Professional Documents
Culture Documents
SPECTRUS NX1104
1 Identification
Identification of substance or preparation
SPECTRUS NX1104
Company/Undertaking Identification
GE Betz, Inc.
4636 Somerton Road
Trevose, PA 19053
T 215 355-3300, F 215 953 5524
Emergency Telephone
(800) 877-1940
2 Hazard(s) identification
********************************************************************************
EMERGENCY OVERVIEW
DANGER
TARGET ORGANS:
Prolonged or repeated exposures may cause CNS depression, primary
irritant dermatitis, skin sensitization, tissue necrosis, and/or
toxicity to the liver and kidney.
SYMPTOMS OF EXPOSURE:
Inhalation of vapors/mists/aerosols may cause eye, nose, throat and
lung irritation. Skin contact may cause severe irritation or burns.
HAZARDOUS INGREDIENTS:
7732-18-5 WATER
4 First-aid measures
5 Fire-fighting measures
FIRE FIGHTING INSTRUCTIONS:
Fire fighters should wear positive pressure self-contained breathing
apparatus (full face-piece type).
EXTINGUISHING MEDIA:
dry chemical, carbon dioxide, foam or water
HAZARDOUS DECOMPOSITION PRODUCTS:
oxides of carbon and nitrogen, hydrogen chloride, ammonia and
volatile amines
FLASH POINT:
150F 66C P-M(CC)
MISCELLANEOUS:
Corrosive to skin, Combustible
UN 3265;Emergency Response Guide #153
2-PROPANOL
PEL (OSHA): 400 PPM
TLV (ACGIH): TWA = 200 PPM; STEL = 400 PPM; A4
ETHANOL
PEL (OSHA): 1000 PPM (1900 MG/M3)
TLV (ACGIH): STEL = 1,000 PPM; A3
MISC: NIOSH REL = 1000 PPM (1900 MG/M3); NIOSH IDLH = 3300 PPM
ENGINEERING CONTROLS:
Adequate ventilation to maintain air contaminants below exposure
limits.
PERSONAL PROTECTIVE EQUIPMENT:
Use protective equipment in accordance with 29CFR 1910 Subpart I
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA’S 29 CFR
1910.134 AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER
WORKPLACE CONDITIONS WARRANT A RESPIRATOR’S USE.
USE AIR PURIFYING RESPIRATORS WITHIN USE LIMITATIONS ASSOCIATED
WITH THE EQUIPMENT OR ELSE USE SUPPLIED AIR-RESPIRATORS.
If air-purifying respirator use is appropriate, use organic
vapor cartridges and any of the following particulate
respirators: N95, N99, N100, R95, R99, R100, P95, P99 or P100.
SKIN PROTECTION:
gauntlet-type rubber, butyl or neoprene gloves, chemical
resistant apron -- Wash off after each use. Replace as
necessary.
EYE PROTECTION:
splash proof chemical goggles, face shield
Odor Mild
Appearance Colorless To Yellow
Physical State Liquid
Flash Point P-M(CC) 150F 66C
pH As Is (approx.) 3.4
Evaporation Rate (Ether=1) < 1.00
Percent VOC: 4.3
11 Toxicological information
Oral LD50 RAT: >5000 mg/kg
NOTE - Calculated value according to GHS additivity formula
Dermal LD50 RABBIT: >5000 mg/kg
NOTE - Estimated value based on chemical structure consideration
12 Ecological information
AQUATIC TOXICOLOGY
Daphnia magna 48 Hour Static Renewal Bioassay
LC50= .16; No Effect Level= .1 mg/L
Fathead Minnow 96 Hour Static Renewal Bioassay
LC50= 2.9; No Effect Level= 1 mg/L
BIODEGRADATION
BOD-28 (mg/g): 24
BOD-5 (mg/g): 9
COD (mg/g): 482
TOC (mg/g): 103
13 Disposal considerations
14 Transport information
Transportation Hazard: Corrosive to skin, Combustible
DOT: CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S.(DODECYLGUANIDINE
HYDROCHLORIDE)
8, UN3265, PG II
DOT EMERGENCY RESPONSE GUIDE #: 153
Note: Some containers may be DOT exempt, please check BOL for
exact container classification
IATA: CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S.(DODCYLGUANIDINE
HYDROCHLORIDE)
8, UN 3265, PG II
IMDG: CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S.(DODECYLGUANIDINE
HYDROCHLORIDE)
8, UN3265, PG II, MARINE POLUTANT
15 Regulatory information
TSCA:
This is an EPA registered biocide and is exempt from TSCA
inventory requirements.
CERCLA AND/OR SARA REPORTABLE QUANTITY (RQ):
No regulated constituent present at OSHA thresholds
FIFRA REGISTRATION NUMBER:
3876- 145
FOOD AND DRUG ADMINISTRATION:
The ingredients in this product are approved by FDA under 21 CFR
176.300.
NSF Registered and/or meets USDA (according to 1998 Guidelines):
Registration number: 141061
Category Code(s):
G5 Cooling and retort water treatment products - all
food processing areas
G7 Boiler treatment products - all food processing
areas/nonfood contact
SARA SECTION 312 HAZARD CLASS:
Immediate(acute);Delayed(Chronic);Fire
SARA SECTION 302 CHEMICALS:
No regulated constituent present at OSHA thresholds
SARA SECTION 313 CHEMICALS:
No regulated constituent present at OSHA thresholds
16 Other information
HMIS vII CODE TRANSLATION
CHANGE LOG
EFFECTIVE
DATE REVISIONS TO SECTION: SUPERCEDES
--------- --------------------- ----------
MSDS status: 07-JUN-2000 ** NEW **
08-JUN-2000 07-JUN-2000
05-APR-2007 2 08-JUN-2000
01-MAY-2007 4,5,7,8,10,15 05-APR-2007
29-APR-2009 3,4,8,10 01-MAY-2007
24-JUN-2009 3,4,8,10 29-APR-2009
09-JUL-2009 8 24-JUN-2009
03-OCT-2011 11 09-JUL-2009
04-NOV-2011 14 03-OCT-2011