You are on page 1of 14
FRICTION Problems based on block Friction on Horizontal Plane Q. LA block weighting 100 kN is placed on rough horizontal plane. A pull force of 40 kN is applied at an angle 30° on it. if the block is just on the point of moving, find the coefficient of friction. (Dee 2017) P=40kN Ans: [t= 0.433 Q. 2A block of weight 200 N rests on a horizontal surface. The co-efficient of friction between the block and the horizontal surface is 0.4, Find the frictional force acting on the block if s horizontal force of 40 N is applied to the block. (Dee 2009) | men | von ‘Ans; F = 40 N (Motion is not impending) Q. 3 Find force requires to pull block B as shown. Coefficient of friction between A & B is 0.3 and between B and floor is 0.25. Mass of A = 40 kg and B = 60 kg. (ee 2015) Ans: P= 331.1N Q.4 The mass of A is 23 kg and mass of B is 36 kg . The coefficient of friction are 0.4 between A and B and 0.2 between ground and block B. Assume smooth drum, Determine the maximum mass of M at impending motion. (May 2014) 7 Ans: M= 11.8 Q. 5 Three blocks A, B and C are placed as shown, Determine the masimurn value of P that ean 3¢ applied before any slipping takes place, (May 2008) Ans @P=32N ()P=35N — i)Pa ISSN Q. 6 Two idence Becks A and B are connected by ared and rest against vertical aed horizontal planes respectively as shown. Ifslding impends when Q = 45 Find eveticent of fection assuming itto be same at both wall and flor. (May 2008) Ans: t= 0416 Problems based on block Friction on Inclined Plane Q.1 A block of weight 800 N is acted upon by a horizontal fave Pas shown in figure. fhe coetTeiet of fition etveen the bloee and incline ae ps = 0.35 and y= 0.25, determine the value of P for impending motion up the plane. (Dee 2015) (Q.2 IF a horizontal fore of 1200 N is applied to block of 1000 N, then block willbe held in equilibrium cor slide down o move up? Take w= 03. (May 2018) ‘Aas: P= 7R04N w= 1000 Pe1200N, So Ans: P= 1200N > J061.1N. + The block shall move up the plane 0.3 A block of weight 1000 N is kept on «rough inclined surface Find out range of P for which the block will be in equlieium. (tay 2013) x eos 30° Q. 4 What should be the value of °0" So that the motion of block A impeads down the plane? The coefficient of ficton 4 forall surfaces is 1/3. Mass of block A = 40 kg, Mass of block B= 13.5 kg. 370.1

You might also like