and R such that
a) P is on the circle
b) Q is in the interior of the circle.
c) R is in the exterior of the circle.

D. (5 mark)
1. Refer to the figure given below, answer the following.
i) Name any radius of the circle
ii) Name centre of the circle
ii) Name any segment of the circle
iv) Name one sector of the circle_
v) Name any point in the interior of the circle
vi) Name any exterior point of circle
vii) Name any point on the circle

RONAK PARMAR 2nd Floor, Above Ganesh Medical, Near Crossroads


9662987078 Restaurant, Aai Mata Circle, Parvat Patia - Surat

You might also like