Slurry handling
Slurry valves
Metso slurry valves used in mineral processing applications are of the following
designs. Contact Metso application engineering for technical assistance in the
selection process.
Knife gate valves
These valves are suitable for most abrasive slurries
and the full-bore’ design with ‘shut-off'isolation
features offer bi-directional operational reliability.
Actuation by manual, pneumatic or other means is
possible,
In the open setting, the elastomeric seats seal
tightly against each other when the gate is fully
withdrawn out of the flow stream. Only the seats
are exposed to the slurry while providing a full
bore opening and no area for media build up.
During the closing action the seats are axially
separated and seal against the gate. Residue can
be discharged from the bottom of the valve at the
end of the cycle.
(ij
Open Open Closed
The table below lists sizes available and the pressure ratings.
DN 50- DN 600
Sy ae
rac
Fnge Mn ri pes
DN 50- DN 400 10 bar
Pressure rating DN 450 - DN 600 Sbar
ANSI 2" — 16" 150 psi
ANSI 18°- 24° 75 psi
Temperature rating and chemical resistance depend on the type of elastomer used.
Contact Metso application engineering for details.
BASICS IN MINERAL PROCESSING 8:37Slurry handling
Dart valves
Dart valves are used for flow shut off inside
sump tanks with vertical outlets. They are
suitable for applications handling abrasive
slurries, powders or granular substances, The
valve and seat are elastomer lined overall the
surfaces that come in contact with slurry. There
is no flow restriction in the open position.
The inside diameter of the seat is the same
as the Slurry Hose System offered by Metso.
Valves from DN100 — DN600 mm (4”-24")
sizes in DIN flanges are available. Pneumatic,
hydraulic or electrically operated actuators can
be used for regulating the dart valve.
Examples of Metso slurry hose and valve installations.
1. Metso 3xD Bend 90°
2. Branch Pipe K45
3. Knife Gate Valve
4, Rubber Lined Steel Pipe
5. Rubber Lined Steel Reducer
6. Sliding Support Clamp
7. Alu Coupling
8, Material Handling Hose
9. Flange Adaptor
10. Support Clamp
11. Trellex Gasket
1. Flange Adapter
2. Rubber Lined Steel Reducer
3. Branch Pipe T90 inlet water
4. Branch Pipe 790 drainage
5. Metso 3xD Bend
6, Metso Dart Valve Seat
7. Metso Dart Valve
1. Flange Adapter
ubber Lined Steel Reducer
3. Rubber Compensator
4. Branch Pipe T90 inlet water
5. Branch Pipe T90 drainage
6. Knife Gate Valve
8:38
BASICS IN MINERAL PROCESSINGSlurry handling
Sump tank with shut off valve
Shut off valve for slurry pump line with K45 branch pipe
Contact Metso application engineering for technical assistance in the
selection process.
BASICS IN MINERAL PROCESSING 8:39