Professional Documents
Culture Documents
1.1 PLUGIN
The below instructions apply to the following ECUs:
ECU Brand ECU Model New Trasdata Plugin
CONTINENTAL-SIEMENS-VDO SIMOS18.1/2 0830
CONTINENTAL-SIEMENS-VDO SIMOS18.10 1073
https://ecu.design
SIEMENS SIMOS18.1_2_10 IROM TC1791 384 SSM VAG
https://ecu.design
SIEMENS SIMOS18.1_2_10 IROM TC1791 384 SSM VAG
It is necessary to use both the ANALOG PORT and the DIGITAL PORT of Trasdata.
https://ecu.design
SIEMENS SIMOS18.1_2_10 IROM TC1791 384 SSM VAG
The password will be automatically saved and used for the connection in open mode.
1.3 CONNECTIONS
ATTENTION
After making all the connections, connect a stabilized power supply to the New Trasdata and make sure
that the POWER LED (red) is on.
To communicate correctly with the control unit, it is necessary to use the F32GN037C/D cable.
https://ecu.design
SIEMENS SIMOS18.1_2_10 IROM TC1791 384 SSM VAG
Connect the BOOT and CNF1 pins to the grey and blue wires of the cable F32GN037C/D .
ATTENTION
For reading and writing operations, it is necessary to make the 3 LINK jumpers between the pads as
displayed in the picture here below.
Remove the LINK jumpers before reinstalling the ECU back into the vehicle.
https://ecu.design