Seite 1 von 5
IECEx Certificate
of Conformity
INTERNATIONAL ELECTROTECHNICAL COMMISSION
IEC Certification Scheme for Explosive Atmospheres
for rles and detais ofthe IECEx Seheme visit wwwiecex.com
Certificate No, IECEx PTB 06.0039U Issue No. 0
Status: Current
Date of issue: 2006-04-26 Page 4 of3
‘Applicant WAGO Kontakttechnik GmbH & Co. KG
Hansastate 27
32423 Minden
Germany
WAGO Modular PCB Terminal blocks and Terminal strips type 745-xxxx!
TAB XBXT en
Electical Apparatus and
Optenal accessory:
‘Type of Protection: Increased Safety
Marking: ExellorExe!
Tamb: -55 °C to #85 °C.
‘Approved for issue on behalf ofthe IECEX Dring. Uwe Klausmeyer
Centeation Body.
Pasion:
f Section "Flameproot Enclosure
‘Signature:
(or printed version)
ow 20-0. 2006
4. This certificate and schedule may only be reproduced in full
2. This certificate is not transferable and remains the property ofthe issuing body.
83. The Status and authentciy ofthis certiicata may be verted by visiting the Oficial IECEx Website
Ceniate ved by
Physikalisch-Technische
Soe a) PIB
serie raunechig
http://domino.iec.ch/iecex/iecexweb.nsf/UID/57702e78d4887c83¢125715e0049268e0.... 20.6.2006Seite 2 von §
IECEx Certificate
of Conformity
Certificate No. IECEx PTB 06.0390
Date of issue: 2006-04-26 Issue No. 0
Page 2013
Manufacturer: WAGO Kontakttechnik GmbH & Co. KG
Hansastrate 27
32423 Minden
Germany
Manufacturing location(s)
“This centiicat is issued 9s verficaton that a sampla(s), representative of production, was assessed and tested and
found to comply with the IEC Standard ist below and thatthe manufactures quality system, elaing tothe Ex products
‘covered by this certificate, was assessed and found to comply withthe IECEx Quaily system requirements. Ths
Cerificate is granted subject tothe conditions asset out in IECEx Scheme Rule, IECEx 02 and Operational Documents
‘3s amended,
STANDARDS:
‘The electrical apparatus and any acceptable variations to it specified inthe schedule of this certificate and the identified
‘documents, was found to comply with te following standards:
IEC 60079-0: 2004 Electrical apparatus for explosive gas atmospheres - Part 0: General requirements
Edition: 40
IEC 60078-7 : 2001 _Electical apparatus for explosive gas atmospheres - Part 7: Increased safety
Edition: 3
‘This Certfcate does not indicate compliance with electrical safety and performance requirements other than those
‘expressly included inthe Standarés listed above.
TEST & ASSESSMENT REPORTS:
‘A samples) of tho equipment listed has successfuly met the examination and test requirements as recorded in
‘Test Report
DEIPTBIEXTROB.0043/00
ually Assessment Report:
DEIPTBIOARDS.0003/00,
http://domino.iec.ch/iecex/iecexweb.nsf/UID/57702e78d4887¢83c125715c0049e68e70.... 20.6.2006Seite 3 von 5
IECEx Certificate
of Conformity
Certeate No. IECEx PTB 06.0039U
Date of sue 2006-04-26, Issue No; 0
Page 3063
Schedule
EQUIPMENT:
Equipment and systems covered by this certificate are as flows:
Description of equipment
‘The screwless modular PCB terminal blocks and termials strips type 745-x«x0/..-.. and 745-X8X7!..-..
consist of an insulation envelope (polyamide PA 6.6) and connection facilities with cage clamp. They serve to
‘connect copper conductors in terminal compartments designed to Increased Saftey “6”
Accessories as end cover plates and barters, partitions, bridging elements and retaining clips and brackets are
included. The terminais are mounted with pins on a board.
Technical data
[ive Bx TASKD Cer)
AB 80x) TAS ABU, T45X820 (4 2)
a apes mm 5am ore
ated nslaTon Wrage fev 20 wo
aed volage fev sav Ov
Fisted cuventwlo comb. pe per bar pra
Fisted curentwih comb: type jumper bar TA
Fisted cass section ae
the cross section for which he rated eurentis va
Fac fin. 608 mm bs Arm
frax connectable cess secton a
=" Tt
fips SxS, Baad SP)
7as.xB6ul = Gr?)
Prose,
Fated curentwih compe jumper bor Bra
lod eoss section ont
the cross section, or which the rated curentis vais)
Prax comoctatie cross sector Eon
[ie exe, TSB OY
Sel T4575 HBO (18m
epee fom fis rm
ats nslaTon Tag ov ov fsov
Fea otage ZOW zn Bev
Fted carcent wo comb-ype per bar Ta
http://domino.iec.ch/iecex/iecexweb.nsf/UID/57702e78d4887¢83¢125715¢0049e68e70,
20.6.2006Scite 4 von $
JRtos current wit comb-tyoe jumper bar ka
ated cross section fis mat
he cross secon or which the rated current i val)
apa brn OP abs eran
x, Connie Sans ecON lism
I T I
PE-Terinels
frvpe rE BOTT FEET SET.
aS-xB171. an84TI 45.0877
45.9820. 45.1887)
Prapecng eo Ene foe 2m
Papacy fin. 008 mn? is fin. 0.2 mn® be 6 mm? fin 0.2 mm? bie Tom
femme
Tx connec was Lara ant homme
ction
General
ind of cONRETE TSE ingle ond mul wie, rely svarded
iumber of wires per Gampiig pont
[ering tamperatue range
nation
1 Name ofthe serie
2. Cross section, pin spacing, jumper, spacer, PE, strips or blacks
see overview item-numbers in the annex
745-Oxo«: terminal strips with jumper but without spacer
745-booe: terminal strips with jumper and spacer
745-300: terminal strips without jumper but with spacer
745.x8x. terminal blocks
745x8x7: PE-terminal
3: Kind of fastening and colour ofthe insulation envelope
‘see overview iter-numbers in the annex
Notes for manufacturing and operation
‘The terminals shall be mounted in an enclosure that meets the requirements ofan approved type of protection as
specified in IEC 60079-0, section 1 or EC 6124-0.
When instaling the terminals in an enciosure designed to Increased Safety “e” type of protection as specifi in
IEC 6078-7, the clearance and creepage cstances shown in table 1 shall be duly considered. Ii accossones are used,
the instuctons for installation provided By the manufacturer shal be observed.
‘Annex: Overview item-numbers and accessories
CONDITIONS OF CERTIFICATION: NO
http://domino.iec.ch/iecex/iecexweb.nsf/UID/57702e7844887¢83c125715c0049e68e20.... 20.6.2006Seite 5 von 5
‘Annexe: Overview item numbers and accessories pat
http://domino .iec.ch/iecex/iecexweb.nsf/UID/57702e7844887¢83c125715c0049268e70.... 20.6.2006