Professional Documents
Culture Documents
Technical Information
TEGOSTAB® B 8734 LF 2
foam stability
cell regulation
emissions
Description Application
TEGOSTAB® B 8734 LF 2 is a silicone surfactant ▪ Typically used at 0.3 to 1.0 pphp (formulation
developed for predominantly MDI based HR and process conditions dependent)
molded foam (known also as cold cure foam). ▪ Recommended for predominantly MDI based
foams
Chemical description ▪ Also suitable as a co-surfactant for TDI or
TDI/MDI based foams
Preparation of organo-modified polysiloxanes
Processing advice
Key performance benefits
▪ Can be added in polyol/fully formulated system
▪ Open, easy to crush foam
or as a separate stream
▪ Excellent surface/subsurface
▪ Should be used at room temperature
▪ Wide processing latitude
▪ Low fogging and very low emissions according
Performance
to VDA 278
▪ Non-hydrolysable In this product, a moderate stabilizing effect is
▪ Phthalate free combined with specially pronounced structure-
regulating properties which lead to a wide pro-
cessing latitude.
Typical properties*
TEGOSTAB® B 8734 LF 2 especially regulates the
Appearance Colorless to yellowish clear liquid
critical zone of the foam structure which is close
Viscosity at 25 °C 40 mPa·s to the surface and an undesirably wide cell size
distribution is safely prevented.
Density at 25 °C 0.980 g/cm3
Thanks to this combination of features,
Calculated OH number 83 mg KOH/g
TEGOSTAB® B 8734 LF 2 is especially well suited
for formulations which are based on the reaction
Water content Max. 0.2 %
of highly reactive polyols (EO-capped) with various
Insoluble in water, soluble in MDI types or as a co-surfactant in TDI or TDI/MDI
Solubility
polyols foams.
MDI (32 % NCO) 57.60 <95> Please consult the Safety Data Sheet for summary
of product hazards, personal protective measures,
and emergency release procedures.
This information and any recommendations, technical or otherwise, are presented in good faith and believed to be correct as of the date Evonik Operations GmbH
prepared. Recipients of this information and recommendations must make their own determination as to its suitability for their purposes. Rellinghauser Straße 1-11
In no event shall Evonik assume liability for damages or losses of any kind or nature that result from the use of or reliance upon this 45128 Essen, Germany
information and recommendations. EVONIK EXPRESSLY DISCLAIMS ANY REPRESENTATIONS AND WARRANTIES OF ANY KIND, WHETHER Phone: +49 201 173 3006
EXPRESS OR IMPLIED, AS TO THE ACCURACY, COMPLETENESS, NON-INFRINGEMENT, MERCHANTABILITY AND/OR FITNESS FOR A Email: polyurethane@evonik.com
PARTICULAR PURPOSE (EVEN IF EVONIK IS AWARE OF SUCH PURPOSE) WITH RESPECT TO ANY INFORMATION AND RECOMMENDATIONS
PROVIDED. Reference to any trade names used by other companies is neither a recommendation nor an endorsement of the corresponding For any further information, contact either your
product, and does not imply that similar products could not be used. Evonik reserves the right to make any changes to the information regional sales or technical support or visit our
and/or recommendations at any time, without prior or subsequent notice. customer portal explorepu.evonik.com.